1999 Ford Mustang technical service bulletins
190 technical service bulletins and manufacturer communications cover the 1999 Ford Mustang.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001...
- Some 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
- Extended coverage program 05N04 - extended coverage for composite intake manifold
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair
- General (PCM) power train control module programming procedures
- Exhaust leak - cracked or separated right side exhaust pipe - 3.8L and 3.9L engines
- Manual transmission hard to shift into first/reverse from a stop
- Engine misfire or running - coil on plug (COP) ignition systems - wds cop kit diagnostic tips
- Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns
- Intermittent loss of power or crank no start - possible pats lamp flashing and diagnostic trouble codes...
- Exhaust leak
- Gear whine in 1ST, 3RD and reverse gears
- Driveline clunk during gear changes and/or quick acceleration after coast (tip-in) clunk
- Remote keyless entry (RKE) - service tips
- Engine misfire or rough running condition with coil on plug (COP) ignition systems may be more accurately...
- Popping type noise while turning into or out of an incline, such as turning into a driveway, at low speeds...
- Malfunction indicator lamp (MIL) illumination with diagnostic trouble codes P0442, P0455, P0456, P0457,...
- New service part - number 5 needle bearing and race kit - 4R70W transmission - service tip
- Passenger seat rubs against door panel
- Inoperative or inacurrate speedometer, 4X4 lamp illuminatd, and / or diagnostic trouble code P1635 or P1639
- Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (CMP) installation...
- Service cylinder head gasket for 4.6L applications
- Climate control a/c service tech tips
- Lamp-brake-invadvertent disabling of brake shift interlock
- Some cobras may exhibit a clunk noise from the driveline during a quick accleration just after coast...
- Subject regarding inaccurate speedometer
- Information regarding discharged battery charging service tips and guidelines
- Subject regarding speed control lamp
- Some vehicles may exhibit an intake manifold crossover (first runner) coolant seepage condition
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant...
- Engine oil system priming procedures, service tips for reports of premature engine failure
- Information on driveline clunk for cobra models
- Some vehicles equipped with the T45 manual transmission may exhibit a condition of being stuck in reverse,...
- Some vehicles may run rough at cruise or momentarily after stopping, a check engine light,and P030X codes
- Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key...
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing...
- Brake shift interlock
- Body - hood scoop loose or detached from hood
- Some vehicles may exhibit the door glass coming off of the window track
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Vehicles may exhibit audio speaker buzz, squeak, rattling or an inoperative condition
- Some vehicles may exhibit a fead belt jump-off toss
- Some vehicles exhibit the door glass popping off track
- Some vehicles may exhibit a stain on the inside of the headlamp lens.
- Some vehicles equipped with a 4R70W automatic transmission may exhibit a clunk noise during the 2-1...
- Some vehicles equipped with a manual transmission may exhibit a powertrain noise described as a brief...
- A whining noise heard from the rear during coastdown from 97 to 56 km/h (60 to 35 mph)
- This bulletin states that on some vehicles (including 2002 blackwood) a battery disconnect or parameter...
- Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on...
- Some vehicles may exhibit driveline vibration felt through the seat, floor and / or steering wheel at...
- Vehicles equipped with passive anti-theft system (PATS) may not start or crank
- Some vehicles may exhibit inoperative door glass due to the window regulator rear track roller breaking...
- Subject regarding certain vehicles with 4.6L romeo engines exhibiting an oil leak from the cylinder head...
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5W-20 motor oil
- Some vehicles may exhibit a hard start, diagnostic trouble code P1233 and / or P1414, right front exterior...
- Inoperative or inaccurate speedometer as well as 4X4 light inoperative and / or diagnostic trouble code...
- Some vehicles equipped with 3.8L engines may exhibit engine spark knock on heavy acceleration with 87...
- Some vehicles equipped with a 7.5 inch axle may exhibit a decel axle whine at approximately 55-30 mph
- Information on caster adjustment when performing a front end alignment
- Some vehicles may exhibit a hesitation and in some cases engine backfiring through the induction system on...
