Trying to back out of my driveway, van will not go into reverse. Restart van, put it into reverse & it falters & stalls. Restart &got van into drive,but it will not accelerate until 3000 rpms, then jerks into drive & stalls again. Had it towed to a local mechanic I have used for over 20 yrs. Van shows no codes.replace battery, have throttle body cleaned, cam sensor is tested, shows not problems. Van starts & runs for one day. Same exact issue happens again. Have it towed a second time. Again, no codes come up.mechanic flushes out the tranny,& van runs again for 50 miles w/o incident. But again, trying to leave for work next day, van displays the exact same issues. No torque to move the van, constant stalling as soon as it is taken out of drive. Will not move at all or starts & moves very hesitantly into reverse, catches gear & jerks, stalls once again. Tow again to a ford dealer. Told the prob is the recalled torque converter. Have it replaced, and van doesn't make it the 12 miles home. The van lost complete power on a highway & I was almost hit by oncoming traffic. Tow back, now being told the transmission needs replacement, over $3,000 because metal from the recalled part has dislogged into tranny. I am now finding thru my own research that this is a common problem relating to the PCM, which replacing tranny doesn't solve the issues. Ford is offering no help or compensation am a single mom of 2 kids, 1 is disabled,& now been fired from my job because I can't get there 28 miles away. The van is stranded at the dealer, because I have no money to fix or tow again. I am at my wits end. Ford needs to step up to the plate &replace this van!!!! Repairing the torque converter, cam sensor, or transmission will not solve the PCM problem, which is not sealed properly, & after numerous repairs, will malfunction again> my q to ford is:does someone have to die for u to do something?
2005 Ford Freestar electrical complaints
Page 3 of 4: complaints 41 to 70 of 85, newest first, as owners wrote them.
Engine stays in third gear on highway ,windshield wiper fluid won't spray and power locks don't work with button on doors or key fob. Getting 11 miles a gallon because won't shift into fourth gear and that's a highway trip!
This information is a collection of incidents that ultimately fit together. I have notice that the floor board of my van was wet. Since I have 3 kids I just shrugged it off. This past week I notice the floor mats weren't wet only the carpet beneath it was soaked. My kids don't spill just under the mats. The water must be entering from the outside in. The van was acting weird on and off -no check engine light until it started happen more frequently. June 2012, I got the p1340 code that the camshaft position sensor had gone bad, I replaced it, went out again, I was told it could have been a faulty part, changed it again, went out again, decided this is beyond me. I took it to the dealership and they "fixed" the camshaft position sensor and another part that was causing the camshaft position sensor not to work. ($900) it broke again because the part they put in was defective. They replaced the defective part and the check engine light came back on again. After they had the car for 2 weeks they found another small problem. ($130) I insisted at the time that they didn't make the proper repairs. They assured me that it all still needed to be done. (caught some double talk) I experienced a few more issues with the van losing power. (july,september, october -check engine light did not turn on.) I:n december the car turned off and I was only able to get about 25ft per restart and the light came on. I've noticed other features not working properly or working intermittently. (power locks, power windows, radio, power doors, key remote ...) I have learned that other 2005 freestar owners have experienced similar incidents caused by water leaking into the car through the windshield wiper blades and running down the wire harness causing multiple parts to short out from time to time. Please look into this. I have 3 children and no more money for "let's try this repairs".
This vehicle has a continuing problem with the PCM shorting out due to water entering the wiring harness through the windshield wipers. Once the PCM short circuits the transmission does not function causing the car to loose its' motion. This occurs without warning and places the occupants of the vehicle at greater risk of being involved in an accident as the car simple ceases to work. The company has currently recalled this make and model to replace a defective torque converter. Although this seems to solve the problem initially, the long term problem of water seeping into the PCM will cause the transmission to fail time and time again.
