On April 1, 2024, while using cruise control going uphill on the interstate in heavy traffic, the truck went into LIMP mode without warning, and multiple lights appeared on the dashboard. Once I swerved over to the side of the road I turned the truck off, let it sit for 15 minutes and turned it back on. Turning it back on allowed the truck to get out of LIMP mode, but the check engine light remained. This happened several times on my drive, but I was able to finally finish my drive several hours later. Next day, all lights on the dashboard were off. The ford dealership could not determine the source of the issue or recreate the issue. This is a major concern as this issue put my safety at risk and could have caused a major accident on a major interstate, putting others’ safety at risk as well. On April 23, 2024, I went to start the truck, and the battery was dead. I confirmed no lights were on to drain the battery, and from April 23, 2024 forward, my power windows randomly stop working.
2022 Ford Maverick Hybrid engine complaints
Page 3 of 6: complaints 41 to 70 of 149, newest first, as owners wrote them.
I had just filled up my truck with gas and started driving to work today and the truck went into limp mode. It flashed a low gear warning, then started to slowly stop, all of the system alarms went off, including the check engine light. There were so many pop-up's I can't recall them all. I was able to pull over and start slowing down before it engaged the emergency brake and I experienced a hard stop. I turned the truck off and back on with no help. I turned the truck off again and opened the door, then shut the door and turned the truck back on and the brake was then turned off but check engine light still on. When I put the truck in drive it would start to accelerate without me pressing the gas. I pulled over again and turned the truck off again and back on. This time the truck behaved more normally but the check engine light is still on. Not sure if this is related to last recall service I recieved.
After shutting the vehicle off and removing the key from the ignition the ICE engine continues to run for a bit. The steering wheel display is also lit up and I had the door open to the vehicle. I opened the hood and confirmed the engine is running. This has happened a few times so far. Sometimes the display that shows the MPH and other info goes out but the engine still runs. I've also had occasions when the key is removed, the engine is running and then shuts off. Pressing the gas pedal, the engine comes to life. If I hold the pedal down the ICE engine runs, remove my foot from the gas and the ICE engine shuts off.
The contact owns a 2022 Ford Maverick. The contact received notification of the federal safety agency Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
On April 22, 2024 my truck had a loss of power foe the second time while driving on the interstate with my family. There was no warnings or anything, the truck simply lost power and I had to pull off the road at which point it went into limp mode. I had several lights on my dash, Mai ly the check engine light and my mobile app recorded a fault with the drive train. This is now the second time this has happened in a few months. I have taken it to the dealer both times and they've told me that nothing is wrong with my truck. I explained that it is extremely dangerous but they said they can't do anything because the truck isn't reporting any issues. Please put pressure on ford to fix this. It is getting out of control.
Recently got a couple recalls done and then yesterday while I was driving back home I Ford chimes twice and then see a plethora of service lights and dash warnings. Completely lost power on the freeway pulled over from originally being in the left lane in time. But could of been a lot worse if I wasn't coming back at 11pm. Restarted the truck and it let me go a max of 20mph all the way home (luckily I was near my exit) flooring it the entire time. Then after an hour of sitting at home I started it up again to surprisingly what felt like full power again but with a check engine light.
I was driving in town going about 20 MPH when I approached and intersection and stepped on the brakes. The brakes locked up, multiple warning lights, messages, audible alarms went off. I though the truck died and I put it in park and turned off the key. Then I turned the key back on, all the lights and warnings came back on, but it also said ready to drive. I was not able to accelerate using the gas pedal, truck was moving slowly on its own, it gained some speed but only ran on the electric motor. No gas engine. I got 3 blocks to my destination very slowly and shut the truck off. I had to go inside to do some work and when I came back about an hour later I turned the truck on and all the alerts were gone except the check engine light. It did run normal then. After calling the dealership they said to bring it in so they could look at it. I left it there and they called later saying they had pulled multiple error codes, did not tell me what they were, they cleared all the codes and drove it and said it did not act up for them and said I could come pick it up. I do not want to drive it because I feel like this could happen again at any time and if I were driving at a higher speed or on a interstate and this happened who knows who could have been hurt. This Maverick is my daily driver for work ect. but I will not drive it unless I absolutely have to right now. I got no answers from the dealership. Before this, no warning lights had been on.
