2005 Ford Freestyle body problems

Filed Dec 9, 2025 · Body, Electrical · PA

When temperature get below freezing car doors will not latch shut and come back open. Car doors work fine when temp are higher. There is a recall already for this the federal safety agency# 06v383000 Ford# 06545. I have a Ford Case# XXX My car was not included in recall and either should be or needs to be further investigated. I don't want my kids falling out while I go down the highway and I can't wait 45 min for the car to warm up. This had done this all last winter and is doing it again and Ford refuses to do anything. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 21, 2025 · Body · CT

Passanger door latch- door opened while driving, will not stay closed checked said recall was repaired in 2006, latch in not closing

Filed Aug 23, 2024 · Body · 170,000 miles · MD

The contact owns a 2005 Ford Freestyle. The contact stated that the vehicle was taken to an independent mechanic for routine maintenance however, the contact was informed that the motor mount torque strap needed to be replaced. The contact had not taken the vehicle to a local dealer to be diagnosed or repaired. The contact stated that the motor mounts had been replaced four times. The vehicle was repaired. The contact stated there was no warning light illuminated. The manufacturer was informed of the failure. The failure mileage was approximately 170,000.

Filed Jan 30, 2019 · Body · 75,000 miles · KY

Car doors will not relatch in freezing temps. The car was stationary but was unsafe to drive after the car door was initially opened. If I drive to work and the temp drops it will be unsafe to drive. I see that this model was recalled for this reason but my VIN was not. Obviously should have been. The dealership applied a lubricant (at my expense) but that did not work.

Filed Jan 23, 2019 · Body · 160,000 miles · OH

Door latches freeze open in cold weather as described in the federal safety agency campaign id 06v383000. The doors have failed to latch when entering the car as well as in motion at 50mph. A search of the cars VIN shows no open recalls however the car has not been serviced for this issue but clearly falls under the recall. Recall noticed was never received for this issue. This is a one owner car purchase and registered in ohio so it is unclear why it would not be covered by this recall. Ford has also stated that this car is not covered by the recall. This is extremely dangerous as the issue can occur when the car is in motion.

Filed Nov 23, 2018 · Body · MA

Anytime the weather drops below 40 degrees, which it most often does during the winter months in ma, my door locks freeze. It could be right when I start the car or while I'm driving, it's very sporadic. I can open the doors, but they will not close again, which is clearly very dangerous if you're driving and the door latches don't hold because of ice. It seems almost every other car that is my year, make and model have been recalled for the same problem, but for some reason mine has not! Not sure what to do, it's my only transportation. Throw my kuds in & just hope for the best while we're out driving?

Filed Dec 24, 2017 · Body, Suspension · 101,000 miles · OH

During safety inspection, front engine subframe rusted beyond repair where steering gear is attached. Dick masheter ford in columbus ohio provided diagnosis when performing other repairs. Replacement frame is unavailable from ford directly; the only alternatives are getting a used subframe or having a new piece of steel welded in. Vehicle was stationary at the time of inspection.

Filed Dec 15, 2017 · Body · MA

My front driver side door does not shut in cold weather. The locks stick on, and the door bounces back open when I try to shut the door. I paid to have the door locks replaced, a few years ago. The issue still happened on almost every cold day. Around 15f to 32f. The ford dealer who replacement the locks, got new locks covered under the lock warranty, but this issue still happens. It has been an ongoing problem for 4 years. I am forced to drive with a driver side door that does not close. I have to hold the door closed with my hand until the door locks decide to unstick and I can close the door. The ford dealer cannot get this problem solved or fixed even after 4 years and many many many trips back to the dealer with this issue.

Filed Oct 11, 2017 · Body · 52,000 miles · ME

Tl* the contact owns a 2005 ford freestyle. The contact took the vehicle in for a state safety inspection and the inspector noticed that the subframe was rusted. The inspector stated that the vehicle was unsafe to drive. The contact mentioned that two or three years before, rust was discovered during another state safety inspection. The vehicle was taken to an independent mechanic who performed welding work to the subframe. The vehicle was not taken to a dealer for diagnostic testing or repairs. Prime ford saco (857 portland rd, saco, me 04072 (207) 282-0300) stated that there were no recalls for the rust failure. Since the vehicle was out of warranty, the dealer offered no further assistance. The manufacturer was not notified of the failure. The failure mileage was approximately 52,000. The VIN was unavailable. *bf updated 7/26/18

Filed Mar 31, 2017 · Body, Steering · 194,000 miles · TN · 1 injury

Tl* the contact owns a 2005 ford freestyle. The contact stated that the driver side door failed to remain open while the contact entered the vehicle. The door struck the contact in the head. In addition, the power steering became difficult to maneuver. The vehicle was not diagnosed or repaired. The contact received medical attention to the frontal lobe of her head and sustained a contusion. The manufacturer was not made aware of the failure. The failure mileage was approximately 194,000. The VIN was not available.