2016 Freightliner Columbia technical service bulletins
412 technical service bulletins and manufacturer communications cover the 2016 Freightliner Columbia.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown
- Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown
- Warranty Information Letter for Detroit Bearing Failures
- Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps
- Technical Service Letter for Detroit Bearing Failures
- Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces
- Service Bulletin for Lengthening the Backup Light Harness
- Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink® 8.11 Standard and...
- Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy,...
- Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs)...
- Service Bulletin on guidelines for repairing or replacing an electrical harness.
- Service Bulletin for A/C system receiver-drier replacement guidelines.
- Service Bulletin revision that adds Century Class and Columbia models to the affected list for a Door...
- Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized...
- Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
- Warranty Information Letter updated to communicate warranty system updates.
- Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
- Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
- Service Information Bulletin regarding PTO Dosing
- Warranty Information Letter
- Training Solution created by DTNA to provide guidance to customers when searching for service information...
- Steering Intermediate Shaft Replacement
- Sb54311 ICU Odometer Programming
- Fp00024 Cable-Tie Reference
- Reminder: Paper Service Bulletin Mailings Are Discontinued
- Ss 1034171
- Important Campaign Information on FL614 Recall
- Service Bulletin 9818- Repainting Plastic Bumper Components
- Service Bulletin 9815- Paint Finish Standards
- Service Bulletin 9813- Side Fairing Primer Repair
- Service Bulletin 9817- Paint Supplier Change
- Emission Recall D18R5 GHG17 DD Platform Model Years 2016-2018 Software Reprogramming For California...
- Service Information Bulletin for Aftertreamtent Failure Guide
- DD13, DD15, DD16
- Important Warranty Information on AutoMeter BCT-460DTNA Powernet Assessment Tool: Warranty Requirement and...
- Release of DiagnosticLink® 8.08 Service Pack 2
- AirLiner Suspension Six-Piece Bolted Service Crossmember
- Operating Hours for the Customer Assistance Center
- Ss 1033638
- If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label
- Fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
- ICI18-014
- FL705 Bendix Rear Brake Calipers
- Sb00042 Flood Damage Repair GuidelinesB
- Sb0164 MBE Engine Support Information
- Sb0175 Replacing Drive Belts on MBE4000 EnginesB
- Sb1512 Accessories On When Key is OffB
- Sb2046 ABA Hose Clamp Torque Values
- Sb2052 Horton Drivemaster Fan Clutch Hub Bearings
- Sb2053 New Stainless Steel Lower Radiator Tubes
- Sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
- Sb4641 Adjusting Tilt Lock Force on TRW Steering ColumnsB
- Sb9815 Paint Finish StandardsB
- Sb31034 Towing ProceduresB
- Sb54122 ICU3 Service Cluster AvailableB
- Sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
- Sb54194 Required Maintenance for Freightliner-Branded and Delco Cassette Players
- Sb54202 Rerouting the DDEC IV Relative-Humidity-Sensor Harness
- Sb54278 Powernet Troubleshooting Guide Batteries, Path, Alternator, and Starter
- Sb54296 Fuel Level Sending Unit RetrofitB
- Sb98020 Axalta Paint Finish CareB
- Fp47019 25-Inch Diameter Fuel Tanks
- Computer Hook-Up Standard Diagnostic Time Update
- 17CSA25
- 17CSA24
- OWL Enhancement Service Model Field
- 17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am
- Warranty Classroom Training in 2018
- 17-026
- 17TL25
- 14CSA23 csc
- Towing Procedures
- Adjusting Tilt Lock Force on TRW Steering Columns
- Ss 1032974
- Fuel Level Sending Unit Retrofit
- Technical Publications Ordering
- Spn 3226 (ACM) (GHG17)
- Diagnostic tests
- Spn 96 (MCM) (GHG17)
- Spn 712 (CPC) (GHG17)
- Fuel System Integrity Check Routine
- Cylinder Liner
- Heavy Duty Engine Wastegate Repair Kit DKI470E16019
- Detroit? DT12? Transmission Proper Moving Procedure
- Spn 3556 fmi 0, 1, 18
- DD Heavy Duty Platform Belt and Belt Tensioner
- Detroit? DT12? Split Rod Bushing Repair
- Spn 1663 (CPC) (EPA07 10 GHG14 GHG17)
- Fmi 2
- Spn 521221 (TCM)
- Spn 521222 (TCM)
- Spn 4765 fmi 0
- GHG14
- GHG14 Intake Manifold Pressure Too Low
- (CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
- 0301-17
- 0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
- 0137-17 spn 3361 fmi 5 (ACM) (GHG17) spn 3361 fmi 5 (ACM) (GHG14)
- 0130-17 spn 520211 (IPPC) (GHG14) spn 520211 (IPPC) (GHG17)
- 0127-17 spn 1077 fmi 14 (GHG14) (GHG17) (MCM)
- 0120-17
- 0118-17
- 0115-17 spn 3226 (ACM) (EPA10;GHG14)
- 1213-16 spn 3480 (MCM) (EPA07;EPA10 GHG14)
- 1207-16 spn 4363 (ACM) (EPA10 GHG14)
- 16TS24 GHG14 dd
- 18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
- 18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
- 16TL20 heavy duty engine valve stem seal installing drift and sleeve
- 1021-16 spn 110 (MCM)(EPA07EPA07;GHG14), spn 110 (CPC)(GHG14)
- 1020-16 chassis fuel system isolation test
- 1018-16 symptom diagnostics - noise
- 1017-16 engine model and serial number designation
- 18SP713REV 18SP713 EPA10 DD13 three-filter fuel system to two-filter KM59 GEN1 fuel system conversion...
