2002 Ford Focus lights problems

Filed Jan 21, 2023 · Electrical, Lights · SC

I drive a 2002 Ford Focus Sedan. My engine light is on, warning light for trunk door ajar light is on (even though the trunk is securely locked, my front headlights due not work consistently (sometimes work, sometimes don't). My trunk does not always latch secure after I close it as well. I took my car to Advanced Auto Parts and had my engine light diagnosed. Engine codes that resulted were: B1318, B1881, C1947, B2438, B2434, P0457. The representative tested my battery and found that the voltage was slightly lower than it should be. My concern is for my safety as well as the safety of others. Do we have some manufacturer defects on this particular vehicle? Have other concerns which could be the result of vehicle wear and tear, or/and due to manufacturer defects as well. Inner tie rods need replaced as well as control arms/bushings, as reported to me by a mechanic. I have seen recall reports related to the 2002 Ford Focus in which there has been issues directly related to what I'm reporting, which is another reason I'm filing a report. Thank you. The contact wanted to add that the wipers are experiencing an electrical issue as well. When in use, the wipers cannot be switched off when it is at the highest position because it will not return in the downward position.

Filed Nov 18, 2016 · Lights · 64,000 miles · ID

Tail light connection melts due to bulb getting too hot. Impossible to remove connector to replace bulb. Have to replace entire lens. Many, many reports online of this happening. Ford denies and refuses to replace. Expensive remedies for customers. This happens on focus wagons and many other fords.

Filed Sep 9, 2013 · Electrical, Engine · 132,000 miles · OR

While waiting at a construction site the engine died and would not start (the engine indicator lit). The brake lights, power windows, and rear hatch release also failed to function. The vehicle was towed and the personal mechanic reported the electrical harness to the rear hatch had failed where is passed between the body and the hatch door. The harness electrical insulation was cracked on the entire bundle of wires and shedding fragments causing some wires to short, the 15 amp fuse for the brake lights had evidence of heating, but did not blow, rather, wires leading to the brake pedal sensor, the 15 amp fuse, and along the harness back to the short in the rear wiring harness near the center brake light had discolored and were melted in some segments. Ford customer service said to consult a ford service center to determine if there was a manufacturing defect. The ford service representative said he had seen this before and said it was not a manufacturing defect, rather it was a design defect that occurs after 10 years or more.

Filed Jun 9, 2010 · Electrical, Lights · 175,778 miles · PR · fire · 1 injury

Engine compartment fires on the driver's side in the area of the battery burning all the wires and the left headlight.

Filed Jan 25, 2009 · Lights, Locks · PA

Rear door wont latch right and driver side tail light wont work.

Filed Jul 2, 2008 · Lights · 74,000 miles · OR

Driver side tail light and brake light. The housing is shaped so that you can't take the lightbulb out w/o breaking it. I told them to do whatever to make it work can't afford $118.00 to replace a manuf defect part.

Filed Jan 29, 2007 · Lights, Transmission · 62,000 miles · IL

Clutch assembly has a leak of fluid into the interior of the car (down the clutch armature to the clutch pad and to floor mat, if significant leakage) which has a) caused the clutch pedal pad to become slippery and fall off due to the fluid seeping behind the pad [after market replacements not available due to relative youth of car, therefore necessitating service at dealer], b) causes the brake light to come on sporadically due to a drop in brake fluid (clutch hydraulics share a reservoir with brake system), although no finding of corresponding brake trouble can be made [problem temporarily disappears when fluid level topped off] and c) causes sporadic clutch "softening" and decreased effectiveness. Issue has been brought to the attention of both dealer and independent service providers several times, but none can find a fault with the braking system as indicated by the error light and therefore none indicate that a trouble exists. The leak is not obvious upon visual inspection of the braking system and the problem does not appear to have a negative impact on braking power (unless left too long and brake fluid levels drop significantly). Unable to locate precise location of leak (suspect either reservoir or some associated line to clutch hydraulics) or to determine why only clutch system appears to be impacted. 1) no noticeable/known events leading to failure; uncertain how long condition existed prior to initial documented problem 2) see failure and consequences noted above 3) no correction in place yet as dealer service does not yet acknowledge problem and did not "find" problem at recent 60k service work-up (included total systems check and full brake inspection with fluid top offs) problem with brake light firing manifest approximately every two weeks (since first noted in november 2006) due to fluid loss, particularly when temperature drops below 30 degrees fahrenheit. Issue is "resolved" by adding brake fluid to reservoir.

Filed May 28, 2006 · Lights · KY

A year ago, the driver's side turn signal light on my 2002 ford focus wagon burned out. In trying to replace it at a local auto parts place. The socket was so tight in the lens/reflector assembly that it could not be removed. I took it to my dealer, kain family ford in london. I learned that the problem was that the fitting for the socket had warped from excessive heat, apparently. The dealer searched to see if there was a technical bulletin and found one instance in which a pizza driver in a similar vehicle had a similar problem. They were able to pull the light out and with a pocket knife make the new socket fit in the assembly, and charged me the hourly rate for the work. I suspect this is a manufacturer's defect, because I've heard of two other instances in the same type of vehicle in this area with the same results. I recently replaced the passenger side headlamp and fount the same warping. I have yet to take it to my dealer, but will. Is there a way to search repair records for this vehicle to determine if this is a defect and should be recalled? I learned of this site from click and clack on npr's cartalk.

Filed Apr 25, 2005 · Lights · OH

The housing on the left rear tail light melted which was caused by the light bulb overheating. This caused the brake light to fail. Consumer informed other drivers that the vehicle was coming to stop, which could result in an accident.

Filed Mar 11, 2005 · Electrical, Fuel system · 2,000 miles · TX

My car stalled when driving anywher from 20 - 70mph. The gauges go haywire the light cut off and on , the clock resets, the speedometer goes crazy, and I have a young daughter that rides in this car. This started in october and is still going on to date. My car is still under warranty.