1991 Geo Storm problems

Filed Jan 16, 2014 · Engine · 40,000 miles · NC

Tl* the contact owns a 1991 geo storm. The contact stated that the vehicle stalled while sitting at a traffic stop. The vehicle was taken to the dealer however, they were unable to repair the vehicle. The manufacture was made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 40,000.

Filed Jun 28, 2008 · Engine · 100 miles · CO

7 months and 5 replacement ecus on my 1991 geo storm gsi, and still has dangerous issues of stalling on highway and when pulling out into traffic. The problem is that between 1985 and 1995, AC delco used a insulative spray on the circuit boards in these ecus/computers which shrinks over time when exposed to warm and cool temperature conditions, such as the normal conditions that an automobile is subjected to. The shrinking insulative spray contracts and pulls the electronic components from the circuit board, breaking solder connections and causing shorts. The symptoms of this fault are most notably erratic idle, idle revving and dropping, idle dipping often with engine dying, idle hanging high above 2,000 RPM, and engine dying or stalling for no reason with no trouble codes. Gm knows about this fault in their AC delco ecus/computers and has even gone so far as to include supplemental instructions on how to test for shorts and broken circuits in the ecu/computer to their technical literature, though they refuse to repair or replace the problem at their own expense. Gm went further and began using a different insulative spray on all of their ecus/computers in 1996, though they do not use this new spray on their factory reconditioned ecus/computers for the geo storm models.

Filed Aug 8, 2005 · Electrical · 86,000 miles · PA

1992 geo storm manual transmission. When engine gets hot ( summer months ) engine idle increases to 2,500 - 3,500 RPM. Must use foot to pull up on accelarator. Car begins to overheat lurches forward. Car also stalls without warning. Heard it has to do with faulty ECM. Very dangerous situation.

Filed Oct 9, 2003 · OH

The e.c.u. Is bad in my 1991 geo storm 2+2. It is a common problem with these cars and gm will not do anything about it.

Filed Apr 17, 2003 · Engine · MN

The vehicle stalled without warning. The dealer replaced the distributor cap, spark plug wires and rotor, however the problem recurred.

Filed Nov 19, 2002 · Acceleration · ID

During warm weather the vehicle's throttle will stick at 2000. Through my research I have found this to be the fault of the ecu. It is a very dangerous thing to have your throttle stick. Dt

Filed Jun 25, 2002 · Acceleration · OH

Vehicle would intermittently lurch forward when brakes were applied. Dealer contacted. Feel free to provide any further information.

Filed Jun 25, 2002 · Engine · OH

Ongoing problem with engine stalling / cutting off while driving at multiple speed. Vehicle been to dealer, but problem reoccurring. Feel free to provide any further information.

Filed Jun 20, 2002 · Electrical · CO

This is the 2nd ECM control module in 2 years. . .both were new with only a year warranty. . .problem only shows up in the summer.

Filed Feb 28, 2002 · Electrical · MO

General motors used a shrinking sealant on the computer boards in these cars which they have since quite using and admit it was a problem, but still use it on the replacement parts when this shrinks it pulls the components on board loose, causing poor idle/ hesitation and stalling even during acceleration (ie when pulling out in traffic).