Tl*the contact owns a 2000 freightliner century truck. While driving approximately 55 MPH, the driver felt a rumble and thump coming from the vehicle. He attempted to pull the vehicle over, but the wheel bearings became loose. As a result, the wheel was hanging on the steering spindle, the brakes were hanging in pieces, and the air line failed. In addition, the plastic access panel failed. There were no injuries. Roadside assistance was called and it was discovered that the entire wheel assembly was defective. The vehicle was then towed to a dealer and repaired at the contact's expense. The manufacturer stated that the vehicle was not included in the federal safety agency campaign id number 03v112000. The current mileage was approximately 910,000 and failure mileage was approximately 900,000. Updated 07/14/09.*lj the consumer was informed he missed the recall by 4 weeks and a couple of days. The consumer stated he has the same hub unit that was recalled and is requesting reimbursement. Updated 07/16/09.
The worst 2000 Freightliner Century problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Suspension8
- Body2
- Engine2
- Seats1
- Steering1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Suspension8
- Body2
- Engine2
- Seats1
- Steering1
- Visibility1
- Wheels1
Recalls 6
Suspension: front: hub
- What is wrong
- On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
- Risk
- Seizure of the bearings can cause wheel separation or wheel end fire.
- Remedy
- Dealers will replace both front hubs. Owner notification is expected to begin on or before september 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.
Recall number 03V112000 · Recall details
Steering: linkages: tie rod assembly
- What is wrong
- Vehicle description: heavy duty trucks equipped with trw tie rod ends on certain meritor axles. The tie rod and drag link ball stud ends contain bearings that are below the specified case depth and/or hardness.
- Risk
- This can lead to premature wear with possible separation of the ball stud from the socket, increasing the risk of loss of control of the vehicle.
- Remedy
- Dealers will remove and replace all affected tie rods and drag links with different designed ends. Owner notification began november 8, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.
Recall number 01V140007 · Recall details
Service brakes, air: controls, pedals and linkages
- What is wrong
- Vehicle description: vehicles equipped with certain haldex brake system two and four port relay valves. The valve may stick open when a high-pressure application is released.
- Risk
- When the valve sticks open, it can result in a total loss of air from either the service or the park brake system. The driver may lose braking ability under a service application, possibly resulting in a vehicle crash.
- Remedy
- Dealers will replace these valves. Owner notification began october 17, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.
Recall number 01V189001 · Recall details
Service brakes, air: antilock
- What is wrong
- Vehicle description: heavy duty trucks and school bus chassis built with bendix air ABS with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Risk
- This condition could cause the ABS ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- Remedy
- Dealers will replace the ABS ecu.
Recall number 00V232002 · Recall details
Power train: automatic transmission
- What is wrong
- Vehicle description: heavy duty trucks equipped with eaton autoshift gen ii transmission assemblies. Due to a software problem in the transmission assemblies, the transmission will select the wrong gear.
- Risk
- If an inappropriate gear is selected without the driver's knowledge, the vehicle will react differently than expected, possibly resulting in injury or crash.
- Remedy
- Dealers will replace the autoshift transmissions.
Recall number 00V131004 · Recall details
Suspension: rear: springs: air suspension system
- What is wrong
- Vehicle description: heavy duty trucks built with dual leaf spring type air ride suspensions and vehicles built with single leaf spring type air ride suspensions. Rear suspension springs can fracture through the center bolt hole after vehicle assembly.
- Risk
- If undetected, the rear end of the spring could separate from the vehicle causing a hazardous road debris situation.
- Remedy
- For vehicles equipped with single leaf springs, dealers will remove and replace all springs. For vehicles equipped with dual leaf springs, dealers will inspect for cracked springs and replace if cracked.
