2005 Ford Freestar fuel system problems

Filed Jun 20, 2020 · Engine, Fuel system · 14,900 miles · TX

3 weeks ago my family and I was almost killed by a semi-truck on the highway our vehicle just gave out in the middle of the highway I then started doing research on my vehicle I then reported the vehicle to the safety vehicle complaint and was contacted by a staffing took my vehicle to the said place in el paso tx case ford my vehicle has been detained for over 2weeks the gentle men [xxx] a worker of casa ford has been very rude and reluctant to actually service my vehicle he said the vehicle wouldn't fail at some point it finally failed I also just purchased a new battery I just bought a week prior to the accident and [xxx] said the battery I had was no good which is not true and charged me 200 for a new battery I feel that casa ford is not trying to resolve the issue with my vehicle I'm disabled and my children as well the said he doesn't know what is wrong that it may be the transmission but something is broken and not showing up what can our family legally do we have no vehicle 7000 down the drain pl information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Jun 21, 2017 · Electrical, Engine · DE

2005 ford freestar. Consumer writes in regards to unsatisfactory customer service at dealership and unresolved vehicle problems. *smd consumer sent additional correspondence. *smd the consumer stated the check engine light remained on after multiple repairs were made. The vehicle would also stall. The torque converter went out and the vehicle had to be towed. The vehicle was traded in. *js

Filed Dec 1, 2015 · Fuel system · 132,000 miles · NC

I had just turned onto mebane street when the car just stopped dead. I steered it off of the road, put it in park and exited the vehicle. I waited a while and tried to start it again. It started and then sputtered and died. I called a tow truck and the driver tried to start it and it did the same thing for him. He stated it was either the fuel pump or fuel filter.

Filed Oct 20, 2015 · Fuel system · 190,000 miles · WV

Tl* the contact owns a 2005 ford freestar. While fueling up the vehicle, the fuel tank overflowed. The contact stated that there was something clogging the tank. The vehicle stalled and was able to be restarted. The failure occurred on multiple occasions. The vehicle was driven to an independent mechanic for diagnostic testing. The technician was unable to find a failure. The manufacturer was not notified of the failure. The failure mileage was 190,000. Updated 02/23/16

Filed Apr 22, 2015 · Fuel system · 120,000 miles · AR

Tl* the contact owns a 2005 ford freestar. While refueling the vehicle, fuel ejected out of the vehicle. The vehicle was taken to an independent mechanic. The vehicle was not diagnosed or repaired. The failure recurred on numerous occasions. The manufacturer was not notified of the failure. The failure mileage was 120,000.

Filed Jan 2, 2015 · Electrical, Fuel system · 16,953 miles · PA

On christmas eve 2014 I got into my recently purchased 2005 ford freestar minivan to run a short errand. After starting my freestar I put it in reverse but the vehicle would not move. I tried all the forward gears with the same result, the vehicle would not move. The engine RPM's would go up but no movement. I turned the vehicle engine off and on several time with the same results each time. I had to wait till the day after christmas to contact my local ford dealership service department and describe my problem. They looked up my VIN number and said that all recalls on my vehicle had been done including the torque converter recall. I then had my freestar towed to the dealership to investigate the problem. Upon investigation it was determined that water had gotten into my powertrain control module, and that is what was causing the problem. They removed the module and dried it and the connector out then reinstalled it and sealed it. After reinstalling the module they then started the vehicle and were able to shift the vehicle into all the gears and get the transmission to fully function, but now there was a service engine light on. The vehicle now would not idle properly and had a hesitation when trying to accelerate. It was determined after further checks that there were fuel codes coming up and that they were related to the PCM getting wet. It was determined that the powertrain control module (which ford no longer manufactures) would need to be replaced. To fix the problem it would be a cost of $1000.00 for a re-manufactured module and reprogramming in addition to the $650.00 that had already been incurred for the work that had been done so far. Note there had been no problems or issues or engine codes on this vehicle till this problem occurred other than a problem one night with the power door locks not working, which corrected itself after restarting the vehicle.

