Dt: 2004 georgie boy crush air - chassis freightliner xc. This is a full air brakes unit, someone has crossed the two air lines to rear axle under tension, and one sawed the other through in 9300 miles, the other within itself was nearly through. This is an metal armored cable, and this was at the initial build. This causes the air pressure to drop from 125 pounds which is normal to less than 60 within 30 seconds, complete air loss. This causes the emergency brake to go off, no matter what speed one was traveling. This did not cause any accidents only because consumer had hand on the emergency brake override.
The worst 2004 Georgie Boy Pursuit problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Body1
- Brakes1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Body1
- Brakes1
Recalls 4
Service brakes, hydraulic: fluid
- What is wrong
- Coachmen is recalling 2,555 my 2000-2009 georgie boy and coachmen recreational trailers equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver.
- Risk
- The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy for this campaign please see 09v‑110. The manufacturer has not yet provided an owner notification schedule. Owners may contact workhorse at 1‑877‑246‑7731 or coachmen at 1‑574‑266‑4030, option 5.
Recall number 09V193000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- Coachmen is recalling 13,662 my 2002-2008 motor homes, fifth wheel and travel trailers equipped with glass shower doors and manufactured from june 15, 2001 thorugh august 6, 2007. When pressure is applied to the towel bar on the glass shower door, the edge of the bar may contact the glass.
- Risk
- Glass breakage may occur which could cause personal injury.
- Remedy
- Owners will be provided with new mounting hardware for the towel bar and installation instructions. If an owner is not comfortable replacing the hardware themselves, a dealer will install the hardware at no cost to them. The recall is expected to begin on or about december 19, 2008. Owners may contact coachmen at 1‑574‑825‑5821.
Recall number 08V639000 · Recall details
Engine and engine cooling
- What is wrong
- On certain motor homes built on workhorse chassis and equipped with gm 8.1l v8 engines, improper hardening during the heat treatment process can cause the fuel rail pulse damper retainer clip to fracture, resulting in inadequate retention of the damper. If the damper becomes loose, fuel could be pumped by the fuel pump into the under hood area.
- Risk
- In the presence of an ignition source, a fire could result.
- Remedy
- Workhorse is handling the owner notification and remedy for this campaign (please see 06v225). Dealers will replace the fuel rail pulse damper retainer clips on these engines free of charge. Owners may contact workhorse at 877‑294‑6773 or coachman at 219‑825‑8528.
Recall number 06V352000 · Recall details
Electrical system
- What is wrong
- On certain motor homes built on workhorse chassis, fail to comply with the requirements of federal motor vehicle safety standard (fmvss) no. 101, "controls and display" and standard no. 105 "hydraulic and electric brake systems." models with actia instrument cluster, the incorrect software programmed into the cluster such that certain warnings are not displayed.
- Risk
- Incorrect software may not have the ability to illuminate warning lamps indicating brake system failures. The standards require driver warning when brake failure codes are set.
- Remedy
- Workhorse is conducting the owner notification and remedy for this campaign. Owners may contact workhorse at 1‑877‑294‑6773 or georgie boy at 877‑876‑9024.
Recall number 05V089000 · Recall details
What 2004 Georgie Boy Pursuit owners say
Most recent owner complaints, unedited.
2004 georgie boy cl a mh no metal in rear fender welds, just fabric under floor board rain water and exhaust fumes enter coach. Returned to service dealer.metal added. No recall on other units according to gbm because they felt not necessary. Took 3 months for repair. Other complaints too numerous.
Compare the 2004 Georgie Boy Pursuit
Other model years
Questions about the 2004 Georgie Boy Pursuit
Is the 2004 Georgie Boy Pursuit reliable?
Owners have filed 2 complaints about the 2004 Georgie Boy Pursuit, close to a typical Pursuit model year.
What is the most common problem with the 2004 Georgie Boy Pursuit?
Body and structure, with 1 complaint. Next is brakes (1).
How many recalls does the 2004 Georgie Boy Pursuit have?
4 recalls, covering service brakes, hydraulic, equipment and engine and engine cooling.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Georgie Boy Pursuit?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history