The contact owns a 2014 Ford Fusion. The contact stated that the "Engine Coolant Overtemperature" message had flashed on the instrument panel while driving at an unknown speed. The contact added coolant to the coolant reservoir because the coolant level was low. Two days later, the vehicle started to jerk and hesitate upon the depression of the accelerator pedal with the check engine warning light illuminated. The vehicle was taken to the dealer where it was discovered that coolant had saturated the entire engine which resulted in engine failure. Upon investigation, the contact discovered the federal safety agency Campaign Number: 17V209000 (Engine and Engine Cooling) which was linked to the failure. The manufacturer was notified of the failure and the contact was informed that there were no recalls on the vehicle related to the engine. The vehicle remained in the possession of the dealer. The failure mileage was approximately 162,000.
2014 Ford Fusion engine complaints
Page 3 of 9: complaints 41 to 70 of 231, newest first, as owners wrote them.
I own a 2014 Ford Fusion. While driving at a slow speed, the "Engine Coolant Overtemperature" warning light illuminated. The vehicle was taken to a dealer where the water pump, thermostat, a/c hoses was replaced; however, several days later while driving 65 MPH, the "Engine Coolant Overtemperature" warning light illuminated, and the vehicle stalled. Due to the failure, the vehicle has been towed back twice to the dealer where the mechanic discovered a coolant intrusion into an engine cylinder. The mechanic informed me that the engine needed to be replaced. The vehicle was not repaired. The failure mileage 69k
The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the oil pressure warning light illuminated, and the vehicle lost motive power. There was smoke coming from the exhaust pipe, and upon inspection, the exhaust pipe was wet. The contact checked the engine oil level and added water to the coolant reservoir. The vehicle was restarted and was driven to the residence. The failure recurred, and the vehicle coasted into the driveway. The vehicle was diagnosed by an independent mechanic at the residence, and it was determined there was a blown head gasket and coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 209,000.
The contact owns a 2014 Ford Fusion. The contact stated that while driving at a slow speed, the "Engine Coolant Overtemperature" warning light illuminated. The vehicle was taken to a dealer where the water pump was replaced; however, several days later while driving 65 MPH, the "Engine Coolant Overtemperature" warning light illuminated, and the vehicle stalled. Due to the failure, the vehicle was towed back to the dealer where the mechanic discovered a coolant intrusion into an engine cylinder. The mechanic informed the contact that the engine needed to be replaced. The manufacturer was notified of the failure and a case was filed. The contact was then referred to the federal safety agency Hotline for assistance. The vehicle was not repaired. The failure mileage was unknown.
In January 2024, while driving the Ford Fusion, I lost power (when I pressed the gas, it would accelerate). I pulled over the best I could (on a 2 lane road, no shoulder, at night). I found that my vehicle had no coolant; it had an oil change within the last 2 months and all fluids were topped off. It was towed to my mechanic and I had to call family for a ride. It was found that the coolant had leaked and burned out, thereby overheating, warping the block/head (placing it in limp mode). It was not holding compression or fluid. For a new engine and installation, I paid $6,800.67. Tonight ([XXX]) my "check manual" wrench light came on and I pulled over to find the coolant was near empty. I was an hour away from home, at night, with my younger brother in the car, in Reno, NV. It was scary waiting for my family to drive an hour to come get me. I paid $97 to have it towed (insurance paid $500). It is now awaiting a second inspection. I just bought this car in 2023 from CarMax with only 55k miles. Now I cannot get to work or college if someone will not borrow me a car and will be forced to walk (not to work, it's 30 miles away). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine light came on and coolant temp started to go up and down. Made it home, and started it before worm, started emitting white smoke and had it towed to a dealer. Was told by Ford there was coolant intrusion into cylinder 3 and 4. Was informed this was a common problem by the dealership.
The contact owns a 2014 Ford Fusion. The contact stated that while the vehicle was parked, he noticed fluid leaking onto the ground. The vehicle was taken to the dealer, where it was diagnosed that coolant was leaking into the engine short block. The dealer determined that the short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact of the federal safety agency Campaign Number: 17V209000 (Engine and Engine Cooling) however, the VIN was not included. The failure mileage was approximately 148,000.