Recall number 00V081000 · Recall details
See all 6 recalls for the 2000 Freightliner Century
Defect investigations
Front brake air hose leaks
Certain 1998-2001 freightliner century and columbia vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage freightliner vehicles.the leaks have been frequently discovered at fmcsa roadside inspections since these inspections are conducted with the brakes applied (pressurizing the air hose) whereas driver pre-trip inspections may not always be performed with the brakes applied. After a thorough technical review of this matter,odi has concuded that while the subject vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage and peer vehicles, these leaks appear to be minor. Freightliner has extended the warranty for this component to 5 years, 500,000 miles and will assist in alerting those vehicle owners whose vehicles are most susceptible to front brake air hose leakage by issuing a service bulletin alerting those owners to the potential for front brake air hose leakage to occur. See attached report for full technical details.
PE03005
Integral hub and bearing assembly
Freightliner submitted a defect report on march 21, 2003 in which they identified approximately 5000 trucks as possibly beingaffected by this problem.arvinmeritor (front axle mfr) submitted a defect report onapril 16, 2003, which identifies 6098 freightliner trucks asbeing affected by this recall and 1191 axles sold to freightliner in the aftermarket. Odi notes that there are twointegral hub and bearing assemblies per front axle.freightliner identified vehicles includingfreightliner,sterling, and western star brand name as beingaffected by this recall.see attached summary report for additional details.
PE02088
Technical service bulletins for the 2000 Freightliner Century 14
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
- Warranty Information Letter
- Steering Intermediate Shaft Replacement
- Important Campaign Information on FL614 Recall
- Service Bulletin 9810- Chassis Paint Usage
- Operating Hours for the Customer Assistance Center
- Ss 1033638
- Sb2030 Surge Tank Breather Cap Leaking
- Sb2039 Cummins N14 Fan Drive Belt
- Sb2040 New-Style Coolant Hose Clamps Available
What 2000 Freightliner Century owners say
Most recent owner complaints, unedited.
Came across this site by word of mouth. Noticed that I've got soot residue in my vents. I've been having a flu like system that my dr couldn't diagnosis and claimed it might be allergies. My blood pressure has been going up and we've been adjusting the meds more frequently since I've been in this truck.
Don't smoke, coughing, waking up with headaches, pastout while in truck ,vomiting, tired all the time, what's going on here. I am in my 30's, this isn't right. I also have a family to take care of, will this cause me problems in the future (health wise).
When it rains water comes in on the passenger's side. The water comes in through the drip pan, per a glass company. Dealer stated it was not covered under a warranty.
Tractor failure, tie rod and king pins and bearings were all in poor condition. *bf
The driver side seat was altered by the manufacturer who disabled the full recline. As a result there was a greater chance of whiplash, spinal injury or driver ejection from the vehicle. The consumer has concerns about executive orders dealing with ergonomic workplace safety. Please provide additional information.
The intake for the heater/AC,is under the hood and is suppose to be sealed from the rest of the engine by a rubber gasket wich fits poorly and there are drain tubes that allow foul air from undder the hood (crankcase blowby,external oil leak burnoff) to be sucked into the cab,I have it happen almost every day with this truck sometimes the smoke is actualy visable in the cab,there is no evidence of exhaust leaking so it has to be blow by or fuel puddling in turbo at idle and being pushed out turbo seal and burrning off then by poor location of HVAC intake gets sucked into pass. Compartment. This is not my truck I am just the driver and I have brought this to freightliners att. And I might as well talk to a wall they said some of the trucks do that but we don't know why
The left front spring hanger is loose, causing the axle to shift.
Front spring hanger is loose on the frame, this is causing the axle to shift.
Front spring hanger is loose, this is causing the axle to shift.
Compare the 2000 Freightliner Century
Other model years
Questions about the 2000 Freightliner Century
Is the 2000 Freightliner Century reliable?
Owners have filed 15 complaints about the 2000 Freightliner Century, 3.8 times a typical Century model year.
What is the most common problem with the 2000 Freightliner Century?
Suspension, with 8 complaints. Next is body (2).
How many recalls does the 2000 Freightliner Century have?
6 recalls, covering suspension, steering and service brakes, air.
Was there a recall on the 2000 Freightliner Century suspension?
Yes, 2 recalls: 03V112000, 00V081000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2000 Freightliner Century?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history