- Some vehicles may exhibit a speaker / buzz rattle when operating the audio system
- Subject regarding parking brake control assembly modification
- Information pertaining to 4.6L 4V pulley instructions
- Some police interceptors may exhibit poor acceleration at wide open throttle after the 3-4 shift from 110...
- Some vehicles equipped with a 5-SPEED manual transmission may exhibit a hesitation / stumble when cold...
- Some vehicles equipped with a 5 speed manual transmission may exhibit a hesitation / stumble when cold...
- Some vehicles may exhibit a vibration that may be heard of felt at the clutch pedal between idle and 2300...
- Some vehicles may experience a whining noise heard from the rear during coastdown from 97 to 56 km/h (60...
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the...
- Some vehicles may exhibit a hood that is hard to close
- Concerns with the intake manifold leaking or weeping coolant from passenger side gasket at right rear...
- Inoperative or inaccurate speedometer, 4X4 lamp illuminated and / or diagnostic trouble codes (DTCS) P1635...
- Some vehicles with traction control, may exhibit an intermittent ABS lamp on with the diagnostic trouble...
- Information regarding free floor mat exchange
- Some vehicles may exhibit a 10-15 second delay in instrument cluster operation with koeo or koer
- Some vehicles equipped with traction control, may exhibit an intermittent ABS lamp on with diagnostic...
- Some vehicles equipped with 3.8L engines may exhibit engine spark knock on heavy acceleration with 87...
- Some vehicles equipped with the 4.6L 2V engine may exhibit a check engine lamp on with diagnostic trouble...
- Brief information stating that engineering is investigating coupe or convertible vehicles exhibiting a...
- Some vehicles built between november 1998 and february 1999 may exhibit a loss of remote transmitter operation
- Some coupes or convertibles may exhibit a water leak or windnoise
- Vehicles equipped with traction control, may exhibit an intermittent ABS lamp on with diagnostic trouble...
- Information regarding the new transmission cooler flusher- service tip
- The vehicle exhibit a dead battery/high amperage drain concern
- All vehicles may exhibit an inoperative or inaccurate speedometer, 4X4 light inoperative and/or DTC P1635...
- Some vehicles equipped with 3.8L engine may exhibit a dead battery/high amperage drain concern
- Some vehicles equipped with the 4.6LO 2V engine may exhibit a check engine light on with dtc's...
- Some vehicles equipped with a 3.8L engine may exhibit spark knock on heavy accel with 87 octane fuel
- Subject regarding installation of crankshaft pulley torque specification
- Some vehicles equipped with 3.8L engine and manual transmission may exhibit transmission oil seepage, oil...
- On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off...
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble...
- Experiencing a vibration felt through the seat or the steering wheel on some vehicles travelling 105 - 125...
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks
- Concerns with the convertible top boot may fit improperly or be difficult to install on some vehicles due...
- Experiencing a popping or oil canning noise coming from the drivers footwell area
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Subject regarding front wipers operating while switch is in off position
- Exhibiting brief intermittent interruption of instrument cluster dash lights function(s) and / or a crank...
- This bulletin mentions that certain vehicles are not equipped with a passenger door lock cylinder
- Exhibiting a speedometer that reads faster than actual vehicle speed
- Information on using peanut style a/c fittings
- Customers may experience a poor or no air conditioner performance due to a loss of refrigerant
- Some coupes may exhibit a vibration at highway speeds
- Information regarding a/c peanut o-ring color
- Some vehicles may exhibit poor or no a/c performance due to a loss of refrigerant
- Some vehicles may exhibit brief intermittent interruption of instrument cluster function(s) and / or a...
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Subject regarding intermittent transmission control indicator lamp or malfunction indicator lamp illumination
- Vehicles built between 3/15/1997 and 12/31/1998 and with 4R70W transmissions may experience delayed or no...
- Some vehicles may exhibit an intermittent transmission control indicator lamp or malfunction indicator...
- Information regarding a change in the torque values of the engine front cover water pump bolts
- Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with...
