Electronic Throttle Body Car lost power on busy, construction road Manufacturer issued secret warranty to owners and did not send out notice Multiple certified mechanics have inspected the vehicle Check engine, ABS, service advance trac, and power train lights were on and i am uncertain when they first came on
2010 Ford Fusion acceleration problems
793 complaints (15% of all complaints for this car). Typical mileage when it fails: 53,000. 21 crashes reported.
- owner complaints
- 793
- of this car's complaints
- 15%
- typical mileage
- 53,000
- crashes
- 21
- recalls
- 0
Which part fails
- Accelerator pedal3
- Throttle2
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Ford Fusion acceleration problems in other years
Specific symptoms reported on the 2010 Ford Fusion acceleration
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
No recalls on record for this model year.
Related investigations
Floor mat interference with accelerator
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.the federal safety agency testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
EA12009
Accel Pedal Interference - Acc Floormat
Unsecured mats may interfere with accelerator pedal return to idle. A heel blocker in the floor pan provides a platform that may lift an unsecured mat into contact with the pedal. Ford introduced new pedals as a running change early in model year (MY) 2010 vehicles. Analysis of complaints received by ODI and Ford show elevated rates of pedal entrapment incidents in MY 2008 through early 2010 production vehicles. Incidents typically occur following hard pedal applications to pass slower traffic or when merging into faster traffic. Drivers allege continued high engine power after releasing the accelerator pedal and difficulty braking, including reports that the incident was controlled by shifting to neutral or turning the engine off. Drivers and service technicians reference observing evidence of mat interference or note unsecured Ford or aftermarket all weather floor mats in post-incident inspections.Based on information gathered during the Preliminary Evaluation the population being investigated has been narrowed to model years 2008 to 2010.This investigation has been upgraded to an engineering analysis on MY 2008 through early-2010 vehicles (produced through September 2009) to further assess the scope, frequency and safety consequences of the alleged defect.The VOQs associated with the opening of this Engineering Analysis are: 10479693, 10415911, 10379562, 10372674, 10345830, 10342572, 10339330, 10335336, 10334211, 10332233, 10331160, 10329659, 10327597, 10320011, 10232027, 10214131
PE10019
What 2010 Ford Fusion owners say
Most recent owner complaints, unedited.
Electronic throttle body failure My car lost power going 50 mph in road construction The car had a recall and extended warranty on it from 2014-2024, i was not notified Check engine light, drive shaft light, and service advance trac appeared a few weeks before the failure
The Anti-Lock Brake System (ABS) malfunctioned causing the brakes to give out while I was driving the vehicle. Luckily I was on a residential street and I was able to safely pull over, but it could have caused a major accident had it not happened in that location. After taking it to two auto-shops, both concluded that it was a problem with the ABS system. There is an open recall for the 2010 Ford Fusion for the same exact issue (Recall number: 19S54), however it does not cover the Hybrid model, even though it is the same exact issue. In order to stop the vehicle, I need to press down on the brake pedal very very hard and use the emergency brake. It is not safe to drive, and it is a substantial and costly problem with the vehicle to repair. I would like my car to be part of that recall program, or at least be able to be recalled for this issue in which there is already an open recall, except not for my specific variety of the 2010 Ford Fusion. I have had to get my car towed several times in order to transport it, as again, it is not safe to drive!
While driving, the throttle body valve malfunctioned, causing the vehicle to rapidly lose power and go into an engine "safe mode." The check engine light appeared on the dash. I was luckily able to pull over to the side of the road. Restarting the vehicle cleared the error, but the issue continued to recur until I was able to get home. Luckily the sudden loss of power did not cause an incident, but as it occurred on the highway, a sudden drop in speed could have posed a safety risk, especially if it had occurred in inclement weather. There was a recall for the specific part that failed, but due to my model being a hybrid, it was not included even though it contained the exact faulty component. Speaking with Ford Customer Care confirmed this to be the case that my specific car was not included in the recall. I was able to order the replacement part myself and perform the repair. The error message that was thrown in the car's OBD system was: P2112 "Throttle Actuator Control System - Stuck Closed" The code was not saved in the module so it could only be read at the time the issue was actively occurring before the vehicle was turned off.
The contact owns a 2010 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle went into Limp Mode and stalled with the check engine warning light illuminated. The contact was able to restart the vehicle. The vehicle was taken to the dealer where the contact was informed that the vehicle could not be properly diagnosed until the warning light was illuminated while diagnosing the vehicle. Additionally, the contact stated that he received a recall notice on the electronic throttle body and was concerned that while driving the vehicle would stall again. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 123,000.
