2009 Ford Flex brakes problems

Filed Jul 19, 2021 · Brakes · 160,000 miles · MI

The contact owns a 2009 Ford Flex. The contact stated that after refueling the vehicle, the odor of fuel was present coming from the vehicle. After parking inside the garage, there was fuel leaking from the seam of the fuel tank on the passenger’s side. The cause of the failure was not yet determined. Also, while attempting to stop the vehicle, the brake pedal would extend to the floor and the vehicle would not immediately stop. The contact determined that the brake booster was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and an unknown dealer were notified of the failure. The failure mileage was approximately 160,000.

Filed Feb 12, 2019 · Acceleration, Brakes · 160,000 miles · FL

Tl* the contact owns a 2009 ford flex. While driving 10 MPH and making a left turn, the contact depressed the accelerator pedal and the traction control and ABS engaged. The vehicle failed to accelerate and coasted off the road. When the driver resumed driving, a grinding noise occurred from the front driver's side of the vehicle. While driving home, the failure recurred numerous times. The vehicle was later taken to garber ford (3380 us-17, green cove springs, fl 32043, (904) 264-2442) to be diagnosed, but a failure code could not be located. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 160,000.

Filed Jul 30, 2018 · Airbags, Brakes · 50,150 miles · MO · crash · 1 injury

Exiting hwy at 50 MPH, hit brake. Hard brake pedal-no brakes followed by engine full throttle acceleration-vehicle was sent to the ford dealer in oct for a check eng light that couldn't be extinguished. Computer was reflashed with basic prom. No other issues until accident

Filed Apr 24, 2018 · Brakes · 20,000 miles · OH

Tl* the contact owns a 2009 ford flex. The contact stated that when the brake pedal was depressed, the pedal traveled to the floorboard numerous times. The dealer (ganley ford west, 16100 lorain ave, cleveland, oh 44111, (216) 941-9800) replaced the brake system four times. The dealer stated that there were internal failures with the front and rear brake system (anti-rotation pin, adjuster spring, spring seat, piston seals, slider frame, anti-rattle clips, slider pins, and caliper frame). The failure continued. The brakes had been replaced every 20,000 miles. The manufacturer was notified of the failure. There was no recall for the brakes. The manufacturer made a recommendation to have the dealer replace the parts again. The VIN was not available. The approximate failure mileage was 20,000.

Filed Mar 1, 2017 · Brakes, Steering · 136,000 miles · TX

While driving ford flex on highway or in town my antibrake system randomly activities causing my entire vehicle to stop. This has happened more than three times and I have complained to ford red mccombs dealership and they can't find nothing wrong. I was billed about 225.00 dollars for a antibrake switch and my car was not fixed. Yes, and I have complaint to ford dealership and made them aware of my continous brake problems with my ford flex vehicle.

Filed Aug 24, 2016 · Brakes, Transmission · 101,946 miles · CA

Tl* the contact owns a 2009 ford flex. While driving 35 MPH, the front of the vehicle began to vibrate. The vehicle was taken to an independent mechanic who diagnosed that the front axle had an indentation and the rear brake caliper had bolts that detached. As a result, the axle and caliper needed to be replaced. In addition, the technician stated that the torque converter and transmission seal were leaking oil and the drive line and torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failures. The failure mileage was 101,946. The VIN was unavailable.

Filed Aug 4, 2016 · Brakes, Driver assistance · 127,500 miles · MD

July 22, 2016. Wife started car in school parking lot and headed to the exit. While making a left hand turn onto the main road, and accelerating, loud noises again heard under the car and it lost power even while giving it gas. Had to pull over to the side of the road. Shut off car and re-started. No issues. Wife refuses to drive the car until fixed. Taken to dealer on july 29, 2016. Unable to duplicate. Returning to dealer aug 5 for computer re-flash. This is a significant safety issue that is being reported all over the ford flex forums and it appears ford motor company will not address the issue.

Filed Aug 4, 2016 · Brakes, Driver assistance · 127,000 miles · MD

Wife started car in school parking lot. Turned left and headed short distance the lot exit. While turning right onto the main road and starting to accelerate, heard 'load noises' that seemed to be under the car. Car started to slow down even though she was giving it gas. She pulled over and shut the car off. Didn't notice any dash lights (ABS or tcs). Restarted car and everything was fine. Car has 128,000 miles.

Filed Oct 30, 2014 · Brakes, Driver assistance · 48,000 miles · WA

While leaving a parking lot and accelerating to barely 10 MPH, the left front brakes seemed to lock up and the car stuttered. After stopping and accelerating again, the problem did not reoccur at that time. The second time, I was leaving my driveway, again going no more that 10 MPH and the same thing happened, this time I noticed my traction control light flashing. I put the car into reverse, backed up a bit thinking I'd run over something, and accelerated again. Nope, didn't run over anything, just traction control seizing up. Very concerned this may happen at higher speeds and cause an accident.

Filed Jun 18, 2014 · Brakes · 24,590 miles · NJ

My 2009 ford flex limited fwd has less than 50k miles and the rear rotors has been replaced twice. They rusted away, corrosive brake fluid causes rust. My dealer keeps saying that all flex vehicles have this problem.