1996 Ford Thunderbird engine problems

Filed Jul 12, 2011 · Engine · 60,000 miles · OR

Tl* the contact owns a 1996 ford thunderbird. The contact was driving 30 MPH when he noticed an abnormally strong coolant odor. The contact then inspected the vehicle and found that the antifreeze intake manifold had failed. The intact manifold was cracked and causing antifreeze to spill. The vehicle was not taken to the dealer to be diagnosed or repaired. The failure and the current mileage was 60,000.

Filed Aug 3, 2007 · Engine · 95,700 miles · CA

Defective intake manifold. Ford replaced once, free of charge @ 48,523 miles. Cracked again @ appx. 95,700 miles. Ford refused to replace free of charge. Replaced one defective manifold with one that was just as defective. There was a class action suit on this manifold, it was so bad.

Filed Jul 14, 2007 · Body, Engine · 20,000 miles · NC · 1 injury

Intake (plastic) cracks ;leaving family and I stranded on 30 mile stretch of highway with no houses or business. Towed to station and fixed recalled intake. Taxi cost home and back 2 days later to retrieve car soon started having heater coil leaks and overheating;antifreeze causing headaches. Almost $1000.00 to replace 30 dollar part(dash board and console removed and air condition unit disconnected and recharged) dealer took cost of next 2 replacement heater coils and it still needs 4th;no heat;still leaks antifreeze inside car. Intake manifold(plastic) cracked again;overheated and burnt me this time also causing serious damage to car;very costly which I guess we the consumer will have to bear. How many complaints does it take?

Filed Dec 26, 2006 · Engine · 80,000 miles · NJ

Tl* - the contact wanted to have repair done to 1996 ford thunderbird, however service bulletin #97m91, dated jan 19, 1998 (the federal safety agency item number: 605621) expired and ford charged for the repairs. The mileage at the time of the failure was 80000. The contact said that the service bulletin was for the intake manifold. The contact wrote to ford. The refused to honor the service bulletin. *ak updated 2/6/2007 -

Filed Sep 13, 2006 · Engine · 84,518 miles · VA

Defective intake manifold on 1996 ford thunderbird. The car only has 84,450 miles on it! Cost was $1002.02 to repair. Why is the consumer being charged for this costly repair when this is a known defective part from the ford motor company?

Filed Apr 11, 2006 · Body, Electrical · KS

Compliant is that through my insurance provider I was alerted to two recalls that should be at least looked into on my auto. The first is the blower on the climate control began to work erratically and now it does not work at all. Meaning that my defrosting does not work at all. The other and more serious is that the drivers side door latch sticks at smacks against the peg and does not latch properly or at all, unless the latch is manually lifted. Both of these are recalls for other t-birds but somehow mine slipped through. Vin is [xxx]. If these are such common problems why weren't all the t-birds recalled? I am looking at over 600.00 to replace these parts. Which is irritating when ford should be fixing it's known problems. *nm updated 07/16/2012 * js information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)

Filed Jan 20, 2006 · Engine · 127,000 miles · AZ

Dt*: the contact stated the intake manifold cracked and caused the vehicle to overheat without prior warning. The vehicle was seen by an independent repair shop. The repair shop personnel suggested the manifold cracked due to the composite plastic used in manufacturing. The manifold was replaced with an after market manifold made of metal material.

Filed Dec 22, 2005 · Engine · WI

I had a 96 t-bird that my daughter now owns. The plastic manifold cracked last spring causing me to be stranded on the highway. My sister towed me to her house where the vehicle sat until I got a new manifold for about $289 online. I installed it myself taking me about 2 days and driving 45 miles each way twice to my sister's house. Old part was discarded.

Filed Oct 3, 2005 · Engine · 78,652 miles · MI

Intake manifold cracked. This part was made out of nylon and is a known defective part installed at the factory. Ford motor company refused to reimburse stating that there was a customer satisfaction action in 1996. Since the problem was due to a known defectivepart I think it should be covered for life of the vehicle. Later ford redisigned the part using aluminum instead of nylon.

Filed Jul 26, 2005 · Engine · 60,000 miles · ID

3.8 cylinder head failure