2024 Ford Ranger body problems

Filed Oct 15, 2026 · Airbags, Body · 50,148 miles · FL

The contact owns a 2024 Ford Ranger. The contact stated that while driving at approximately 15 MPH and making a U-turn, the vehicle experienced a total loss of motive power. The Service Emergency Brake and Trailer Brake Assist warning lights illuminated. The vehicle was towed to a local dealer, where it was diagnosed; however, the diagnosis details were unavailable. Additionally, during rainy weather, water intruded into the cabin and accumulated, leaving the seats wet and causing mold growth. The local dealer was contacted on several occasions regarding the water intrusion. Upon further investigation, the contact associated the failure with the federal safety agency Campaign Number: 26V238000 (Structure, Electrical System) and the federal safety agency Campaign Number: 25V541000 (Air Bags), suspecting that improper completion of a prior recall repair contributed to the failure. The manufacturer was notified of the failure by telephone and email. The failure mileage was approximately 50,148.

Filed Sep 10, 2026 · Body, Electrical · MN

The consumer owns a 2024 Ford Ranger. The consumer received notification of the federal safety agency Campaign Number: 26V238000 (Structure, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted and stated that the parts were unavailable, even though the recall notification stated that parts were available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The vehicle remained with the dealer unrepaired since June 22, 2026. The contact stated that the interior lights, including the dome light and the sun visor lights, were inoperable. The dealer confirmed the failure.

Filed Aug 19, 2026 · Body, Electrical · 323 miles · NY

The contact owns a 2024 Ford Ranger. The contact received notification of the federal safety agency Campaign Number: 26V238000 (Structure, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that there was an abnormal burning odor inside the vehicle, and the instrument cluster flickered while driving. The dealer was contacted and confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that a second letter would be sent once the remedy was available, and parts were anticipated by the end of August 2026. The failure mileage was approximately 323.

Filed Jul 16, 2026 · Body · NY

The front passenger side door on my 2024 Ford Ranger does not latch properly creating the possibility of passenger ejection. 2 Ford dealers have each tried to fix the problem but both say they cannot and that it is a Ford design issue. This problem was present upon delivery of my new vehicle. and continues to this day.

Filed Dec 21, 2025 · Body · MI

Didt show how close car was to pole

Filed Jul 21, 2025 · Body · 10,000 miles · PA

The contact owns a 2024 Ford Ranger. The contact stated that while trying to purchase a diamond back bed cover, upon further investigation, it was found that the vehicle was missing the load box reinforcement bracket. The missing bracket might cause the structural performance of the bed to fail. The vehicle was taken to the dealer; however, the vehicle was not inspected or repaired. The manufacturer was made aware of the failure. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 10,000.

Filed Mar 12, 2025 · Body · TX

[XXX] [XXX] [XXX] [XXX] 3/12/2025 the federal safety agency 1200 New Jersey Avenue SE Washington, DC 20590 Subject: Complaint Regarding 2024 Ford Ranger Raptor VIN [XXX] Team, I am writing to formally report a safety issue with my 2024 Ford Ranger Raptor, VIN [XXX] . After purchasing this vehicle, I encountered a significant problem that I believe poses safety concerns. Recently, I learned that Ford has developed a solution for this issue, as detailed in the following press release: WSAV Press Release. However, Ford is unwilling to cover the necessary repairs under warranty, despite the fact that this solution became available shortly after my purchase. I believe that this situation requires your attention, as it not only impacts my vehicle but may affect other owners of the same model. I urge the federal safety agency to investigate this matter to ensure that safety standards are upheld and that consumers are treated fairly. Thank you for your attention to this important issue. I look forward to your response. Link #1: [XXX] #2: [XXX] Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 21, 2025 · Body · CA

Not sure if this is the correct channel, but here goes my concern. The safety incident has not yet occurred, but the manufacturer has stated it could/may occur if a certain fix is not performed, but are unwilling to issue a recall for said fix, or even produce the parts they say are necessary to implement the fix. I own a 2024 Ford Ranger Raptor that Ford has demonstrated has a design flaw in their bed (for vehicles produced before mid Sept, 2024) in that it cannot carry more than 88 lbs on the bed rails without the potential for failure. I need to install a topper to protect and secure cargo in the bed which will exceed the 88 lb failure number they state. The fix they say must be implemented is to install 2 Ford supplied load box reinforcement brackets (called J-braces), yet I've been trying to order/obtain said braces for almost 5 months now without success. Ford seems to have given up on producing them as they've been "out of stock" since I purchased my vehicle, and Ford has cancelled my order for them twice now, when I try to submit an order. If the bed fails due to weight above 88 lbs put on the rails while driving, depending on what a failure looks like, it could cause collisions with the affected vehicle, or with other traffic in the vicinity. Ford has been completely unresponsive in issuing a recall so far regarding this known design flaw, yet they redesigned the suspect area mid year to fix the issue on vehicles produced after mid-Sept and going forward. Yet they are leaving purchasers of vehicles prior to this time, in a precarious position as they have potential safety concerns that Ford is unwilling to address, or even provide a solution for.

Filed Dec 28, 2024 · Body, Suspension · CA

I purchased a new 2024 Ford Ranger yesterday. As I was researching camper shells and truck racks I found that these common items cannot be installed without first installing a load bed reinforcement bracket kit to reinforce the truck bed to the bed side rails. Apparently, nothing can be attached to the side rail which weights more that 88 lbs or the truck bed could separate from the side rails. This is an design/engineering shortcoming from Ford as these are common after market add-ons for mid-sized trucks. Also, Ford is asking customers to pay for the reinforcement bracket and installation - which was quoted today at $1,600, and the Ford part is not currently available from the corporate US Ford website, and has not been available for several months.

Filed Sep 29, 2024 · Body · ID

2024 Ford Ranger Trucks made in Michigan between January 4, 2024 to July 15, 2024 do not include the load box reinforcement bracket. Without this bracket installed, if the owner were to place more than 88lbs onto one or both bed side rails the bed could crack, warp, bend, or break. If operators of this vehicle are not aware and do load the bed side rails over 88lbs, this could pose a safety issue to the driver or other drivers on the road around the vehicle. Ford has not notified all owners of affected vehicles, and in my case I found out my vehicle was affected out of sheer curiosity and reading forums with posts of other owners whose vehicles are also affected. Ford is currently not willing to address the issue without additional cost burden on the vehicle owner.