2015 Ford Transit engine problems

Filed Jul 22, 2026 · Engine · CA

See attached document for complaint.

Filed Jul 22, 2026 · Engine · CA

See attached document for complaint.

Filed Dec 5, 2025 · Engine, Transmission · IN

Recalled part failed causing damage to other parts on vehicle, ford motor company refuses to repair the damage - no recall notifiactions sent - we are not original owners of vehicle

Filed Nov 7, 2025 · Electrical, Engine · 70,000 miles · CT

The contact owns a 2015 Ford Transit. The contact stated that water had leaked through the windshield and into the air filter compartment, onto several wires for different electrical systems in the vehicle, and onto emissions components, which affected the engine timing. The contact stated that while inspecting the vehicle, the contact noticed that there was approximately 2-inches of water in the air filter box. The check engine warning light was illuminated, with diagnostic trouble codes indicating that the Oxygen sensors had failed, and the timing was not being converted correctly. The vehicle was taken to a certified mechanic, who diagnosed that the catalytic converter needed to be replaced. The vehicle was not repaired by the mechanic. The contact replaced the catalytic converter and placed a seal around the windshield. The manufacturer was informed of the failure, and it was confirmed that the VIN was not included in a recall related to the failure. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 70,000.

Filed Aug 21, 2025 · Engine · 100,000 miles · IL

The contact owns a 2015 Ford Transit. The contact stated that while his brother was driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the fuel pump module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,000.

Filed Mar 13, 2025 · Engine · OH · fire

See attached document for complaint.

Filed Feb 11, 2025 · Engine, Fuel system · 109,000 miles · CA

The contact owns a 2015 Ford Transit. The contact stated while driving at an undisclosed speed, the message "Exhaust filter overloaded, drive to clean", after which the vehicle entered LIMP Mode, and was unable to accelerate above 30 MPH. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the Diesel Particulate Filter (DPF). The vehicle was repaired under Customer Satisfaction Program: 23M01, but the failure reoccurred. The vehicle was then taken to an independent mechanic, who diagnosed a failure with the Diesel Particulate Filter (DPF). The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 109,000.

Filed Jan 2, 2025 · Engine · 59,000 miles · NJ

The contact owns a 2015 Ford Transit. The contact stated that while at a stop light, the vehicle stalled. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the engine had seized and needed to be replaced. The cause of the engine failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 59,000.

Filed Dec 6, 2024 · Engine · 13,000 miles · NC

The contact owns a 2015 Ford Transit. The contact stated while driving at undisclosed speeds, the check engine warning light was illuminated. The contact stated that the failure was related to Customer Satisfaction Program: 15B39 CPR and Technical Service Bulletin: 19-2091. The vehicle was taken to the local dealer, where it was diagnosed with water intrusion from insufficient sealing in certain areas of the engine compartment, allowing water entry into the engine compartment. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no warranty coverage on vehicle. The failure mileage was approximately 13,000.

Filed May 22, 2024 · Brakes, Electrical · CA

The Van looses all power. This has happened 4 times. The display will appear brake boost failure or engine failure. We were driving on the 60 fwy in the number one lane when this happened last. My husband was able maneuver to shoulder without causing an accident.