2006 Ford Ranger body problems

Filed Jun 24, 2022 · Body · PA

Frame prematurely rotting out in critical areas near fuel tank/middle of vehicle frame

Filed Jun 9, 2022 · Body, Suspension · IN

The spare tire stabilizing bracket rusted away and fell off. The rear shackles for the springs broke on both sides, and is coming up through the bed. The frame has rusted apart and it’s not possible to bolt a new shackle for the rear springs on. The body is not rusting out. They used inferior steel on the frame and it has rusted away. They should do a recall on these like other manufacturers have. This is a serious safety issue. I bought this truck new, and it only has 98000 mikes on it.

Filed Mar 12, 2021 · Body · 171,500 miles · MA

The rear frame crossmember rusted to the point where the spare tire it supports almost fell out. I noticed it was hanging about 6' low so I caught it before it fell. The entire part is horribly corroded. Note that the wood was temporarily installed to hold the steel up to drive home.

Filed Jan 25, 2021 · Body · 140,000 miles · VT

Tl* the contact owns a 2006 ford ranger. The contact stated while getting the vehicle inspected he was informed that the subframe was corroded. The vehicle was taken to an independent mechanic however, the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 140,000. *bf the consumer stated repairing the vehicle would cost more than vehicle's worth.

Filed Sep 2, 2020 · Body, Wheels · 150,000 miles · OH

The frame and bed is completely rusted out. So much so that the one of the leaf springs broke loose and came through the bottom of the bed while driving down a straight stretch of road. The truck is now completely not drivable. I have heard several complaints about this same make/model/year truck. Even from people where their cities don't salt the roads in the winter.

Filed Jul 21, 2020 · Body · 124,000 miles · OH

The body on my fx4 ford ranger is in really great condition, the frame is rusting away. Mostly on the driver side bed. Is there any recall on this. Thanks for your time. Sincerely [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Jun 14, 2020 · Body · MD

The frame on this 2006 ford ranger is completely rusted out and is no longer safe to drive.

Filed Oct 3, 2019 · Body · 46,000 miles · MA

While driving at highway speed got a fuel cap loose warning light on dash board. Pulled off the highway and checked and it was tight. Took the 2006 ford ranger to the repair shop where it was found that the cross frame that supports the spare tire under the bed has rusted free at both ends! It was fortunate that the cable that lifts the tire into placed was still attached. Had the tire come loose it would most likely caused the rear end to lift up and at 60 MPH in morning rush hour traffic that would be spectacular! The reason for the warninglight was tha as the frame broke loose it crcked the connection to the emissions canister that is mounted on the corss framemember.

Filed Feb 25, 2019 · Body · 150,000 miles · SC

2006 ford ranger. The whole frame is rusting bad enough it has to be replaced. There has been a few places patched and the cross member news to be replaced as well

Filed Oct 8, 2018 · Body · 85 miles · CT

Takata recall on my ford ranger underneath the truck where the frame is it has been completely eaten up by rust. My spair tire has fallen off because the frame is covered in rust. And the main body frame rust off and it's completely disconnected under the bed. My vehicle was in motion when I lost the spair tire