2004 Ford Focus suspension problems

Filed Nov 13, 2017 · Suspension · 151,239 miles · IL

The bottom of my subframe is completely rusted out. I called ford dealer and they told me it is because of the area I live in the vehicle has 151239 miles

Filed Mar 18, 2015 · Body, Suspension · 114,000 miles · NY

Tl* the contact owns a 2004 ford focus. While driving at various speeds, a rattling type noise was heard coming from the rear wheel area. While inspecting the vehicle, the contact discovered that the rear passenger shock absorber punctured through the wheel well. The vehicle was taken to an independent mechanic who discovered that the failure was due to rusting and corrosion of the wheel well. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 114,000.

Filed Nov 15, 2013 · Suspension · 110,000 miles · IA

Tl* the contact owns a 2004 ford focus. The contact stated that the vehicle experienced a flat tire. The contact called road side assistance and the spare tire was installed. The vehicle was later taken to an independent mechanic, who diagnosed that the adjustable upper arm kit would need to be installed in order to correct the chamber on the rear driver and passenger's sides. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 110,000.

Filed Apr 1, 2009 · Suspension · 19,000 miles · NJ

I was backing out of my driveway when the right front coil spring broke puncturing my tire. My car is currently at the dealership getting repairs. (estimated repair costs are $782.).

Filed Nov 30, 2007 · Brakes, Engine · 50,759 miles · CA

Tl*the contact owns a 2004 ford focus. While driving 55-70 MPH, the vehicle and the steering wheel both began to shake. When the speed is below 55 MPH, the shaking will stop or decrease. When applying the brakes while driving, the contact heard metal on metal from the rear of the vehicle on the driver's side. The dealer stated that the brakes were fine. The current mileage was 54,019 and failure mileage was 50,759. Updated 01/02/08 *bf the consumer stated the vehicle squeaked and vibrated and when the brakes were applied there was a grinding noise. The engine mount was replaced, due to it being broken. The shifter squeaked. The rims were bent and the tires were out of balance. Updated

Filed Jan 19, 2007 · Suspension · 82,000 miles · TN

Tl* - the contact has a 2004 ford focus se with a odometer reading of 82000 miles. The contact stated that he has a rear wheel alignment problem which has resulted in tire cupping and he has to replace the rear tires for a third time. The contact has taken the vehicle to the dealer and to an independent mechanic shop and they both told him that he as an alignment problem. Neither the mechanic shop nor the dealer know why this failure has recurred and have been able to offered a solution. *jb updated 03/19/07.

Filed Dec 15, 2006 · Acceleration, Body · TX

2004 focus belt tensioner broke and battery failed. *ts the front door had to be aligned and the door seal was replaced. The throttle cable had to be re-routed due to the cable binding. The front wheel bearings were replaced. The left rear motor assembly was replaced, the 3rd brake light lens and right side cv axle was replaced. The transmission started shifting erratically. The consumer attempted to make a turn, and the transmission would shift from 1st to 2nd gear until the engine revved up past 6000 RPM. The consumer was told there was a problem with the servo pistons. The transmission was eventually repaired. The battery failed 5 times.

Filed Aug 15, 2006 · Suspension · 60,000 miles · CA

Dt*: the contact stated while the vehicle was driven at an undisclosed freeway speed, the rear passenger tire became wobbly. The vehicle became hard to control, and was pulled over to the side of the road. The driver continued to drive on the side of the freeway to the residence. Once the vehicle was at the residence, the contact jacked up the vehicle and noticed a broken weld in the rear and the tire was being held on with the a-arm. The vehicle was towed the dealership, but was not inspected. The manufacturer was alerted.

Filed Jan 22, 2006 · Suspension · 10,000 miles · PA

Premature wear on inside front tires.

Filed Nov 18, 2005 · Brakes, Engine · 6,000 miles · NY

Brake problem. At about 2000 to 3000 miles breaks starts to squeal and grind. Took it in to service at dealer complaining about problem, as it got worse and was not normal in 6,000 miles. Was told no problem, routine break in. Then at 12,000 miles still a problem. Went to another dealer, said the same thing. Now with nearly 18,000 miles, rotors are grooved very bad. Evidence and warning was evident in the earlier miles as well. Ford has done nothing to help. I feel they owe me a new pair of rotors and pads. Also, complained of clutch noise problem. I have heard of a tsb claiming certain 2004 focus have a transaxle misalignment causing pre-mature clutch wear and noise. Wiper switch has been replaced by rc lacy ford, better service, but they won't service me anymore, since I did not buy it there, and ravena is so close. I need to contact crossroads about all future warranty issues and complaints. Doors in the rear also stick, and wear of door striker is evident. Tires have also been worn pretty bad pirelli 195/60 r15. Back pair are totally bald, and only have had like 18,000 miles, I think it was a alignment issue, which for a car 17 months old should not be an issue. I noticed wear at around 13,000 miles. During my second tire rotation. Have had too many problems with this new vehicle. Also issues with extreme chipping around the rear wheel well. Also have had a hesitation problem at about 25 MPH. #rd gear used to be difficult to engage. Please help me resolve these issues. I got nowhere with the dealers myself. The VIN is not the appropriate VIN. My car is a 2004 zx5 duratec 2.3e 5 spd. Almost all options included. Thank you.