Received recall for torque converter- had it replaced on aug 20, 2012. On nov. 19th the van wouldn't go pass 20 MPH. Drove slow approx. 3 miles to destination. Had it towed to dealership to check out problem at initial contact was told they knew of no problems relating to torque converter replacement. After checking van out was told that we needed a new transmission, at second contact was told they were aware of torque recall issues but nothing would be done for us. We had not had any problems with transmission prior to nov 19th. When asked, was also told that they did not flush and replace fluids with the torque converter recall service as this extra cost was not part of the recall. We were told by an independent mechanic that if fluids were not changed that it could cause the transmission to fail which it did. Was quoted a high cost to replace transmission, ended up using disabled vehicle as a trade 'as is' to purchase a working vehicle. Other issues with vehicle prior to last incident were electrical functions not working, sliding doors would reopen upon closing, had to turn off auto doors, backup warning quit working, traction control button didn't work, dvd player would start running on its own.
Was driving the vehicle going down the highway at 60mph and the vehicle started to act up pulled over and it shut down completely security light started to flash real rapidly turned the key to start it again and nothing had to have it towed 300.00 worth and has been broke down for four months been trying to start it ever since and nothing there is defiantly something wrong with the electrical system.
Having a similar problem to others with my 2005 ford freestar. Water getting into PCM and causing problems. Took vehicle to dealership for torque converter recall and they noticed water in the PCM. They dried it out and vehicle ran fine for two weeks. Had significant rain last night and problem happened again. This is an obvious flaw in this vehicle and needs to be fixed.
I was driving my minivan back to work from lunch. It cut off as I took a turn. I stopped the vehicle and restarted it. As I began to go again, it cut off again. I pulled over and restarted the vehicle. I was right outside my work parking lot so I pulled in and parked. I called egan automotives because they are located right beside my work. During my break I drove it to their place of business. My minivan check engine light was on and it was acting sluggish. I left the vehicle with them overnight. Egan automotive called me and told me that there was moisture getting into the computer box. They said that ford knew about this problem and were selling a kit that will insulate the computer box. I called ford and they won't help even though the placement of the computer box under the wiper blade vents was there brilliant idea. Looking online this seems like a pretty common problem, yet ford won't recognize it and fix it. This is going to cost me $300, which I feel I'm not responsible for. A vehicle cutting out while driving is a safety hazard. Can you help get this resolved?
I have had the car stop after and during rainy days. Most recently the car would not start or move during a heavy rain. I have had to wait days until the car dries out for the car to move. Have taken it to the shop after several instances of this same occurrence. They can not find out what is wrong as the car runs ok? After researching on the internet I have come to the conclusion that it is water leaking on and into the PCM causing the car to not start or move. Ford dealership has not been able to solve the problem or have a solution?
Add-on info for complaint #10472027. The date stated for the problem with the PCM was merely an arbitrary start date for our problems, which was required to proceed with the complaint. We have had continual problems for at least near 2 years with the vehicle, but no mechanic (including ford's) has been able to accurately confirm the basis of such issues. Our assessment of a damaged PCM is based on research of on-line complaints from other freestar owners which seem to almost perfectly match our situation, as well as the fact that our mechanic had to remove water from the computer compartment. Currently, we are in search of a replacement computer, but they are almost impossible to find.
2005 ford freestar PCM problems. Symptoms include intermittent incidences including vehicle's failure to start, running rough, improperly accelerating, refusing to move forward/backward, and other random problems. The fuel system components/camshaft sensor/etc, as well as the transmission have been replaced on the vehicle, but all of these issues still exist. Codes do not show up on mechanic's diagnostic computers unless the car is actively having the problem, which seems to rarely happen. Mechanics, including the local ford dealership, has not been able to confirm the problem with the PCM; however, our mechanic did find water in the computer module. He dried it out and resealed it, in hopes of resolving the issues we were having. The problems have continued though and despite lack of codes, all indications are that the computer is no longer good. Another problem is the fact that getting a replacement PCM is nearly impossible. The demand for freestar reconditioned computers is so high that we've not been able to find one to replace the bad unit in the van. (apparently, new PCM's are not available at all.) after seeing the massive number of on-line complaints which are so similar to ours, I cannot believe that ford shut the case regarding the computer problem. If the diagnosis of failed PCM's is almost impossible to achieve, ford simply chooses to ignore the obvious. (read all of the complaints on the federal safety agency.dot.gov.) poor placement of the PCM on the back of the vehicle wall has allowed water to run off of the windshield into the unit, but ford will not take ownership in this problem. How many people have to risk having a wreck and possibly dying due to water-damaged components? It is unfortunate and unnecessary. One last question... Is it possible that the transmission problems (currently on recall) be related to the water-damaged PCM's?