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 45 MPH, his girlfriend who was occupying the front passenger's side seat, informed him that there was an abnormal odor inside the vehicle. Additionally, the contact sustained severe headaches while driving. The contact drove to the hospital, where he was informed that there was an elevated level of carbon monoxide in his blood, and he had sustained carbon monoxide poisoning after two hours of exposure. The contact also stated that the check engine warning light was illuminated intermittently. The vehicle was taken to the dealer, where it was determined that the heater exchange needed to be replaced. The vehicle was repaired. Additionally, the contact stated while driving 70-75 MPH with the Adaptive Cruise Control engaged, a message indicating that the gear was changed forcibly was displayed, and the Eco mode was disengaged, and the engine stalled. The contact was able to pull to the side of the road. The messages "Service Advancetrac", "Service Engine Soon" "Pre-collision Assist Not Available" and "Hill Assist Not Available" were displayed on the instrument panel. Additionally, the messages "Power Train System Fault" and "Collision Assist Unavailable" were displayed on the mobile app. The traction control warning light was illuminated. The contact was able to restart the vehicle after several attempts and a Police Officer assisted the contact in driving to the other side of the road. The contact was able to continue driving at 45 MPH. The vehicle was taken to the dealer, where the failure could not duplicated because the check engine warning light was not illuminated. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 18,000.
 The contact owns a 2022 Ford Maverick. The contact received notification of the federal safety agency Campaign Number: 23V380000 (Engine); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2022 Ford Maverick. The contact received notification of the federal safety agency Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Driving at 65mph and the vehicle began to lose power. Messages displayed on instrument cluster "Service engine soon" "Pre-Collision Asist not available" "Power train malfunction/reduced power" vehicle started losing power and was unable to maintain speed. Check engine light appeared as this was occurring. This occurred in traffic and other drivers did not expect this. I was able to pull over to the side of the road and shut the vehicle down. Once I started the truck again the check engine light remained on but I was able to accelerate back to 60mph.
The contact owns a 2022 Ford Maverick. The contact received notification of the federal safety agency Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The contact stated while driving at 65 MPH, the engine unexpectedly shut off. The Power Train Malfunction, Service Engine Soon, Reduced Power Warning, Pre-collision Assist Not Available, and Active Trac Not Engaged messages were displayed. The check engine warning light was illuminated. The contact pulled over to the side of the road and disconnected and reconnected the negative battery cable to reboot the computer system. The vehicle was able to be restarted, and only the message Service Engine Soon was displayed. The vehicle was taken to the dealer, where diagnostic trouble codes U1011 and U1028 were retrieved; however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000. VIN tool confirms parts not available.
The contact owns a 2022 Ford Maverick. The contact received notification of the federal safety agency Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
My vehicle has been issued recall 23S27 by Ford initially noted in May of 2023. A resolution was to be available in Oct, or 4th quarter of 2023. That did not happen. I received another recall notice from Ford saying the recall would be resolved in the first quarter of 2024. While completing my taxes on April 15, I remembered this and also that no action or repair has been detailed or explained. Thought I would fire off a complaint to the federal safety agency because of the lack of action on this recall. Please advise what, if anything, is happening to resolve this issue.
When coming to a stop on a 25 mph road, saw a cascade of warnings come up, including: Hill start assist not available, precollision assist not available, service AdvanceTrac, service vehicle soon, check engine light, service light, traction control light. Once stopped the car turned the parking brake on and requested that I put it into park. After putting the car into park and turning off the parking brake the car began to accerate on it's own, unresponsive to how hard I pressed the accelerator (limp mode?). I was able to get the car back home on residential roads.
