2007 Ford Focus suspension problems

Filed Jun 15, 2022 · Lights, Suspension · OH

The contact stated that her mother-in-law owns a 2007 Ford Focus. The contact stated that while her mother-in-law was driving at an unknown speed, the front passenger’s side wheel detached from the vehicle. The vehicle was towed to the independent mechanic who diagnosed the failure as a control arm failure. The contact stated that the vehicle was repaired. The contact stated that 2 weeks later the driver’s side wheel detached. The vehicle was towed back to the independent mechanic who stated that the control arm had detached from the vehicle. The vehicle was repaired. The contact stated that 3 months later while stopped at a traffic light, the driver was unable to control the vehicle as the front passenger’s side wheel detached from the vehicle as well as the transmission slid into the engine. The transmission observation was by the tow truck company. The vehicle was towed to the owner's residence. The failure cause was not diagnosed by the dealer or an independent mechanic. The contact stated that the tow company informed her that the vehicle was unable to be towed on the flatbed due to the fact that the front end of the vehicle might detach. The contact stated that the headlights would also flicker on and off while driving. The contact stated that the independent mechanic replaced the light bulbs however, the failure continued. The manufacturer was not made aware of the failure. The failure mileage was unknown.

Filed Jun 14, 2021 · Suspension · IA

Noticed small hole in front control arm while servicing brakes. Stamped sheet metal control arm rusted through and was failing. Very poor designe that was discontinued for apparent reasons the following model year.

Filed Mar 27, 2017 · Suspension · 98,000 miles · MI

Tl* the contact owns a 2007 ford focus. While slowing down to 5 MPH to approach an intersection, the vehicle drove over a pothole. The contact lost control of the vehicle, but managed to apply the brakes to stop the vehicle. The control arm assembly was rusted and split in half, the plastic shroud was ripped, and the fender on the passenger side was pushed into the front passenger door, which made the door difficult to open and close. The vehicle was towed to a residential home where it was diagnosed. The independent mechanic determined that the lower control arm failed. The control arm failure was repaired by the independent mechanic. The contact did not notify the manufacturer of the failure. The failure mileage was approximately 98,000. ..updated 06/08/17 *bf

Filed Dec 24, 2015 · Airbags, Suspension · 155,000 miles · GA

Tl* the contact owns a 2007 ford focus. While driving over 50 MPH, the vehicle became unstable and was difficult to drive in a straight line. In addition, the air bag sensor and overdrive sensor lights suddenly illuminated while operating the vehicle. The cause of the failures were not diagnosed or repaired. The manufacturer was not notified of the failures. The failure mileage was 155,000. Updated 02/18/16

Filed Oct 15, 2015 · Suspension · 50,000 miles · IN

Tl* the contact owns a 2007 ford focus. The contact stated that while driving at approximately 10 MPH, there was a abnormal noise coming from the front and rear passenger side of the vehicle. The failure occurred multiple occasions. The vehicle was taken to an independent mechanic for diagnostic testing. The technician stated that they were receiving a vehicle structure error. The manufacturer was not notified of the failure. The failure mileage was 50,000.

Filed Jan 5, 2015 · Suspension · 45,000 miles · NM

While driving on snow for the first time with this vehicle, I experienced significant and extremely difficult to control fishtailing of the rear end. I have significant experience driving in the snow, the tires are in extremely good condition and the vehicle was checked prior to the trip. The problem is not with the tires or maintenance. The problem is with the design of the suspension. After the incident, a quick internet search reveals that this is a known problem with the ford focus of this vintage. It is beyond belief that ford is unaware of the problem. The vehicle is defective and unsafe. We were lucky to keep the vehicle under control and get off the road alive. Attempts to contact ford directly have proven unsuccessful.

Filed Oct 2, 2014 · Airbags, Body · 117,000 miles · VA · crash · 1 injury

Front left tire blew causing to loose control of the car it went off road and slammed into a ditch. Front bumper and quarter panel damage, front axle broke, rims dented, suspension needs to be replaced to name a few. Almost 5000.00 in damage. Person jerked forward enough to have cuts in the chest/shoulder by the seat belt yet the airbag did not deploy.

Filed Jul 9, 2014 · Engine, Fuel system · 10,000 miles · CA

Something in the car makes a squeaky noise air conditioner gave out.

Filed Apr 1, 2014 · Suspension, Tires · IL

I have a 2007 ford focus, I have replaced the rear tires 4 times since I bought the car. The mechanic said all focus eat rear tires. I have read several other reports of the same issue. Thanks ford.

Filed Aug 9, 2013 · Suspension, Wheels · 52,645 miles · CA

I noticed a vibration that seemed to increase over time of about 2 weeks. I took the vehicle into the dealer where they replaced a wheel bearing and recommended I replace the rear tires due to severe cupping. The tires are continental contacts with about 10,000 miles on them and should have lasted the next 5 years. I went to the tire shop where they told me that ford focuses are known to have alignment problems and will destroy their tires prematurely. Researching the internet I found 47 such complaints over the years relating exactly to what I experienced. The problem is the rear suspension is cambered in too much at the top and ford never made the suspension adjustable. Mine measured 1/4 inch difference between the top of the 15 inch rim compared to the bottom. This sits the car on the inside edge of the tire creating the premature wear. Ford must know this problem exists.