Was stalled out several times during the month of january and february of this year. It would just stop responding. It acted much like a transmission going out, but that was not the problem. After multiple towes and trips to the mechanic to attempt getting this vehicle repaired, it was determined that the PCM had gotten water inside and had to be replaced. I spent several thousand dollars trying to get this vehicle to run as well as it had before. Once the PCM issue was discovered, it did run much better, but by this time I had lost my faith in the vehicle. I cannot believe that ford positioned a computer component where water would run down onto it, and they have not been forced to fix this issue. As a result of all of my problems with this vehicle, after many years of being a ford owner, I sold this van and purchased a chrysler town & country.
I was driving 45 MPH in a heavy rain when my vehicle began to sputter and check engine light began flashing. I started to pull over, but light went off and engine ran fine. After several days of rain engine would hesitate in acceleration and would feel like it was missing. It began only occasionally and usually when traveling up hill. It progressively got worse, especially after rain or being washed. Investigated and found this to be a common problem with this model with the power control module getting wet. Today while driving on the interstate check engine light began flashing and engine hesitated, then check engine light stayed on. Very dangerous situation to feel like my van was going to stall at 70 MPH with my family in the car.
After driving in or after a hard rain, the engine light comes on and the engine runs very rough and often stops. Has happened while driving on highway at 55mph. Cowl was removed at dealership to prevent water intrusion in oct2010, but same problem started happening again in 2012...
I was driving my freestar home, pulling into my complex when the battery light came on, then a second later the brake light, then all the power to the van was lost. I had no control, the entire electrical system went out, the engine shut off, I had to rub the van up against the curb to stop it. When I got it going again and parked in my parking spot the battery light came on again and I lost all power again. The next day I replaced the battery as I was told it could be a battery issue, but even with the new battery the light was still on. I had the alternator and the battery cables checked and it was fine. Then I was told it maybe the PCM which is a known issue with this model and what I experienced is the identified issue...this is very serious as I was bring home my family home and we just got off the highway like 5-10 minutes before this thing shut down on me, if this was the highway we could have been seriously hurt. Plus now I can't even drive because the part is not available, it's on back order, so this must mean a lot of people are having this issue. We need to have a recall on this before people get hurt or killed, especially when it's a known issue http://nhthqnwws111.odi.the federal safety agency.dot.gov/acms/docservlet/artemis/public/pursuits/2009/dp/insl-dp09004-35644p.pdf !!!!!
Was on a very busy highway. The freestars dash lights lite up and went back off. Ac cut off then everything started working again. About 30 seconds later the freestar died at 65. I was able to coast to a stop on the shoulder. Again on may 5 2012 the lights started flickering and the AC started to blow hard and it would slow back down then the dash lights ABS,brake,battery lights would blink on and off then the freestar died again at 70 MPH. Brakes didn't work I was going through a intersection and had to use the e brake. Freestar has done this several times over the last month I just hit the high spots. It has had test after test and I'm always told a different story! I just want my van fixed before someone gets hurt or killed.
When driving down the road the van will suddenly lose all forward momentum and drift momentarily until it will just as suddenly resume forward momentum and continue like normal. When this happens, the rpms drop off like the vehicle is stalling or fuel starved (however it has no hesitation like its running out of gas) no warning lights come on and there is no pattern to when or how it happens. However, the problem has been getting progressively worse and now it is noticed that it has a higher tendency to do it when it is raining or there is high humidity. It does it at all speeds from 25mph to 70mph. Ford dealership has looked at the van and could not get it to reproduce the problem when they had it. However, they stated this does not sound like a torque converter problem addressed under safety recall notice 11s25/ the federal safety agency recall 12v‑006. This is a very dangerous problem and has almost caused several accidents as I have no warning the problem is getting ready to happen and have no way to notify other motorist of my sudden and quick deceleration.