Filed Jun 23, 2014 · Electrical, Fuel system · 134,343 miles · NY

I would like to report the failure of a company and a van. I recently purchased a 2005 ford freestar for my family of five that has been the worst decision of my life. A month after I experienced what too many other owner have also experienced. Water in the PCM, this almost resulted in a crash and injury to me and my family. Stalling out without warning at any speed. This known issue has gone on too long without any response from ford company. I am not a believer in someone has to die for there to be change. Also don't appreciate the cost of this job over $1000. I was fortunate to not be on the highway and crash. Although then we might get our money back. This has also LED to other issues that has become a chain reaction of failure. I will keep my receipt for as long as I have to.

Filed Mar 27, 2013 · Engine, Fuel system · 157,000 miles · WA

Driving down the road in heavy traffic, without warning suddenly had no power, at 40mph, put it in neutral and restarted only to die again 3 more times. I thought I was out of gas but the gage said 1/8th of a tank. Pulled off the road and had friends bring gas. Started up fine and drove maybe a block when it started sputtering and bucking. The check engine idiot light came on so I pulled over again. I reset the battery connection and light went off. I pulled off to drive around in the parking lot and it died when I cranked the wheel turning every corner. Started again, this time it was hard to turn over, and it sputtered and the transaxle idiot light started flashing, the radio came on by itself and the eve player ejected. Interior lights were on but switch was turned off. Checked the tranny fluid, it looked a little low in the dark(midnight) so put in half a quart. Light went out but the van refused to go forward. I dropped it manually into 1st and it slowly moved. Parked it and tried other gears, all unresponsive but when shifting into neutral the engine jumped and the rpms revved up to 3000!! Afraid it would jump into gear and run over my friend, I cut off the ignition while in neutral. I waited until midnight for no traffic, then drove the van home, keeping the emergency flashers on. Was able to travel about 25 feet per restart, each time the van would die when speed exceeded 15mph or 2000rpms. Took an hour to get the 1.5 miles home. This van had just gotten a full service oil change/lube/filter service and I had the transmission serviced at sears upon purchasing it just 6 months ago and had no other issues at all. Upon researching, this is a known issue that ford published but refuses to fix/recall. There is a recall on my van's torque converter, this is a serious safety issue and a major defect that will get someone killed or serious injured.

Filed Mar 1, 2013 · Fuel system · 90,000 miles · OH

Faulty fuel system vent causes gasoline to spray out when filling up. Additionally a hissing sound is heard when opening the gas cap, indicating that the gas tank pressure is high during normal operation. Severe fire hazard; leaked gasoline may cause fire and/or explosion. There are several similar complaints for this model vehicle listed in the federal safety agency database, so it needs to be investigated. The issue is likely to have been happening before listed time and mileage; observed almost immediately after I received vehicle from previous owner.

Filed Apr 2, 2012 · Acceleration, Engine · 127,305 miles · AR

I just received a safety recall notice 11s25 / the federal safety agency recall 12v‑006 everytime I drive my van it does not seem to want to accelerate or maintain speed. I have taken it to the mechanic and I was told that I needed to have a new egr valve put on, so I did. That did not fix the problem and I was told new spark plugs and wires so I had them replace, that did not fix the problem. Then I was told that I may need a new fuel filter, so I had it replaced and once again that did not solve the problem. This is the only vehicle I have and I am a single mom to two young children. I am worried that while I am driving I will lose all power and will be hit by another vehicle. My van never wants to go over 40 MPH and once it does reach that speed it will not maintain and sometimes makes an odd noise. I pulled onto the by-pass the other day and my van would not accelerate right away... Thank god that the truck behind me was able to pass me on the shoulder. There have been a couple other times when my van would not gain speed and I would have to pull over so that the vehicles behind me could pass. So in a nut shell the problems are as listed: 1.) van will not accelerate or maintain speed 2.) when I press on the gas pedal there is often a pinging / knocking sound I just want to know what I need to do to get this problem fixed and not be out any more money. Please help!