- FL718 front axle hub rating
- SB0006 freightliner courtesy engineering policy
- 16-032_DETROIT standard diagnostic time for GHG14 aftertreatment device checklist updated
- 0910-16 spn 3251 (ACM) (GHG17)
- 0909-16 excessive oil consumption
- 0905-16 spn 100 (MCM) (GHG17)
- 0901-16 spn 5927 (MCM) (GHG17)
- FP46907 steering intermediate shaft replacement
- 16TS16 detroit DT12 transmission oil and oil fill/drain plug washers
- 0810-16 symptom diagnostic noise
- 0809-16 symptom diagnostics : noisy 1- box aftertreatment
- 16TS14 EPA10 and GHG14 service replacement 1-BOX doc inlet change
- Clutch Release Bearing Grease Hose
- Been incorrectly shimmed at the factory, and may lean slightly to the right or left
- Fmi 3,4,5
- 15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
- 16TS9 dd
- 16TL4 doc
- 16TS8 DD13
- 16TL5 dd
- Warranty Recognition Program Suspension
- 16-011
- 16TS7 Reman Diesel Particulate Filter Serial Number
- 16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
- New Detroit Bearing Failure Analysis Standard Diagnostic Time
- 16-009R_OWL Enhancements
- 16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
- Canadian Warranty Parts Return Address Change
- 0307-16 spn 723 (MCM)
- 16TS5 Release of the DD Platform Bearing Failure Guide
- Contaminated Fluids
- Hydrocarbon Doser Coolant Lines
- 0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
- Vehicles built in model year 2016 use a bulkhead module (BHM) with a 500k auto baud rate
- Early EPA07 QLD Radiator Replacement
- Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
- 1210-14
- 1207-15
- 15TS4_Rev2_ EPA07 DD15 Piston Kits
- 15TL24 otc 1750
- 15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
- 14TS16REV excessive overhead engine noise on GHG14 dd platform engines
- 15R3 detroit axle steering arm capscrew replacement
- 18SP718 EPA07 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service kit
- 18SP720 EPA10 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service...
- 18SP720 EPA10 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service kit
- 18SP722 DD13 KM59 GEN1 bus two-filter system amplifier, needle and plv return fuel line clearance package...
- 18SP725 two-filter fuel system KM63 GEN2 DD13 high pressure fuel feed lines, mounting bracket and p-clips...
- AEO15M1 GHG14 dd platform software reprogramming for auto elevate
- 15R2 detroit axle steering arm capscrew inspection
- FINAL_15M1_BULLETIN GHG14 dd platform software reprogramming for auto elevate
- Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
- _NewDetroitCoolantLineSRTs
- _Warranty Recognition Program
- 15-028
- 805-15 fmi 0
- 803-15
- 802-15 spn 520970 fmi 7 (TCM)
- 801-15 spn 520999 fmi 7 (TCM)
- 15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
- 711-15
- 15TS14 GHG14 dd
- 708-15
- 706-15 spn 1323 (MCM) (GHG14) spn 1324 (MCM) (GHG14) spn 1325
- 703-15 GHG14 DD15 at
- 702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
- Sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
- Sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
- 704-15 spn 4364 (ACM)(EPA10)
- 15-017
- 15TS12 dd
- 15TS13 dd
- 512-15 GHG14 DD15 at
- 511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
- 509-15
- 508-15 spn 625 (mcm)( EPA10;GHG14)
- 507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
- 506-15
- 505-15 spn 3361 (ACM) (EPA10)
- 15-015
- 15-016-DLR
- 504-15 DD13
- 503-15 DD13
- 502-15
- Sb4654 Rack and Pinion Steering Gear Retrofit Guide
- 18SP716
- 501-15
- 15CSA9
- 15CSA10
- 15CSA4
- 15TS10Rev DD Engine Platform Coolant Filter
- 14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
- 406-15 spn 97 (MCM) (EPA10) / spn 97 (MCM) (GHG14)
- 405-15
- 404-15 spn 4364 (ACM) (EPA10)
- 403-15 spn 677 (MCM)(EPA07)
- 402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
- 15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
- Sb3133 Step Clamps Are Not Reusable
- 18SP717 DD13 EGR
- 401-15
- 15-010-DLR
- 15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
- 326-15
- 325-15
- 324-15
- 323-15
- 321-15 spn 4364 (ACM) (GHG14)
- 320-15 spn 4374 (ACM) (GHG14)
- 15-009_Detroit_New_SDTs
- 15TL5 davco
- 308-15
- 307-15 spn 3480 (MCM) (EPA07;EPA10;GHG14)
- 306-15 spn 3246 (ACM)(EPA10;GHG14)
- 304-15
- 15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
- 303-15
- 302-15
- Sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
- 18SP714 EPA10 DD15/16
- 18SP713 EPA10 DD13
- 18SP712 EPA07 DD15/16
- 18SP706
- 301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
- Sb54290 Guidelines for Repairing or Replacing an Electrical Harness
- 15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
- 0204-15
- 15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
- 0203-15
- 15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
- 0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
- 0201-15 spn 3250 fmi 31 - GHG14
- 15TS4 EPA07 DD15
- 15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
- 15TS1 GHG14 dd
- 0108-15 SPN 1323 through 1328 (MCM) (GHG14)
- 0107-15
- 0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
- 0105-15 spn 102 (MCM) (GHG14)
- 0104-15 spn 3464/ fmi 16, 18 (MCM) (GHG14)
- 102-15
- Sb9815 Paint Finish Standards
- 18SP687 DD15 16 EGR
- 0101-15 spn 4364 (ACM) (EPA10)
- 1110-14 EPA10 doc
- 1108-14 spn 636 (MCM) (EPA07;EPA10;GHG14)
- 1105-14
- 1104-14
- 1102-14 DD13
- 18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
- 18SP708Rev EPA07 10 Three-Filter Fuel
- 18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and...
