Tl*the contact owns a 1994 geo tracker purchased in 2004 as a fuel vehicle. While driving at various speeds of less than 30 MPH the vehicle began to smoke and stalled. He was misinformed as to which type of fuel to put into the vehicle and was told it was a diesel fuel vehicle. The contact complained that the "conduit of continuum of vehicular propriety." the dealer stated the carburetor and exhaust system failed and needed repairs at an estimated costs of $700. The failure and current mileages were 238,000.
The worst 1994 Geo Tracker problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Body18
- Suspension5
- Transmission5
- Seat belts4
- Seats4
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Body18
- Suspension5
- Transmission5
- Seat belts4
- Seats4
- Brakes3
- Electrical3
- Engine3
- Steering3
- Visibility2
- Acceleration1
- Fuel system1
- Lights1
- Tires1
- Wheels1
Recalls 3
Steering: steering wheel/handle bar
- What is wrong
- The steering wheel center hub to spoke weld can fracture.
- Risk
- This condition will allow the steering wheel to separate from the steering column increasing the risk of a vehicle accident.
- Remedy
- Dealers will inspect the steering wheel for the suspect steering wheel lot date code and replace any found to have this suspect date.
Recall number 96V118000 · Recall details
Suspension: rear
- What is wrong
- The right rear and left axle shaft housing tubes were incorrectly welded and can fracture. Fracture of the rear axle shaft housing can result in separation of the affected wheel assembly and separation of the brake line.
- Risk
- Separation of the wheel assembly can cause loss of vehicle control and separation of the brake line results in loss of one-half of the braking system, increasing stopping distance. In either case, an accident can occur.
- Remedy
- Dealers will inspect the welds of the rear axle assemblies on involved vehicles and, if necessary, replace the complete rear axle assembly.
Recall number 94V073001 · Recall details
Steering: rack and pinion
- What is wrong
- These vehicles were assembled with a lower steering shaft that can separate due to a mislocated weld.
- Risk
- If the separation occurred while the vehicle was in motion, a loss of steering control can result and an accident can occur without prior warning.
- Remedy
- Dealers will inspect the steering shaft and replace it if necessary.
Recall number 94V016000 · Recall details
See all 3 recalls for the 1994 Geo Tracker
Defect investigations
Rear axle housing failure
There is no summary currently available
PE94011
Technical service bulletins for the 1994 Geo Tracker 12
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This Preliminary Information communication provides information to the technician on how to unlock radios...
- This Preliminary Information communication provides information to the technician on how to unlock radios...
- Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
- Some customers may want to tow their vehicle behind another vehicle with all four tires ont he ground....
- Some customers may want to tow their vehicle behind another vehicle with all four tires ont he ground....
- Subject regarding upper door hinge loosens from body. tt
- 4-WHEEL drive low mode cannot be engaged/disengages (replace transfer case boot). sd
- Torque converter clutch (tcc) chugle/hunting condition. tw
- Torque converter clutch (tcc) chuggle/hunting condition. sd
- Product campaign 94-C-22 - reopening of campaign to inspect and repair rear axle housings that were...
1994 Geo Tracker fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 1.6L 4‑cyl | RWD | 21-22 | 22-24 | 21-23 |
| 1.6L 4‑cyl | 4WD | 21-22 | 22-24 | 21-23 |
What 1994 Geo Tracker owners say
Most recent owner complaints, unedited.
Right rear rides low. Rear right axle housing welds appear to be stretched and leaking. Vehicle brought to dealer for recall inspection (recall id the federal safety agency: 94v073001). Recall inspection of axle housing refused due to recall cancellation by general motors.
While steering the driver noticed that the steering wheel was hard to turn. A loud noise come from the steering wheel. Driver took vehicle to the dealer for inspection, and mechanic informed could not duplicate the problem. Driver informed the mechanic that a recall 96v118000 wa sissued for steering wheel and column. However, mechanic told the driver that this recall was not for this vehicle due to VIN.
Metal frame that holds windshield wiper motor is deteriorating. Dealer and manufacturer have been notified. *ak the vehicles body is defective. The area that holds the windshield wiper motor has rotted. This defect deprived consumer the use of the windshield wiper. Consumer does not feel this is a warranty issue. Consumer had no way of knowing this part was defective at the time of purchase.
While trying to use windshield wipers, was unable to use the windhsield wipers because bolts and arm that holds rubber wiper has corroded and became inoperable.
While driving 35-40 MPH, consumer hit another vehicle on the passenger side and shoulder belt did not restrain consumer, damage to vehicle unknown at this time. Consumer hit back of his head on windshield, also suffered injuries to lower back/chest/wrist and neck.*ak.
Vehicle was running very rough, vehicle was inspected by mechanic, who determined that engine blewout and needed to be replaced.
Upper hinge bolts came loose on driver side door. Have to lift door to close, and door doesn't latch properly. Also, door could come open.
Consumer was coming out of driver's side door when door fell off hinges. Screw actually come out of the body of vehicle. *ak
Driver's door top hinge broke, and door disconnected on top. *ak
Compare the 1994 Geo Tracker
Other model years
Questions about the 1994 Geo Tracker
Is the 1994 Geo Tracker reliable?
Owners have filed 48 complaints about the 1994 Geo Tracker, 24.0 times a typical Tracker model year.
What is the most common problem with the 1994 Geo Tracker?
Body and structure, with 18 complaints. Next is suspension (5).
How many recalls does the 1994 Geo Tracker have?
3 recalls, covering steering and suspension.
What gas mileage does the 1994 Geo Tracker get?
Official estimates for the 1994 Geo Tracker range from 21 to 23 mpg combined. The most efficient version (1.6L 4-cyl, RWD) gets 21-22 city and 22-24 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Geo Tracker?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history