The contact owns a 2014 Ford Fusion. The contact stated that while her husband was driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating; after which, the vehicle lost motive power. The driver was able to pull to the shoulder of the roadway, where the failure persisted. The vehicle was taken to an independent mechanic, who determined that coolant intrusion in cylinder #4 resulted in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 89,000.
The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, there was white smoke coming from the exhaust pipe. The contact stated that the failure recurred while driving. There was no warning light illuminated. Additionally, the contact stated that there was an abnormal chemical and burning odor inside the cabin. The vehicle was taken to an independent mechanic, where it was diagnosed that the engine had failed. The vehicle was taken to two other independent mechanics, where the same assessment was made. Additionally, the contact was informed that the generation of heat caused by the friction between the two pistons led to the engine failure. Additionally, the contact was informed that there was coolant intrusion in the engine. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 80,950.
Coolant began leaking into the engine causing engine failure
Car was purchased with less than 100,000k miles and within 2 weeks the the car was put into the shop for loss of power while driving and overheating. Had supposedly needed repair and within a week the car overheated again. Paid over 2,000 in repairs and tows due to issue. Car is towed to Ford was told coolant was in the entire and would need to be replaced over $7000. No way Ford should be able to sell calls with known issues and the consumer be responsible for outrageous repair fees. Ford customer service at corporate nor did the dealership offer any type of assistance with the exception of pay for it or start over for scratch which is impossible with today’s inflation. Ford knowingly sold a faulty product and they should be held accountable.
Vehicle started indicating issues turning over to crank. I purchased a new key and key fob for the vehicle and got it programmed successfully I also replaced the starter with a brand new starter, issue still present in which vehicle is not turning on when I turn vehicle on to crank.
2014 Ford Fusion 1.5 Eco boost engine now has 37,000 miles coolant leak into cylinders. Coolant container empty's quickly. Car is undrivable over heats causing a problem driving on the highway. Two mechanics confirmed.
The contact owns a 2014 Ford Fusion. The contact stated that while operating the vehicle, there was white smoke coming from the exhaust pipes and the engine was misfiring. Additionally, the check engine warning light had remained illuminated. The vehicle was taken to the local dealer who diagnosed that engine coolant had leaked into the engine cylinders and the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not eligible for the Manufacturer’s Extended Coverage for the failure. The failure mileage was 75,000.
The contact owns a 2014 Ford Fusion. The contact stated while pulling out of a parking space and driving, the vehicle jerked and stalled. There was no warning light illuminated. The contact was able to pull to the side of the road. The contact turned off and restarted the vehicle, and the vehicle responded as needed. The contact stated that the failure recurred while driving on another occasion. The vehicle was taken to the dealer however, the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 88,000.
The contact owns a 2014 Ford Fusion. The contact initially discovered that the engine was consuming an excessive amount of coolant. There was no warning light illuminated. Upon inspection, the contact discovered that the coolant level was low; however, the contact later discovered that the coolant level was low again soon after topping off the coolant reservoir. The contact stated that the check engine warning light was illuminated. Upon inspection, the contact discovered that coolant was leaking into an engine cylinder. The dealer was notified of the failure and was given an estimate for a diagnostic test. The manufacturer was notified of the failure and referred the contact to the NTHSA Hotline. The vehicle was not repaired. The failure mileage was approximately 108,000.
Engine coolant leak.
Head gasket failed in January of 2023, replaced water pump timing belt and had a full head job completed. Head gasket failed again in September 2023; had a full head job replacement and now again, my engine has overheated with a suspected blown head gasket.
The contact owns a 2014 Ford Fusion. The contact stated while driving approximately 45 MPH, the temperature gauge rose to the HOT zone. The contact stated that she pulled into an auto parts store and was advised to refill the coolant reservoir. The contact topped off the coolant reservoir and then drove the vehicle for less than 20 minutes before the vehicle went into LIMP Mode and lost motive power. The contact stated that the vehicle failed to respond while depressing the accelerator pedal. There were several warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that either the engine or the short block needed to be replaced due to coolant intrusion into the cylinders. The vehicle had not been repaired. The contact researched online and related the failure to Technical Service Bulletin Number: 19-2139 - Coolant Intrusion into the Cylinder (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 140,000.
Coolant intrusion 1.5 liter eco boost.