On september 21, 2011 I noticed that my 2005 ford freestar was hesitating when I pulled out of a parking spot in front of my home. I was able to get to my final destination, a local supermarket, without incident but could tell that the car was not shifting gears as smoothly as I was accustomed to. On the return trip home, upon merging onto the expressway I typically take, my freestar's engine began to sputter then immediately shut down. All power to the engine was lost. Power steering was lost as well making the car impossible to maneuver. The electrical system completely shut down and I was forced to come to a complete stop, shift into park and reengage the ignition. From that point on, until I arrived home, the freestar would not shift beyond second gear. If I made an attempt to accelerate, again the engine would sputter and all power to the engine, power steering and electrical systems would shut down completely. I managed to get home that day by stopping and restarting my freestar what I can only estimate to be 50 to 75 times. The most harrowing part of this experience was the lost of power and control without warning. Prior to this day, I had never experienced anything remotely like this with the freestar, and then from one day to the next, I was helpless on the expressway expecting a fatal collision with an unsuspecting driver.
Was driving around 30mph then the RPM's went up to 5000 let off gas RPM slowley went down..2nd time it happened took it in they said it was a sensor "fixed" it...the 3rd time was going threw an intersection died on me in middle of intersection almost got smashed by oncoming traffic with my kids in the van...had it towed they could not find anything wrong....4th or 5th time was going to work got of highway rpms went up to 5000 and the van wont go no wheres now...no reverse no drive just sits there sounding like [xxx]they way ford made it...now waiting on them to tell me whats wrong with it.... Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
This vehicle has died on me numerous times while driving down the freeway or around town driving. It has been very scary and a miracle we weren't killed. The first time it happened in 2006. The ford dealer had no idea what it was, finally discovered it was happening in cold weather, moist air or rain. The PCM was getting wet. They put foam and sealed with an adhesive. It started again in 2008 had to be resealed. It has started again in 2011 and 2012 it is very scary and you never know when you will lose power. It is very expensive to have fixed. Ford knows this was a bad design. They are waiting for someone to get killed and be sued before they will take responsibility for this problem. My van is now parked, while I try to get the money together to have it sealed again. Hemborg ford doesn't even offer a discount for the repair. They are not concerned at all that the vehicle dies while you are traveling down the freeway. This van has had numerous recalls, it should have had one for the PCM but so far it has not. I guess they are waiting for someone to die. Online there is a lot of complaints on this same issue from people from all over the united states.
Pcm failure moisture gets into PCM because of design flaw and causes electrical shorts and vehicle jerks and cuts out. Loses power.
Van started acting like the key was being turned off and on. Misfire was so bad that van was like riding a bucking bronco. Pulled to the side several times as I thought we would not make it home. Got home from sunday diner and took to local dealer the next day on 6/20/11. Installed 1f1z 6b288 ba sensor. Back to dealer on 6/28/11. Installed 164r4901 foam strip along with sealant. Back to dealer on 7/5/11. Installed. Installed xl3z 9f472 aa sensor. To independant repair shop on 12/2/11. Installed yfiz-7h103aa sensor. Back to same repair shop. Installed 5f2z12a650 bc PCM module. That seemed to resolve the problem as van is running better than for the last 2 years.
After a rain storm my van experiences problems with the power control module. The transmission will not operate correctly. This is the third time this has taken place and always associated with a rain storm. This time the engine will not start.
Pcm (power train control module) has gotten wet and causes car to not drive. Lose power. Not start. Lunge, lurch forward. Won't engage in drive or reverse. I have replaced PCM 6 times. Broke down 5 times. Had van towed 5 times. Left van at repair shop for months at a time to diagnose problem. Finally moved the PCM to the inside of van so that it won't be effected by water. Ford has refused to acknowledge problem despite a tsb being issued. Furthermore, I replaced the transmission and a recall has been issued but ford will not review my receipts for the transmission until letters go out. Total stonewalling by ford.
