1999 Ford Ranger fuel system problems

Filed Sep 21, 2019 · Fuel system, Suspension · TN

Frame is very rusted and big holes in the frame. I think there is a gas leak as well but the frame is very bad.

Filed Feb 2, 2016 · Body, Fuel system · 120,000 miles · NY

My frame is rusting out! I was having problems filling my gas tank so I brought it in to the shop to find that where the gas tank supports attached to the frame had rusted out. My gas tank was hanging on by a thread. I had to have the whole thing removed, repaired, and replaced.

Filed Oct 10, 2014 · Body, Fuel system · WV

I have seen multiple 99 ford ranger, and every one I have seen is rusted out. Frame, rear bumper & bed. There are other places rusted but not as bad as the frame, rusted in half, rear bumper fell off going down the road, other thinga that bolt under the bed fell out.

Filed Feb 27, 2013 · Body, Fuel system · 126,000 miles · PA

Rear of truck is rotting away to nothing. Had the rear of the frame plated a few years ago where the shackle brackets bolt on. Now I noticed one of the fuel tank straps hanging. The crossmember that holds it is rotted away to nothing. Took the truck to my mechanic. He called me after about an hour & told me the truck was junk. The whole frame & crossmembers from the cab back are rusted horribly. He told me not to even drive the truck because it wasn't safe.

Filed Feb 19, 2012 · Body, Fuel system · 127,000 miles · MA

1999 ford ranger with 130,000 miles. Leaf springs rusted out (both sides) and mounting brackets also rusted. Went to 3 autobody shops and nobody would touch it. Bumper just rusted out on both sides and spare tire well is completely rusted. Bumper and spare currently being held together with 2, 1900 lb chains. Ranger runs fine just body falling apart. Very concerned tire, bumper may become dislodged and cause further damage to myself or others. Gas tank also rusted but not leaking so far.

Filed Sep 13, 2011 · Body, Fuel system · 153,000 miles · VA

First failure was where leaf springs attach to frame (rear shackles) failed due to rust and put hole in truck bed. Replaced parts. Second failure is when filling tank with fuel; gas has started to run out on the ground at the gas station. Just received filler neck today to replace current rusted one. While under vehicle noticed tank strap is hanging loose not attached due to connection point rusted off (similar failure to the federal safety agency recall campaign #11v385000 fuel tank strap failure). Also noticed severe rust like little or no rust inhibitor was applied to frame and components. Shield above muffler is almost non-existent, frame cross member is flaking away due to rust. I am not qualified to provide full details of problems or cause but rust is becoming a safety issue with this vehicle. Contacted ford and they say vehicle is not part of recall.

Filed Aug 10, 2011 · Body, Fuel system · 130,000 miles · MA

Tl* the contact owns a 1999 ford ranger. While parked, the contact noticed that the fuel tank had partially detached from the vehicle and was hanging down below the frame. The vehicle was taken an independent mechanic, who stated that the cross member, which held the mounting system for the fuel tank, was rusted. The manufacturer was made aware of the failure and suggested the vehicle be taken to an authorized dealer for diagnostics. In addition, the cross member was not available for purchase and the rear frame would have had to have been replaced. The vehicle was not repaired. The approximate failure mileage was 130,000. Updated 09/21/11*lj the cross member support at attaching fuel tank strap failed due to rust, allowing the fuel tank to hang low. The fuel tank is currently being held in place by a rope. The fuel filler is now separated from the body. Updated 09/27/11

Filed Aug 1, 2011 · Fuel system · GA

1999 ford ranger xlt 4x4 fuel filler tube to the gas tank made of material that corrodes.

Filed Oct 27, 2008 · Fuel system · 71,000 miles · OH

In july 2008 engine light came on with code po442. Put new gas cap on and light was off until sept 2008 when it came on again with the same code. I cleared the code and the light came on again oct 2008 with code po455. I crawled under the truck and discovered the (fuel filler) tube is rusted out. Fuel leaks on ground when filling tank and the automatic nozzle shuts off. I believe this is a safety hazard. John

Filed Mar 31, 2006 · Fuel system · OK

When filling the gas tank, fuel spilled out onto ground. At the time, I was not aware of this site to post complaint.