- 1101-14 DD15 and DD16 Cylinder Head
- 14TS19Rev DD Platform High Pressure Fuel Lines
- 14TL8 TorcUP? Non-Impacting Torque Tool.
- 14-036-DLR dtna & jad
- 14-038
- 14-039
- 14-040
- 14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
- 14-039_additional_SDTs New Detroit Standard Diagnostic Times
- 14-038_New_SRTs Additional Detroit Standard Repair Times.
- 14CSA22 dtna
- 14WO-9_Warranty_Access Detroit New User Warranty Access Request
- 14TL9 Special Tool Warranty Program.
- 14TL7 dd
- 14CSA21
- 14CSA20 EGR
- 1010-14 spn 2623 (CPC) (GHG14)
- 1009-14 spn 5016 (ACM) (GHG14)
- 1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
- 14TS28 dd
- 1007-14 spn 5016/fmi 3, 4 (ACM) (EPA10)
- 1006-14 spn 4374 (ACM) (GHG14)
- 1005-14
- 1003-14
- Sb2080 Australian CST M1400 Isolated Radiator Retrofit
- Sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
- Sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
- 18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
- 18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
- 812-14 fmi 3, 4
- 14TS21 hdep
- 14-017R
- 811-14 fmi 7
- 809-14 fmi 3, 4, 5, 31
- 807-14 fmi 8 SCR
- 804-14 fmi 16, 18
- 803-14 fmi 16,18
- 802-14 fmi 3, 4
- 18SP703 18SP703 - GHG14 KM63 GEN2
- 801-14 fmi 19: rcm
- 14TL2 dd
- 14TL5 ABS
- 14-028
- 14TS18 GHG14 dd
- 14TS19 dd
- 14-027
- 14-026-DLR
- 719-14 spn 84 (CPC) (GHG14)
- 715-14
- 14-022
- 14-023
- 14-024-DLR dtna & jad
- 714-14
- 713-14
- 712-14
- 711-14 spn 107 (CPC) (GHG14
- 710-14 spn 96 (CPC) (GHG14)
- 709-14 spn 3216 (MCM) (GHG14)
- 708-14 spn 520219 (IPPC) (GHG14)
- 707-14 spn 520229 fmi 3 (IPPC) (GHG14
- 706-14 spn 171 fmi 3, 4 (CPC)(GHG14)
- 705-14 spn 520203 fmi 6 (IPPC)(GHG14)
- 704-14 spn 520200 fmi 6 (IPPC)(GHG14)
- 703-14 spn 3556 (ACM) (EPA10)
- 702-14 spn 520230FMI 5 (IPPC)(GHG14)
- 20-75 - canceled
- 20-73 - canceled
- 54-215 - ICU4M
- 18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
- 18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
- 18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
- 701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
- 14TS5 Replacing Damaged Aftertreatment Sensor Bosses
- 0228-14
- 14TS4 Valve and Liner Installation Tool Issue
- 13wo3rev2_final Actual Labor Hours on Detroit Claims
- 0224-14 spn 1590 fmi 9 - cpc
- 0219-14
- 0215-14
- 0210-14
- 0209-14
- 0202-14
- 0237-14
- 0233-14 spn 51 fmi 2
- 0229-14
- 0238-14
- 0239-14
- 54-274
- 54-278
- 54-277
- 35-30
- 33-28
- Sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
- Sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
- 12-039-DLR owl
- 12-040-DLR
- 12-041-DLR
- ICI12-028-DLR FL632
- 12-038-DLR
- Body SRT Updates -2012.12.12
- Sb4268 Brake S-Cam Tube Lubrication Interval Change
- Sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
- Sb3131 Huck-Spin 2 Changeover
- 12-022-DLR
- Sb4267 Brake Shimmy
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Freightliner Columbia?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history