2012 Ford Fiesta electrical problems

Filed Sep 10, 2024 · Electrical, Transmission · 12,000 miles · IL

The contact owns a 2012 Ford Fiesta. The contact stated while attempting to accelerate, the vehicle hesitated to move forward or backwards. Additionally, the contact stated that the ignition key had failed to operate as intended also. The vehicle was towed to the local dealer where it was diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was notified on the failure. The approximate failure mileage was 12,000.

Filed Dec 20, 2023 · Electrical, Visibility · 153,000 miles · NY

The contact owns a 2012 Ford Fiesta. The contact stated that while attempting to activate the headlights, the headlights failed to respond. The contact stated that several attempts were needed for the headlights to become operable. However, the failure reoccurred, and the low-beam headlights failed to function as needed. The contact checked the high-beam headlights and the high-beam headlights functioned properly. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to Customer Satisfaction Program Number: 19B22 - Corrosion due to road salts in the Battery Junction Box (Electrical System, Visibility). The failure mileage was approximately 153,000.

Filed Feb 9, 2023 · Electrical, Engine · PA

2012 ford fiesta check engine light on codes reading o2 sensors, catalytic intake, misfires, fuel injection, etc. I have had my fiesta at 3 mechanics all very known for there reliability all diagnosing it different issue recommending me to go to dealership which I was turned away because the recalls for the vehicle isn’t an issue for any of the possible diagnostics. Single mother of 3 now no vehicle, no money and no way of providing without transportation. Less than 150,000 Miles owned less than two years and the amount of money put into the vehicle ford should be ashamed. Shuddering and accelerating issue was told clutch and transmission issue but no help or actual known diagnosis since ford won’t diagnose the suspected diagnosis from any of the mechanics I have taken the vehicle to and they can’t for sure diagnose it until ford confirms the diagnosis since this is a known issue. They also sent me two recalls but refused to fix the recalls because I wasn’t 100% sure my vehicle needed the repair and threatened to charge me 150 diagnostic charge for the recall after I already poured my heart out to them about the issue I can’t seem to even get repaired due to there lack of care care as a manufacturer

Filed Jan 3, 2023 · Electrical · 160,000 miles · MO

The contact owns a 2012 Ford Fiesta. The contact stated while driving 70 MPH at night, the low-beam headlights stopped working. There was no warning light illuminated. The contact stated that he engaged in the high-beam headlights and continued driving. The contact, who is an electrician, diagnosed that the relay that controlled the low-beam headlights was corroded in the battery junction box. The dealer was notified of the failure and informed the contact that he had to pay out of pocket for the repair. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 19B22. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.

Filed Mar 22, 2022 · Electrical · 115,000 miles · MA

The contact owns a 2012 Ford Fiesta. The contact stated while driving approximately 55 MPH at night, the low-beam headlamps failed to operate as needed. The contact mentioned that the high beam was needed to be able to see the roadway correctly. The dealer was not contacted. The contact was a mechanic and diagnosed that there was corrosion on the junction box that caused the failure of the headlamps. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 115,000.

Filed Mar 4, 2022 · Electrical, Engine · RI

Transmission Malfunction, this is the 4th time that I am having to replace the transmission. I am taking the car back to dealership to get the transmission fixed for the 5th time. The car jerks when it comes to a stop. Hard time accelerating or does not accelerate. I put the car in R and it did not budge at all, even turned the car off and turned it back on same thing. This car should not be permitted on the road. Does not shift gears properly, the RPM run very high. I am afraid to drive this car constantly, even after I get it out of the shop because I just know that the transmission will eventually malfunction on me again. Very unsafe and unreliable to drive.

Filed Oct 6, 2021 · Electrical · GA

My engine light came on so I took it to Ford dealership and they told me it's the car computer not understanding when the engine is turned off and that it is not an urgent issue to keep driving it since they are backed up. A week later while driving the car just stopped the engine light started glitching. After 2 minutes it starts again. So I called Ford explained what happened they could check it a week later so I start calling around. Found Ford dealership that can check it immediately, then they told me that the issue is a wiring problem that Ford has sent them a bulletin about but it is not a recall. I told them that it should be a recall if Ford knew that a wiring issue can make your car just stop in the middle of traffic with no warning whatsoever. The issue on my invoice says EEC TEST CODES P2610 P2138, PIN POINT TEST, NEED TO PERFORM TSB 13-11-15 WIRE REPAIR BYPASS CONNECTOR C210 TO PCM, REPROGRAM PCM TO LATEST SOFTWARE. It is a safety issue if your car just stops working in the middle of traffic and Ford know but refuse to issue a recall for it.