I was going 70 mph on the interstate when I suddenly lost power. The engine wouldn’t respond. I had to quickly change lanes to get off of the interstate. Luckily there was space otherwise I could have been in an accident. The dash gave a warning of Advance Trac issue. The D on the selector was flashing. I got stopped and turned off the truck. Luckily after I gathered myself I searched and found it was a sensor issue and the truck did start and I drove 2 hours home. I was very scary though not having control of the vehicle at 70 mph.
My 22 Lariat Hybrid lost power last Wednesday while I was driving it. I believe the engine was still running, but I couldn't accelerate. I parked, turned the truck off, then back on, and drove home. I was able to drive it to the dealership the next day, no problem, It's at the dealership right now. I haven't heard anything yet.
The contact owns a 2022 Ford Maverick. The contact received notification of the federal safety agency Campaign Number: 23V380000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
I was driving [XXX] on [XXX] around [XXX] yesterday morning north . Without warning I lost control of the accelerator and the speed diminished to around 35 MPH. Several warning lights flashed onto the dashboard saying systems were failing. Check engine light came on and a "wrench" symbol appeared. The light on the transition control dial for "D" started flashing. I was in a construction area with no shoulder when it happened. I was able to creep into a niche on a partial turnoff around .5 miles later. I shut the car off and restarted it. Same problems. I noticed I was .25 miles from an exit and waited for traffic to clear from behind. Managed to get to 10-15 MPH and up the exit with traffic blaring around me. Parked at a McDonald's and wait for a tow truck that never came after 2.5 hours. Made an appointment with nice folks at Classic Ford in Columbia. I was told tow truck might be another 2.5 hours so I tried to restart car. This time only the "check engine" light stayed on. I drove the car slowly in electric mode around the parking lot and it seemed safe at lower speeds. I mapped out a "less the 45 MPH" route to Classic Ford and was able to reach there without further incident. However, the "check engine" light remained on the entire trip. The car is now being checked by Classic Ford. I have had no diagnosis yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
See attached document for complaint
Driving down highway at normal speed. Car lost all engine power, still on but indicated gear shift was not in drive. Pulled off to side of highway. Put drive in park. Dash came up with a bunch of warnings. Turned off. Turned back on. Same warnings happened. Put it in drive and it just start going forward without any input. Was injured in power. Drove it to safe spot. Turned off called for tow. Tried turning it back on and returned to normal but check engine light was on. Very unsafe to loose power in the middle of the highway. My two friends died like that!
While driving at cruising speed on freeway/interstate, experienced sudden and unexpected loss of power and multiple error codes, including "gear selected will engage at low speed" and "service advancetrac", together with flashing service engine soon light. This occurred approximately 3 weeks after completing service recalls for power train control module (23E09) and turn signal outage detection failure and instrument panel cluster IPC Illumination
Took my maverick for the system softward update and when I drove it after the update my truck suddenly had a loss of total power while driving on the freeway at 70mph. The dashboard cluster had all the lights come on check engine, abs ect light up and I had limit power 5mph enough to get my to the side of the freeway and all of a sudden the brake engaged and the truck jolted to a stop. I took the truck back to the dealer and they uploaded the system update again and released the truck back to me and a couple of days later the same thing happened.
The contact owns a 2022 Ford Maverick. The contact stated that while driving the vehicle in a parking lot at approximately 10 MPH, the engine shut off and the vehicle shifted into park(P) independently. The contact stated that several unknown warning lights were illuminated. The contact was able to restart the vehicle; however, the vehicle shuddered while in motion. The contact turned the vehicle off and restarted it after 15 minutes, and the vehicle operated as needed, however, the check engine light illuminated. The vehicle was taken to the residence where it stayed for 2 days. The vehicle was taken to the dealer, but the check engine light was no longer illuminated. The dealer stated that the failure could not be duplicated; however, the manufacturer application showed the messages, "Pre-Collision Assist Not Available", "Service Engine Soon Warning", and "Power Train Malfunction/ Reduce Speed". The vehicle was not repaired. The manufacturer was not aware of the failure. The failure mileage was approximately 30,473.