The contact owns a 2014 Ford Fusion. The contact stated that while his daughter was driving approximately 65 MPH, the coolant warning light illuminated. The contact was informed that the vehicle lost motive power and decelerated to approximately 15 MPH. The contact stated that his daughter pulled off the roadway and turned the vehicle off. The contact drove out to his daughter and jumpstarted the vehicle. The contact used an ODB scanner and retrieved fault code: P1299 “Engine overheated”. The contact cleared the code, and the vehicle was driven back to his residence. The contact replaced the coolant temperature gauge. The contact stated that the vehicle drove normally for several days however, the failure reoccurred. The contact checked the coolant reservoir and noticed that the reservoir was nearly empty. The contact then drove the vehicle to a local dealer who diagnosed the vehicle and determined that coolant had intruded into the engine cylinders. The contact was advised that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact researched online and related the failure to the manufacturer Technical Service Bulletin Number: 19-2139 - Coolant Intrusion into the Cylinder (Engine and Engine Cooling). The failure mileage was approximately 62,000.
Coolant leak into the cylinders of the 1.5 L GTDI EcoBoost engine and causes the vehicles to misfire, overheat and even catch fire. As a result of the failure which has been confirmed by an independent mechanic, the car is not operational only has 103K miles.
The contact owns a 2014 Ford Fusion. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The vehicle failed to function in fifth and sixth gear. There was an abnormal clicking and grinding sound while in fourth gear. There were no warning lights illuminated. The driver was able to pull over to the side of the road. The vehicle was towed to the residence. The vehicle was taken to several independent mechanics, and the contact was informed the vehicle could not be serviced at their location. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the federal safety agency Hotline. The failure mileage was approximately 146,000.
Large volume coolant leak
Replace my first engine because of overheating and severely white smoke due to leaking coolant. Now I'm about to replace my engine again, same problems. I found out from dealership this problem is on recall , just not my particular car but it's the same motor on the other approved cars.
The contact owns a 2014 Ford Fusion. The contact stated that while his wife was driving at an undisclosed speed, the "Engine Coolant Overheating" message was displayed, and the check engine warning light was illuminated. The contact who is an independent mechanic, diagnosed the vehicle and determined that there was a misfire in the engine and the coolant level was low. The contact added more coolant; however, the failure recurred. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 175,000.
Hello, on Saturday May 27th, I took my car in for a regular oil change and thereafter, the rattling noise started the next day, continued rattle had me bring the vehicle back to the dealership on Monday, June 5th. I was informed that my fusion rattling sound was due to the engine flexplate being cracked causing damaging to the transmission oil pump and torque converter. Used chassis ears to pinpoint noise within the transmission bellhousing. Engine flexplat cracked causing out ot round rotation and damage to the transmission. Required transmission and engine flexpalate replacement with alignment due to subframe removal. I looked up online for recalls and found a Ford Customer Satisfaction Program 22N12 for 2019-2020 Fusion - Rattle Noise at the Transmission Bellhousing Area - Flexplate Cracks (dated 08-26-22). Here is the link to the online document found: I purchased this vehicle used in 2021. If this issue affects other Ford years, why is it not included in the recall for older Ford Fusion models especially if the issue is the same as that of the 2019-2022 models? Thank you
The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed, an unknown warning light illuminated. The contact inspected the vehicle and noticed there was no brake fluid in the reservoir. Additionally, the contact stated that while driving the vehicle was overheating. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to the federal safety agency Campaign Number: 23V162000 (Service Brakes, Hydraulic). The manufacturer was not made aware of the failure. The failure mileage was 148,141.
The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The contact looked under the hood and noticed smoke, coolant, and water was pouring from the vehicle. There were no warning lights illuminated. The vehicle was towed to an independent mechanic who stated that the water pump needed to be replaced. The vehicle was repaired but the failure recurred. After further diagnostic tests, the mechanic informed the contact that there was an improper casting on the head and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed the contact that the repair was not covered under warranty. The failure mileage was approximately 104,237.
The contact owns a 2014 Ford Fusion. The contact stated while driving approximately 55 MPH, she heard an alarm sound indicating that the coolant temperature warning light was illuminated. The contact stated that she veered the vehicle off the road when the vehicle hesitated, and the engine seized. The contact was unable to restart the vehicle. The contact then notified her husband who advised her to have the vehicle towed. The vehicle was towed to the dealer where it was diagnosed that the engine short block failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was over the warranty coverage, but no further assistance was provided. The failure mileage was approximately 50,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2014 Ford Fusion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history