1992 Ford Thunderbird electrical problems

Filed Sep 15, 2010 · Electrical · FL

1992 ford thunderbird recalled for replacement of ignition switch a few years back (the federal safety agency action number: ea95002). Defective switch was replaced with exact same part that was recalled and failed again within one year with two halves of unit again coming apart. I have just replaced for the fifth time with exact same defective unit, this being the only thing available from ford and from aftermarket suppliers. How does replacing defective part with exactly same part eliminate fire hazard associated with this part which prompted recall in the first place???

Filed Jan 24, 2005 · Electrical, Lights · 98,000 miles · OH

Consumer' s vehicle experienced the same problems as stated in the federal safety agency recalls 96v071000 and 99v27500 concerning ignition system and headlights. The dealership indicated consumer's vehicle not included in the recall due to VIN. *ak

Filed Aug 24, 2004 · Electrical · OH · fire

While driving consumer smelled smoke coming in from the vents. Consumer pulled over, lifted the hood up, and vehicle caught on fire. Consumer was able to extinguish the fire. Consumer had the vehicle towed to the dealer for inspection.

Filed Aug 13, 2004 · Electrical · CA

While placing the key inside of the ignition switch the key failed to come out from the ignition. Consumer had the vehicle towed to the dealer for inspection, and mechanic determined that the ignition switch needed to be replaced.

Filed May 12, 2004 · Electrical · CA

While placing the key in the ignition switch vehicle failed to start. Consumer turned off the vehicle, and then restarted it. Drove it to the dealer for inspection, and mechanic replaced solenoid switch inside the ignition due to a burnt out wire.

Filed Apr 15, 2003 · Electrical · GA

While driving the eec fuse blew out and caused the vehicle to stall. The dealer was notified.

Filed Aug 26, 2002 · Electrical, Lights · WA

Sometimes turn signal works and sometimes they do not work. Consumer has to wiggle key, and signals may or may not illuminate. Cause unknown. Recall 96 v 071 000 described the same problem. Please provide any further information.

Filed Aug 21, 2002 · Electrical · TN · fire

The harness at the alternator has caught fire twice and I have replaced the alternator three times in two years. This is a very dangerous situation. It starts smoking and suet comes out and you think the car is going to blow up. It is a very frightening experience. The mechanic found service bullentin article #96-21-4 which describes this. It has happened to me twice in less than two years. I am very distrubed. Please help me.

Filed Jul 9, 2002 · Electrical · KS

Vehicle exhibits symptoms similar to earlier models with tfi; sudden stall at any speed or configuration. Always associated with high ambient/engine temperature. Problem has occured on highway, creating extraordinarily dangerous situation. Dealer technician dismissed possible ignition failure when asked.

Filed Jun 13, 2001 · Electrical · FL

Headlights goe out for various intervals which may be preceded by flickering or blinking as a result of circuit breaker opening. Dealer has been notified. Please provide further information.