- Information regarding ABS with traction control code B1142
- Information regarding ABS false cycling
- Information regarding camshaft position (CMP) sensor alignment tool chart (continued)
- Information regarding front cover & water pump bolts-torque valve revision/3.8-4.2L
- Information regarding 5-SPEED- exchange transmission unit
- (Continued from 13251 and 13252) uncommanded front wiper function. mjs
- Subject regarding vehicles equipped with 4.6L engine regardless of transmission, may exhibit a (front end...
- Some vehicles equipped with T-45 manual transmissions may exhibit inability to shift out of reverse,...
- Sone police vehicles and other vehicles with 4R70W may exhibit a vibration and / or transmission extension...
- Some vehicles may exhibit a front end accessory drive (FEAD) belt toss
- Some vehicles equipped with T45 manual transmissions may exhibit the inability to shift out of reverse,...
- Information on the new flush and fill tool available through rotunda
- Customers may have concerns that beverages will spill when put into the cup holder
- Information on using the service bay technical system (SBTS) and new generation star (NGS) tester, and to...
- Some vehicles may exhibit some normal service concerns with power seat operation
- Subject regarding evaporator case investigation
- Conditions with the brake lamps inadvertently disabling the brake shift interlock
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (NVH)...
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on...
- Ford motor company has released a private labeled material to be used for iron particle / acid rain...
- Concerns with road noise may be heard from the rear wheel area as well as dust intrusion into the luggage...
- Some vehicles with manual transmission may exhibit a fed belt concern
- Information on the new mustang, cobra r and econolined featured on the next spotlight on qsf show
- Exhibiting front windshield wiper activation without command
- Information on checking driveshaft run out
- Experiencing front wipers activation without command
- Information on power seat switch replacement
- Some vehicles may exhibit activation of front wipers without command
- Subject regarding door trim panel replacement - service tip
- Ford motor company now recommends sae 5W-30 viscosity grade for servicing any ford gasoline-powered...
- Recall information regarding speed control cable replacement
- Information regarding passenger door locks
- Conditions with a hard start or diagnostic trouble code (DTC) P1233
- Information on resetting the passive anti-theft system (PATS)
- Some convertible vehicles may exhibit a body vibration / shake
- Experiencing a vibration and / or transmission extension housing bushing damage
- Concerns with moaning / groaning noise from the heater core
- Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system...
- Some vehicles may exhibit a vibration and / or transmission extension housing bushing damage from...
- Some vehicles equipped with a 4.6L 2V engine may exhibit a moan / groan from the heater core area of the...
- Some vehicles with manual transmission equipped convertibles may exhibit a body vibration / shake
- Some vehicles with a manual transmission may exhibit a fead belt concern (front end accessory drive)
- Information regarding reprogramming powertrain control modules (PCMS)
- Concerns with transmission fluid leaking at radiator
- Information on diagnosing passive anti-theft system (PATS) issues
- Some vehicles may exhibit a loss of key fob (remote transmitter) operation
- Concerns with transmission fluid leaking at the radiator
- Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent,...
- Ford motor company has released a new electrical grease ( F8AZ - 19G208-AA ) to reduce the possibility of...
- Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern
- Information on the alive memory (DAM) feature during various diagnostic and repair procedures
- Some vehicles built from october through december 1998 may exhibit an inability to program new rke...
- Some vehicles may have headlamp assemblies that appear to have damaged horizontal adjustments
- Some vehicles built 10/1998 through 12/1998 may exhibit an iso diagnostic link failure message when...
- Some vehicles built from october through decemger 1998 may exhibit an inability to program new rke...
- Some vehicles may have headlamp assemblies that appear to have damaged horizontal adjustments
- Mass air flow (maf)- sensor contamination- service tip
- Some vehicles may exhibit an inoperative speedometer and DTC P1635 after a PCM has been replaced
- Some vehicles with 4R70W transmissions built from 4/16/98 through 10/30/98 may exhibit a leak from the...
- Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys...
- Certain vehicles may exhibit an inoperative speedometer and diagnostic trouble code P1635 after a pecm has...
- Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern
- Some vehicles may require the keep alive memory (KAM) to be reset during various diagnostic and repair...
- Experiencing a " buzzing " or " rattling " noise from the exhaust system
- Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Ford Mustang?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history