I brought my 2022 Ford Maverick hybrid to Franklin Ford dealership on 10/2/23 for repair with battery issues I was having previously. At random times the car would not turn on from start despite the battery testing at full power. Franklin Ford installed software updates they said resolved the power issue and I drove off the lot with the car on 10/7. 15 minutes later I was driving on the highway at 70 mph and the entire dash panel lost power. I tried to accelerate and the engine had no power as well. Fortunately I was safely able to move to the break down lane and coast into a highway exit. Since the car had no power I removed the key and tried restarting which worked successfully. My engine light was on and I received about 10 engine and powertrain warnings in my Ford mobile app. This was a major and life-threatening malfunction that the dealership had no explanation for and neither did my case worker at Ford Customer Service. I had owned the car for less than 12 months at the time and it was extremely concerning knowing that the car could now shut off at a moments notice while driving. I returned the vehicle to the same Franklin Ford dealership where it received the software update that seemed to put the vehicle into failure. Their solution was to reroute the wiring harness through the engine since it was previously exposed to the wheel well and had corroded the external layer of the harness. I'm submitting this report because I have seen dozens of similar cases with the same year and model as me. As a first time customer of Ford this has been a nightmare experience.
Engine failed while driving on highway. No noises, just check engine and multiple other warnings on instrument panel turned on. The vehicle lost power but would still drive at about 25 mph. I was able to stop the car in a safe place and after turning it off for 10 minutes it started up again like normal.
Freeway driving - normal conditions. Vehicle suddenly loses most power and all the warning lights appear. After powering off for a couple minutes then it will act normal with check engine light on. This happens multiple times in a couple hundred mile drive.
I experienced a loss of engine power/propulsion at 71 mph. There were no warning lights, messages or chimes to indicate something was wrong. I only noticed I was losing speed when the cruise control went to the standby/cancelled state from the 71 mph set point. The accelerator pedal was completely unresponsive. I coasted to the side of the freeway and performed a key cycle by powering the vehicle off, opening and closing the driver’s door to put the modules to sleep. Once the instrument panel cluster and center stack screens went dark, I restarted the vehicle and was able to proceed with my trip. It’s worth noting that I recently had the instrument panel recall repair performed which was a reflash of the IPC module. Other Maverick drivers have reported similar incidents after Ford 24C01/the federal safety agency 24V140 was “fixed.” I will be reporting this to the manufacturer as well.
One week after having recall [XXX] completed on [XXX] driving on [XXX] at about 70 miles per hour my truck slowed down to 10 miles an hour with my dashboard lighting up with a slew of warning lights blinking like crazy. I was able to get to the side of the road before it conked out all the way. Luckily my wife and did not get rammed into. Service engine now, powertrain failure, will not go into gear at this speed, collision assist warning lights all came on and were blinking. This was [XXX]. Luckily somehow I got the computer rebooted and drove home very carefully. I took it to dealer the following Monday, they had it for 2 days but warning lights were not on so they gave it back to me with nothing rectified. One week later this happened again on [XXX] a smaller highway, same warning lights but at a slower speed. Once again I got the computer to reboot but had to hold my foot on the brake because vehicle wanted to take off and the speed limit was 35. I took it into the same dealer the next day [XXX] and it has been their since. Today is March 29. The dealer finally was able to get Ford to admit this recall screwed up some software and they have no fix yet. No one should go ahead and get this recall done because someone is going to get killed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2022 Maverick shuts down without warning. Driving at highway speeds, 65mph, the car simply loses all power. This started happening after factory recall work was completed on 3-11-24. I have stranded 7 times on the shoulder.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Ford Maverick Hybrid?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history