2022 Ford Mustang Mach E engine problems

Filed Nov 9, 2026 · Electrical, Engine · GA

While driving my EV Mach e, one warning light popped up for “battery charging” service soon. When I turned off of I95 onto the exit, the vehicle suddenly shut down while simultaneously popping up a warning to “pull over to safety” except, the car would not do anything, to allow me to pull to safety. It was a brick in the left turning lane of a highway, while tractor trailers and vehicles were flying up behind me. I tried three times to restart the thing or get it into neutral with no ability to do anything. At that point I realized to keep myself safe from getting killed, I got out of the car in the grass on the middle of the busy highway. Reported the issue to ford, my husband came to get me out of the highway and we waited for the tow truck in a Taco Bell parking lot. The hazard lights were turned on when I got out of the car, however, while waiting for the tow truck the hazard lights died as well, putting other drivers on the highway in a huge risk of safety as well. I’m assuming this is part of the known High voltage junction box recall that Ford put out on the 21-22 Mach E’s, however, Ford Motor company only recalled the extended range and the GT models, mine is a select. I will update this as I get information from the service garage. I’ve attached a screenshot of my vehicle report that shows “no open recalls” as well.

Filed Sep 18, 2026 · Electrical, Engine · CA

1) The high voltage junction box failed causing the vehicle to abruptly stall on a public road. The part will be available for inspection through contacting a local dealership. 2) The vehicle completely stalled at night in the middle of a 6 lane intersection. This posed a hazard for myself as well as for on coming and cross traffic. 3) The dealer has confirmed the failure of this component. 4) The vehicle component is being order of replacement at the dealership. The manufacture has also been informed via their corporate customer service line. 4) 5 seconds before the stall, the vehicle user interface displayed the message "please pull over safely". 10 minutes after the stall the Ford My Pass App showed three error messages: “High-Voltage Battery Warning”, “Powertrain Malfunction/Reduced Power” “Charge System Fault”

Filed Aug 20, 2026 · Electrical, Engine · CA

The high voltage battery junction box connector has failed. There have been two recalls one software and one to replace this part the high voltage battery junction box with a more robust part to handle thermal loads. As of now there are zero recalls on my car open so they are all done. The first time this component failed was around 24k miles ish it's now 56k miles ish and it has failed again even after two recalls and an investigation around the same exact time. This means one of two things has happened either somehow the recalls by Tim Moran ford where not done properly and somehow the older failed part number was installed in my car or the more likely senario is that fords supposed robust part was just a simple part number change without a robust enough design to handle the thermal load. I would like to think that Tim Moran ford who is independent from for has done there due diligence the first time it was replaced and but the correct part number which leads me to conclude the investigation by the NHSTA that resulted in a part change did not fix the issue at hand and the car is now unsafe to drive as this is the second time it has happened to me on this vehicle. Thank god this time I was not going through a curve and headed off road. Same issue almost exact same failure part gone wrong and same issue to date. I demand not only for myself but the safety of others as a former Quality Assurance Representative of electronics on Hueys and Cobras that this be re investigated immediately. It is to late in the game to have zero recalls on my car open two that have been done and the same part fails a second time this should never happen to anyone if it has already been investigated and supposedly fixed. I do not believe it is fixed and the car is not safe to drive I'm hesitant to even go get it when it's ready next week with this serious safety flaw in the design of this vehicle with it still incurring.

Filed Aug 17, 2026 · Electrical, Engine · CA

I am unsure, but I think it's the High Voltage Battery Junction Box. A week after buying the car used from Aaron Ford of Poway, I received a Safely Stop now warning, then the car broke down on the middle of the turning lane into my job a medical clinic putting myself, patients, other drivers, and my coworkers all on danger as it is a busy street. The hazard lights would not work, and the car would not go into neutral. The next day, all the dealership did was replace the 12v battery, then I only got 1 mile from the dealership before it broke down again in an even more busier and dangerous highway in the slow lane and crosswalk. The hazard lights would not work, and the car would not go into neutral.

Filed Feb 17, 2026 · Electrical, Engine · AZ

File against: Ford Motor Company Vehicle: 2022 Ford Mustang Mach-E VIN: [XXX] Safety Complaint While driving, the vehicle unexpectedly slowed down, lost power, and became inoperable, creating a serious safety hazard. I was able to pull over safely, but the sudden loss of motive power occurred during active roadway conditions. Dealer diagnosis identified a wiring harness connector failure affecting communication between vehicle control modules. After the repair, the same issue reoccurred within one to two days, again causing loss of power. The vehicle is currently back at the dealership, and the underlying defect has not yet been permanently resolved. This recurring electrical failure represents a loss-of-motive-power safety risk that may indicate a broader wiring harness defect affecting vehicle reliability and safety. Thanks and Regards INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 10, 2025 · Electrical, Engine · CA

- What component or system failed or malfunctioned, and is it available for inspection upon request? According to the technician, there was a 12-volt battery in the beginning, but after staying in the shop for three days, they found that it was HVBJB, also known as the bussed electrical center (BEC). The car was recalled last July and was in the shop for about a month for HVBJB, also known as the bussed electrical center (BEC). The shop had already replaced the part last year. - How was your safety or the safety of others put at risk? The car suddenly stopped and lost battery power when I was driving on [XXX] going to [XXX]. Las Vegas, Nevada. The car turned off, and there was an error message on the screen. I could not move the car anymore. "When the car suddenly stopped, my wife and I felt like we had hit a wall at 45 miles per hour". - Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, last year, it was by Galpin Ford in Los Angeles when the vehicle was called for a recall in that specific part, and now it was by Gaudin Ford in Las Vegas when this incident happened and they claim they need to replace the same part. Recall Reference Number: 23S56 - Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 26, 2024 · Electrical, Engine · MA

While driving, the car suddenly stopped, showed a "Stop Safely Now" warning and stopped in the middle of a busy road. Car went into Park and could not be moved from the middle of a busy road. Remained in Park and could not even be shifted into Neutral to be pushed out of the way of bust traffic. Very dangerous. No prior warning. Car had to be towed and now at deal for investigation into cause.

Filed Jul 31, 2024 · Driver assistance, Engine · CA · crash

Car was stopped at the top of a hill. Driver put the car in park and exited to talk to a security guard to raise a security barrier. Car began to roll down a hill and didn't stop until it hit a metal security gate 250 yards away. Car was totaled as result of collision with gate. No one was hurt. It would appear that the transmission/engine did not stay in park and began to roll and that none of the other safety features stopped the car. There were no passengers in the car at the time of the accident and no airbags went off.

Filed Apr 11, 2024 · Electrical, Engine · TX

Car suddenly lost all power and flashed multiple warnings. Steering also became disabled. This was moving at a low speed through a school zone so it did not cause an accident. After several restart attempts the car moved again but quickly same issue occurred. Car was towed to Ford. Still waiting for diagnostic.

Filed Dec 17, 2023 · Electrical, Engine · MI

Car got a stop safely now error and stopped working. I had to call a tow truck and have it sent to a dealership.