2005 Ford Freestyle technical service bulletins
43 technical service bulletins and manufacturer communications cover the 2005 Ford Freestyle.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Motorcraft® Continuously Variable Chain-Type Transmission Fluid (XT-7-QCFT in non-Canadian markets,...
- The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic...
- Ford: momentary engine idle RPM surge may be intermittent and may occur, due to deposits buildup in...
- Ford mercury service campaign: certain 2005 through 2007 FWD and AWD ford five hundred, freestyle and...
- Rear brake drag, noise, dust, and/or premature pad wear
- MIL on with DTC P0191 - fuel rail pressure sensor circuit performance
- MIL with DTC P0106 and/or P0109
- Transmission shifter binding / high effort bezel replacement
- Premature shoulder (TOE) wear on inside edge of the front tires
- Fuel gauge erratic/inaccurate and/or MIL on with DTC P0463, B1202, B2627, B2879, and/or P2068
- Intermittent instrument cluster operation - including gauges sweep/reset - multiple warning lights...
- Battery light illuminated
- Tenths digit not displayed on odometer after 10,000 miles/kilometers
- Intermittent bounce-back of the driver's window during one touch up operation
- Noise in right front of passenger compartment - air inlet door actuator inoperative (recirculation)
- Grunt or squeak from front suspension during full lock turns - service tip
- Heated seats inoperative
- Oil leak from power transfer unit
- Second row seat recline concern
- Intermittent instrument cluster gauge sweep/reset - multiple warning lights on - reverse lights on -...
- Continuously variable transaxle (CVT) noise diagnosis
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Intermittent speed control deactivation and/or speed control will not set
- Engine RPM fluctuation at highway cruising speeds - vehicles built prior to 8/2/2005
- Squeak/clunk noise from rear lower control arm - vehicles built 7/12/2004 through 9/21/2004
- Intermittent headlamp flicker with no key in the ignition - vehicles built before 2/21/2005
- Thumping noise or roughness from rear brakes
- Engine service procedures
- Squeak from rear of vehicle when driving over bumps
- Incorrect compass information in owners guide and work shop manual
- Memory seat, adjustable pedals and mirrors operation concerns
- Memory seat, mirrors and pedals operation
- Vehicle may exhibit an oil life xx% message inthe odometer message center display prior to the vehicle...
- Weld bonding procedure
- Driveability concerns during deceleration
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair
- General (PCM) power train control module programming procedures
- Audio unit backlight inoperative and or DTC B2477
- Oil leak from power transfer unit
- Wrench light on, no engagement in drive or reverse and diagnostic trouble code P0942
- Wrench light on, diagnostic trouble code P0562 and transaxle in limp home mode after battery jump start
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Ford Freestyle?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history