Filed Aug 21, 2021 · Electrical · NJ

It started with a loud thud sound while driving. It was as if something hit or fell on the car. Scary loud sounds from the car used to happen randomly at anytime. I had to stop the car, get out and check what fell or hit the car but every time I checked there was no mark or scratch or sign of something hitting. Sounds were so sudden and loud that someone could easily be shocked and lose control of the car. After such repeated incidents of loud thumping sounds I thought that it was the speakers (part of cars standard audio system) that was making the sound. I thought that the problem can be temporarily solved by turning off the audio system. But it was not so. Car kept making disturbing noises even with the audio system turned off. Over time it got worse and more frequent. It scares kids and other co-passengers. Knowing how disturbingly and dangerously sudden these noises are I absolutely cannot lend my car to any family member or friend to drive on their own. They could lose control of the car harming themselves or others. Now it does long crackling, popping and thumping sounds even when the car itself is off ignition. I am holding the car keys, am outside the car, it makes crackling sounds on simply opening and shutting the doors of the car. Upon quick search of this problem on the internet I find that a LOT of people have reported having this problem - https://www.youtube.com/watch?v=WLx0WN23SD4. I along with lot of others who have reported this problem are surprised that there is not already a recall of this. There appears a related TSB but it doesn't list 2012 Ford Fiesta SE - https://www.tsbsearch.com/Ford/13-4-14. Please have Ford address this and save lives. Thank you

Filed Aug 1, 2021 · Electrical, Engine · AZ

While my 16 yr old twin sons were driving on freeway, a loud pop of pressure release from motor occured, and steam blew out from under hood obscurring their visibilty. they were able to pull over safely and call me. Upon arrival, after confirming they were ok, I checked under hood to see that the intake manifold had built up to much pressure for the PCV hose and the recirculating hose that connects to top of valve cover. Oil had sprayed out everywhere and car will not start. Ive lost compression in 2 cylinders now from the fast overheat. My childrens safety was severily compromised by this chain reaction of a failed PCV valve. Ive since found out of recalls.This is whats stated for my 2015 Ford Focus, but happened to my 2012 Ford Fiesta Oct 22,2018 Manufacturer Recall Number18S32 the federal safety agency Recall Number18V735 Recall StatusRecall Incomplete Summary ON YOUR VEHICLE, THE PCM SOFTWARE MAY NOT ADEQUATELY DETECT A STUCK-OPEN CANISTER PURGE VALVE (CPV) WITHIN THE FUEL VAPOR SYSTEM. IF THE CPV MALFUNCTIONS AND STICKS OPEN, IT CAN LEAD TO EXCESSIVE VACUUM IN THE FUEL VAPOR SYSTEM, POTENTIALLY DEFORMING THE PLASTIC FUEL TANK. THIS CAN CAUSE THE FOLLOWING SYMPTOMS: ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH CERTAIN DIAGNOSTIC TROUBLE CODES (DTCS) INACCURATE OR ERRATIC FUEL GAUGE INDICATION INACCURATE DISTANCE TO EMPTY (DTE) ENGINE STALL AND/OR OTHER DRIVABILITY CONCERNS RELATED TO STUCK OPEN CPV Safety Risk THIS MAY RESULT IN AN ENGINE STALL WHILE DRIVING WITHOUT WARNING OR WITHOUT THE ABILITY TO RESTART, AND CAN INCREASE THE RISK OF A CRASH. I now have 2 auto loans im upside down on for recalls that I cant even get my car to Ford because I cant afford the tow. I pay over $500 monthly for lemons.

Filed Jul 6, 2021 · Electrical · 160,000 miles · KY · fire

The contact owns a 2012 Ford Fiesta. The contact stated while driving at various speeds, the vehicle stalled. The contact stated that occasionally there was smoke coming from the engine compartment. The contact also stated that the vehicle would not restart. The contact stated no warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with the battery needing to be replaced. The vehicle was repaired but the failure still occurred. The contact then towed the vehicle to another independent mechanic where it was diagnosed with nothing needing to be replaced. The manufacturer had been informed of the failure and referred the contact to the federal safety agency. The failure mileage was approximately 160,000.