While driving my 2010 Ford Fusion, on five separate occasions (two times less than a week apart) and over the last five months, while stopping for traffic lights, traffic or pedestrians the brake pedal travelled just inches from the floor and extra effort was needed in attempt to activate the brakes hoping to come to a complete stop. On two jarring instances collision was avoided only by swerving the vehicle to keep from hitting a wayward pedestrian and the other instance was with another vehicle backing out in a mall shopping center. On all five occasions there was an associated amber ABS light on the dash, a sudden drop in brake pressure and severely degraded to no braking power during application. The brake fluid reservoir is appropriately filled with the manufacturer specified DOT 3 brake fluid and there are no leaks in the system whatsoever. I’ve been told at the Ford dealership that my vehicle will not be able to be inspected or seen by appointment for a little over 2 months (late Oct 2022). I’ve contacted Ford’s customer service at 1‑866‑436‑7332 and they stated that my VIN# is not included in the recall: 19S54. It’s apparent that my vehicle is experiencing all of the identical issues which prompted the Ford recall 19S54. Please assist so the Ford Fusion community can resolve this issue before another catastrophic event occurs.
The contact owns a 2010 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and would not accelerate more than 40 mph. The accelerator pedal would go to the floorboard when depressed however, the vehicle would not accelerate. The contact was able to restart the vehicle as the failure occurred intermittently. The contact had a code reader reading with the failure code P112 - throttle actuator body control stuck closed. The dealer was made aware of the failure and informed the contact that he needed to pay for replacement of the throttle body and calibration. The vehicle was not diagnosed by the dealer nor repaired. The manufacturer was made aware of the failure and informed the contact that there were no recalls relating to the failure. The failure mileage was 144,866.
Engine light, advance trac light, ABS light, battery light, tire pressure monitoring system light, alarm light suddenly came on. Then dash went completely blank. Headlights went out,lost control of vehicle at high speed. Dash lights came back on stirring control of vehicle lost. All dash lights started flashing. Breaking system not working.
On december 1st I was driving my ford fusion 2 the actual ford dealership to get a look at their field service action that they had posted on my ford app. While on my way I was stopped at a light on columbia drive in portland oregon and I had thought my foot slipped off the brake initially but actually would happen if my car had accelerated and to the gentleman in front of me causing a car accident. My insurance company would have nothing to do with it I tried to contact ford the dealership that I normally go to to see if they could repair the front-end of my ford fusion that was demolished and also no airbags went off as I had just got my car out of the shop at ford for a recall on the airbags my fiance was with me so there was definitely cause for concern fortunately nobody was hurt but like I said my car was demolished on the right passenger side front end I couldn't figure out why my car accelerating on its own so looking into it the explanation that I came up with was definitely the electronic throttle body motor and all I want is my car returned back to its prior condition I have no other vehicle I don't know who to contact I did contact ford and was referred to a bigger ford company if someone could help that would be amazing I'd appreciate it... Also no warnings or sensors went off in my vehicle I do have the sel package and once again no airbags were deployed and for the amount of damage that was done I was very surprised
Tl* the contact owns a 2010 ford fusion. The contact stated that while her son was driving at various speeds, the vehicle loss motive power, sputtered, and stalled without warning. The vehicle was taken to town and country ford located at 7800 e. Lloyd expy, evansville, in 47715, to be diagnosed. The contact was informed that the throttle body was defective and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but offered no assistance. The failure mileage was 68,000.
Questions about the 2010 Ford Fusion acceleration
Does the 2010 Ford Fusion have acceleration problems?
Owners have filed 793 complaints about the acceleration of the 2010 Ford Fusion, 15% of all its complaints.
At what mileage do 2010 Ford Fusion acceleration problems start?
The typical (median) mileage in owner complaints is 53,000 miles.
Was there a recall on the 2010 Ford Fusion acceleration?
There is no recall for this problem on this model year.
What year does the Ford Fusion have the most acceleration problems?
The Ford Fusion model years with the most acceleration complaints are 2010 (793 complaints), 2011 (256 complaints) and 2012 (86 complaints).
Other 2010 Ford Fusion problems
Steering 1,662Transmission 894Engine 793Fuel system 705Airbags 591Brakes 548Electrical 324Driver assistance 167Wheels 143Body 87Seats 34Suspension 34Visibility 25Locks 19Tires 18Lights 13Seat belts 9
VIN decoder
See the problems and recalls for an exact car
Buying a used 2010 Ford Fusion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history