9/2007 my husband, myself, and our 5 children were driving to my mothers house and out of the blue the van just stopped accelerating. We had the van towed to the dealership that we bought it. They told us that we needed a new transmission at 41,000 miles (just out of warranty) $2000 oop!! We had the trans replaced and are now 12/2011 having the same issue again. (just over 90,00 miles) we owe 2000$ on the van and the cost of repairs are over that. This has to be a safety issue..children in car + car randomly stopping!! I just don't understand how a van bought new off the lot can be on its 3rd transmission on less then 100,000 miles. We will never buy a ford again and after doing a lot of research I have found 1000"s of owners with the same issues...its a shame ford will continue to allow customers to pay for their faulty products!
Drove to the store that day. We have been having a lot of rain. When done at the store got in the van and it started fine but when you pressed on the gas pedal the RPM would race up but the van would go no where. The ford dealership replaced the PCM sensor because it had water in it. It was running but not like before. Took back the van on 4/21/11. Engine runs fine. Driving down the road and van started sputtering like it was choking. Stopped the van and shut off the engine, turned it back on and it ran fine. Two days later had the same problem but I was at a stop sign and the van did not want to move forward. My husband barely got it to the dealership, it just completely died on him once. Once the dealership had it they said they couldn't find anything. Just had a speed sensor changed on it on 11/15/11 they had the van for 8 days trying to figure out what is wrong. Now just tonight, when you put the van in any gear the rpms drop and the shifting is delayed. I am guessing something is wrong with transmission. How can I ever trust the ford company again? I have been reading too many of the same problems. We are going to take the van tomorrow to see what is wrong with it again?! Help!!! I also read I need to call ford for them to have some many complaints for a recall is this true?
This van has a bad computer board (PCM) due to rainwater that is allowed to funnel under the hood due to poor design of the hood. It is also possible that the transmission is being affected by this as well. The vehicle just stopped shifting into gear, followed by all sorts of electrical problems. The mechanic said the PCM was full of water and would need to be replaced. There are numerous message boards on the internet discussing this exact same problem with ford freestars ranging from 2004-2007 model years. Ford needs to issue a recall on these vans as this causes the engine to stall and this could happen at any time - in the middle of a busy intersection, on the highway, etc. This could have devastating results if it happens at the wrong time. Also, from what I've read on these message boards - this is a repeat problem!!!! Once you fix this you will have the same problem in a year or two. The federal safety agency should do some research outside of formal complaints filed as I'm sure most people do not know the proper route to go. A simple internet search (that would allow you to contact or respond to individual reports) would direct you to hundreds of people with the exact same issue!
Numerous problems with this vehicle. Transmission went out, replaced it and still having original problem. After exiting highway and coming to complete stop, transmission will whine out in 1st gear, will not shift unless you stop accelerating. Alarm system went off and would not stop, lights would not shut off unless you disconnect the battery. Consistent problems with drivers side ventilation system (heat blowing cold, air blowing hot). Airbag warning light on. Pass warranty, to tired to keep putting money into this vehicle.
Moisture damage to powertrain control module (computer system). Vehicle would not idle, transmission would not shift, and erratic electronics resulting in multiple warning lights to go on and off. Fortunately, I was in a parking lot, however, this could have resulted in catastrophic failure if I was driving on an interstate. Repair shop stated that they have seen this same problem. I have to have a new computer installed and the vehicle is only 6 years old.
My 2005 ford freestar has stop driving.it starts but when I shift into gears the car does nothing. It won't drive or go in reverse. I had a mechanic look at it and they said water got into the PCM. And would cost about $1200 to fix.I have notice many other 2005 ford freestars with the same problem. Many have repaired the problem out of pocket because ford won't pay for the problem.we didn't design the vechile so why is it we have to pay for the problem.I was lucky that I was pulling into my house when my car cut off.but many other stories with the same water on the PCM problem have been on highways or busy streets when their car dies so is ford waiting for someone or a group of people to die in order to recall this problem and take resposibility and repair it so the consumer don't have to pay with thier money or thier lives.I swear had I known that ford has ignored serious lifethreating problem like the water on the PCM or transmission problem I would have never gotten a van from ford or any vehicle from them. Ford clearly stands for found on road dead and soon its not going to be just the vehicle but someone life as well if they drive a ford.and ford doesn't give a crap.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Ford Freestar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history