My 2004 gmc envoy xl slt is leaking gas at the gas tank and the filler hose gas just runs down the tank to the ground its a fire risk
2004 GMC Envoy XL fuel system problems
28 complaints (15% of all complaints for this car). Typical mileage when it fails: 101,000.
- owner complaints
- 28
- of this car's complaints
- 15%
- typical mileage
- 101,000
- crashes
- 0
- recalls
- 0
Which part fails
- Storage: tank assembly3
- Delivery: fuel pump2
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
GMC Envoy XL fuel system problems in other years
Specific symptoms reported on the 2004 GMC Envoy XL fuel system
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
No recalls on record for this model year.
Related investigations
Fuel pump module leaks gasoline
During the course of this ea investigation, odi observed that the majority of the complaints (88%) and warranty claims (94%) were reported for vehicles that are registered for use in the salt belt region of the us.this area includes 20 states in the northeast, mid atlantic and the midwest regions and the district of columbia.consumers in the salt belt region reported to odi that they could smell fuel vapors in their vehicles while driving.upon further examination of their vehicles, they discovered that fuel vapors were coming out of the top of the fuel tank. This condition is caused by corrosion of the return and sender lines of the fuel pump module.water and road salt collect on top of the fuel pump leading to small pinholes appearing on the fuel lines.fuel may leak and collect on top of the module and/or spill onto the ground.the data evaluated under this investigation reflect a relatively low frequency of occurrence that largely arises in salt belt states.gm has extended the warranty on the subject component to ten years or 120,000 miles.further use of agency resources does not appear to be warranted at this time; accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by the federal safety agency that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.for additional information select document search.
EA07009
What 2004 GMC Envoy XL owners say
Most recent owner complaints, unedited.
I was driving and my vehicle on I-985 hall county ga. My check gage light came on and less than 1/2 of a mile it start to smoke and burn as soon as I stopped turned of the ignition. It burnt to the ground from the engine area to the inside.
Vehicle was taken in for oil change and I was advised it had a crack at the neck of fuel tank. Upon further research there has been a recall for this very same problem on the same vehicle. Vehicle was never in a accident or anything that would cause this.
The gas tank has a lose connector that leaks and allows fumes to escape.
Special coverage adjustment fuel tank inlet check valve fracture #07099a. Issued august 24, 2007. My 2004 gmc envoy is now experiencing this problem. I was never notified of this as gm claims they did not know I was the owner of this car. I bought it used in 2005. I was told by a mechanic when I took it in to check out the problem that I should not fill the gas tank full as it could cause gas leakage. I am also facing an expensive bill to get this fixed. A recall was never issued and it appears this is a life safety issue. I would appreciate your attention in this matter.
Tl* the contact owns a 2004 gmc envoy xl. The contact stated that while driving approximately 30 MPH, she noticed that the fuel gauge reading was fluctuating while the fuel tank was full. The engine then suddenly stalled due to the faulty fuel gauge. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the problem. The approximate failure mileage was 101,000.
My gmc's service engine soon light went on and I took into the shop. They stated that there is a fuel issue for the fuel cap and that the fuel tank needs to be replaced because it leaks. This is a manufacturers defect and this part should never "wear out" over time or due to the number of miles driven. Gmc needs to stand behind their vehicle and replace this part for free!
The fuel tank neck where the fuel goes into the vehicle, then down to the gas tank, has in the plastic & leaks fuel & gas vapors so the check engine light is always on. My mechanic said there is no way to fix this without purchasing a new fuel tank since this is all one piece.
Due to the check engine light constantly coming on I was told that I needed a new gas cap. It was stated if the cap is not on properly it affects the emission controls. I have replaced the gas cap several times nothing has changed engine light goes on and off. There still has not been accurate justification for this matter. Vehicle has faulty / leaking air bags on the rear suspension. Upon research this has been a problem on gmc vehicles from 1994 ~ 2006. Why are there no recalls? Gmc envoy vehicle are sitting very low during freezing temperatures. Upon starting the vehicle it will raise back up and level itself but it should not drop down low period. Websites are flooded with complaints. I have contacted gmc regarding all these issues and nothing has been done. I was told there were no recalls regarding these matters which I don't understand. I have viewed so many complaints on several websites regarding these same issues. Exterior lights~ lamps have faulty sockets due to moisture getting inside the lamps / back up lamps. Bulbs burning out continuously. Unfortunately when you take your vehicle to a frequent dealer, many times they'll step outside to check your vehicle quickly without putting you in the system if they feel no service is required. I believe this may be why these complaints are not being addressed/ reported / or recorded. It is apparent there are serious problems with these vehicles. Something needs to be done, and we should not have to deal with repeat manufacturer defects/hazards year after year. It is not fair to us (the customer). They can continually contact you to trade in your vehicle or buy it, but they can't contact you regarding defects on the vehicle. I was told they only notify the original owner of recalls. Again they'll contact you regarding marketing and advertising. Thank you in advance for your time and consideration.
My envoy has had the check engine light on for years, and the smell of gas, went to gmc and they said need new gas cap, didn,t work, went to another car repair need new gas cap, same thing over and over again, every month on my onstar report, said I had emission problems, they tested the car, looks like it could be you need a new gas cap..... A few months ago my gmc would not start, call aaa to pick up envoy and take in the charles shop near my home.... As the auto was being put on the trailer, I saw gas dripping from the area of the gas tank....went to charles repair to them about what I saw and explained that for you I have been trying to find out what was wrong with the gas cap, and the smell of gas... Well the checked it out and found my gas tank had a crack in it and I would need a new gas tank cost around $900.00, I paid them for the starting problem that they fixed and took the gmc home, I live in florida and I was reading the sunday paper and there is an article, about gmc recalls, about how the warm weather states having a problem with a plastic part might crack and cause a fuel leak..well this is what happened to my gmc, how do I get my car repaired by gmc, what can I do to get it fixed, I only put $20 to $30 of gas at a time ,in the car because I don't want gas leaking and might cause a fire. Help me please.
Questions about the 2004 GMC Envoy XL fuel system
Does the 2004 GMC Envoy XL have fuel system problems?
Owners have filed 28 complaints about the fuel system of the 2004 GMC Envoy XL, 15% of all its complaints.
At what mileage do 2004 GMC Envoy XL fuel system problems start?
The typical (median) mileage in owner complaints is 101,000 miles.
Was there a recall on the 2004 GMC Envoy XL fuel system?
There is no recall for this problem on this model year.
What year does the GMC Envoy XL have the most fuel system problems?
The GMC Envoy XL model years with the most fuel system complaints are 2006 (71 complaints), 2003 (63 complaints) and 2004 (28 complaints).
Other 2004 GMC Envoy XL problems
Electrical 81Engine 20Transmission 20Lights 12Visibility 10Acceleration 9Airbags 7Brakes 6Body 5Tires 5Seats 4Seat belts 3Steering 3Locks 2Suspension 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 GMC Envoy XL?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history