2024 GMC Canyon engine problems

Filed Nov 8, 2026 · Driver assistance, Engine · PA

I'm reporting several serious safety and reliability issues with my 2024 Canyon, including the collision avoidance system triggering sudden braking when reversing and moving forward, a roof damage incident from car wash blowers that required repairs, transmission shuddering and a sensation of locking during downshifts, repeated check engine lights with coolant issues, and limb mode events. These problems affect safe operation.

Filed Mar 9, 2026 · Engine · VA

Coolant leak caused by known manufacture defect in upper hose assembly causes coolant to drain and engine to overheat. CEL only comes on when coolant is almost gone. GMC refuses to cover the known issue after 36k miles.

Filed Mar 7, 2026 · Engine · SC

Coolant Leaking at 22K miles, smell of coolant, check engine light on and off 2X's. Coolant evidence on driveway and in engine cabin. Known condition for GM Model. No parts available for replacement. No recall for issue.

Filed Feb 27, 2026 · Engine · VA

Upper radiator hose connection to radiator is faulty causing leak of coolant. Yes it is available for inspection upon request. Truck began to run cooling fan at full speed in the middle of winter with no warnings of high heat or low coolant. After two weeks, check engine light finally cut on to indicate low coolant flow. Coolant reservoir was subsequently checked and found to be completely empty. It is apparent this reservoir had been extremely low / empty for at least two weeks with no warnings. Without proper warning and leaking coolant, truck could have overheated. Should this had happened in dead of summer, truck could have very well overheated with no warning. The problem was investigated and confirmed by dealer as leaking coolant at the connection of the upper radiator hose to the radiator. Was quoted $983 to replace the hose. No warning lights appeared until issue had been ongoing for over two weeks. A quick search of "GMC Canyon Upper Radiator Hose" will reveal many identical occurrences of this issue. This is a safety hazard / design flaw that GM is not acknowledging and is putting the burden on the vehicle owners for their own issue.

Filed Feb 14, 2026 · Brakes, Electrical · HI

On 2 occasions the battery was drained and a tow truck had to jump the battery. On one occasion after the battery was jump started it took several hours before the brakes were able to be used and the car driven safely. Had to drive very slowly (under 50 mph) per note that appeared on dashboard. After nearly an hour of waiting Engine light stayed on and dealership ran diagnostic and found nothing wrong with the battery nor anything else. Have to start and run engine everyday to keep battery from dying. If not started in 24 to 36 hours, battery will die.

Filed Jan 19, 2026 · Engine · IN

Upper radiator hose attachment is leaking due to faulty rubber gasket. This comes up across GMC Canyon groups on Facebook 10 times a day. It is happening to ALL of them mainly pre 2025 on 3rd gens. Part is on back order at all GMC dealers due to so much volume of issue. Happening as early as 10k-20k miles on brand new trucks causing over heating issues due to coolant leaking out. Hopefully a recall for the part is done before engines start blowing.

Filed Jan 19, 2026 · Engine · VA

There are widespread reports of the O ring seals on the radiator and heater hoses failing and causing coolant leaks. These leaks are significant enough to render the vehicle inoperable and with no cabin heating or cooling. This could lead to life-threatening situations in adverse weather conditions. It could also create dangerous roadside failure situation in heavy traffic, particularly on interstate highways. Dealers are aware of the issue and are currently repairing vehicles under warranty. However some dealers are telling owners that the cooling system is not part of the engine and drivetrain, and therefor is not covered under the original factory warranty if the vehicle has exceeded the initial bumper to bumper warranty limits. Dealers are also telling owners that parts are on backorder due to high demand, and that repair wait times could take weeks. The vehicle is unsafe to operate with a known coolant leak. Video of leak (another owner) here. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 14, 2026 · Engine, Transmission · TX

Truck began idling very rough. Went straight to the dealership. They shut the truck off and it would not restart. No CEL or messages on the dash. Tear down reveled a failed exhaust valve in cylinder #4. Truck has 10,000 miles. A replacement engine has been ordered under warranty. Luckily, we happened to only be a few miles from a dealership when the failure happened. There was no warning, no prior symptoms what so ever.

Filed Dec 30, 2025 · Engine · MO

Upper radiator hose leaks where it connects to radiator. 40k miles and my truck has no coolant

Filed Nov 7, 2025 · Acceleration, Engine · CA

I've noticed an issue since I picked up my vehicle from its last service where the RPMs stay around 1,000 when I let off the gas and should be coasting. The vehicle will continue to accelerate at 11 to 13 mph, and I really have to mash the brake pedal to stop. There is an update notice that popped up starting yesterday, but it will not install. Looks like the update is for the issue I am having. The update was supposed to be installed already per the service bulletin. Update number is N242452130