2021 GMC Acadia fuel system problems

Filed Oct 15, 2026 · Fuel system · OH

exhaust flex pipe is cracked. Causes fumes of gas to be released through the crack. inspected by GMC Repair shop Vibrating noise started, then a few days later the smell of gas, and now yes the Engine light is on. This has been on going for about 3 weeks.

Filed Oct 5, 2026 · Fuel system · VA

My 2021 GMC Acadia that has 63,768 miles on it was idling Wednesday 9/30 when it died and would not start back we had to have it towed to a shop to get it checked out and it was throwing the P023F code for the fuel pump control module that has a recall bulletin for the same thing make model problem and under their 80,000 miles but recall not on my vin number and GM is refusing to pay for it. It's going to cost me 937.27 to get it fixed.

Filed Sep 14, 2026 · Electrical, Fuel system · PA

While driving home from work the car displayed a "No Fuel" warning, despite having a full tank of gas. Within seconds of the display showing the car stalled out and stopped right in the middle of the road. It would not go into neutral and I had to be towed from the middle of the road to a mechanic close by. Upon reading forums online it looks like this is a known and common issue affecting the fuel pump sensor and system in these models. There are no open recalls but being this is known and happens so often I am shocked GMC has not taken ownership to recall and correct this issue. If I had not been on a slower road I could have gotten into an accident and, as I said, the car would not go in neutral so I couldn't even safely get off the road.

Filed Jul 18, 2026 · Fuel system · IN

I have seen numerous complaints for this same issue. My 2021 Acadia with 31,600 miles failed to start when parked in garage. It turned over just fine but wouldn't fire as if it wasn't getting any fuel. I had it towed to my regular mechanic. He troubleshot it and told me it was the "Fuel Pump Power Control Module". He said he could replace it but it would have to be programmed by a GM dealer as he didn't have the equipment to do that. So I had it towed to the local GMC dealer. Two tow bills equal $360. There is a recall for this issue. It is called "Emission Recall N252516900, Fuel Pump Power Control Module". part number 13554820 I have yet to receive a recall notice. I have seen mentioned in several of the other complaints that I have read that many of the service employees say that this has been an ongoing issue for several of the GM vehicles. Hopefully I will get a recall notice soon and be able to get reimbursed for the cost of the repair.

Filed Feb 19, 2026 · Fuel system · 46,000 miles · TN

The contact owns a 2021 GMC Acadia. The contact stated that while driving approximately 30 MPH, the vehicle started running rough before the vehicle stalled. The contact attempted to restart the vehicle, but the vehicle failed to restart. There was no warning illuminated. The vehicle was towed to a local dealer, where it was diagnosed and determined that the fuel pump module had failed and needed to be replaced. The dealer informed the contact that the part to do the repair was on backorder. The contact researched online and associated the failure with the federal safety agency Campaign Number: 20V639000 (Fuel System, Gasoline); however, the model year and VIN were not included in the recall. The manufacturer was informed of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 46,000.

Filed Jan 21, 2026 · Fuel system · 78,200 miles · MD

The contact owns a 2021 GMC Acadia. The contact stated that while the vehicle was parked, the vehicle started, and the contact exited the vehicle and ran into the house for a while. The contact stated that while reentering the vehicle, the contact noticed that the check engine warning light was illuminated. The contact was employed by an independent mechanic, and the vehicle was driven to the place of employment. The independent mechanic attached the mobile diagnostic tester to the vehicle and retrieved DTC: P023F, which indicated fuel pump secondary circuit failure. The contact was advised that the fuel pump module needed to be replaced. The vehicle was not repaired. The vehicle was not repaired. The contact referenced the federal safety agency Campaign Number: 21V422000 (Fuel System, Gasoline); however, the VIN was not associated. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 78,200.

Filed Nov 19, 2025 · Engine, Fuel system · 36,970 miles · RI

The contact owns a 2021 GMC Acadia. The contact stated that while his wife was driving at an undisclosed speed, the vehicle inadvertently lost motive power. The driver was able to coast to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the fuel pump control module. The vehicle was repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 36,970.

Filed Nov 7, 2025 · Fuel system · 35,500 miles · VA

The contact owns a 2021 GMC Acadia. The contact stated while driving 75 MPH, the check engine warning light illuminated. Additionally, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended. The vehicle was driven to the shoulder of the road. The contact stated while attempting to start the vehicle, the vehicle failed to start as intended. The contact stated that the failure had nearly caused the vehicle to be run over by a tractor trailer. The contact's wife and three minor children were also occupying the vehicle during the failure. The contact stated that he and his family could have been killed due to the failure. The vehicle was towed to the dealer, where it was diagnosed with fuel pump power control module failure. The contact was informed that the fuel pump power control module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact related the failure to an unknown recall; however, the VIN was not included in the recall. The failure mileage was approximately 35,500.

Filed Aug 25, 2025 · Fuel system · MI

My Acadia, 2021 has just 36011 miles. Car sputtered a few times like it was running out of gas and stalled as I was driving home in rush hour traffic. I couldn't even get it off the road. No warning lights or advance warning. Waited 3 hours for AAA (told 20 minutes) and then towed to dealer. Tow person could not get it into neutral so they used the sleds to ramp it up onto the flatbed. The dealer replaced the fuel module board which seems to be a common problem with these cars. Dangerous in that I thought someone might rear end the car while sitting in the single lane. Look on the Acadia forum and you'll see this is common and no recall has been issued and it sounds like it could very well happen again.

Filed Aug 21, 2025 · Fuel system · NE

I was driving down a heavy traffic expressway with a lot of semi traffic and the SUV started puttering. All of a sudden it died, the check engine light came on and I started to slow down quickly. I was in the middle lane of 3 lanes going 70 mph. VERY LUCKILY, I was able to pull to the right and barely made it onto the shoulder. The SUV had $28,972 miles on it. It was more that 100 degrees outside at the time. I called for a tow and had to wait over 2 hours. My car was nearly hit many times during the wait. The whole situation was very dangerous. What if my children were in the car at the time???? The tow truck driver was nearly killed while trying to get it on the truck. He had to call the police to block the lane. He stated that he could not put it in neutral and had to do something else with it to get it up. It was towed to the dealership where I purchased it. They did the diagnostics and said it was a fuel pump module issue. Less than 30,000 miles and this happened. I was planning to take a trip through the mountains, but at this point I do not feel safe at all in this vehicle. THIS SHOULD BE A RECALL IF GMC IS AWARE OF THIS ISSUE!!!!!