Tl* the contact owns a 2005 (na) gmc envoy xl. The contact stated that the low beam headlights failed to illuminate. The contact was able to drive home with the high beams activated. The vehicle was taken to an independent body shop and the mechanic stated that the low beam lights needed to be replaced; however, the contact was not advised as to what caused the failure. The vehicle was not repaired. The manufacturer stated that the vehicle was not included in the federal safety agency campaign number: 07e014000 (exterior lighting). The failure mileage was 129,000.
2004 GMC Envoy XL lights problems
12 complaints (6% of all complaints for this car). Typical mileage when it fails: 117,000. 1 crash reported.
- owner complaints
- 12
- of this car's complaints
- 6%
- typical mileage
- 117,000
- crashes
- 1
- recalls
- 1
Which part fails
- Turn signal3
- Headlights3
- Brake lights1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
GMC Envoy XL lights problems in other years
Specific symptoms reported on the 2004 GMC Envoy XL lights
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Exterior lighting: brake lights
- What is wrong
- On certain sport utility vehicles, vibration and heat may cause the tail lamp/stop lamp bulb to loosen in its socket. If this occurs, the bulb may flicker and eventually become inoperative.
- Risk
- An inoperative brake lamp will not convey the driver's intention of stopping to drivers in following vehicles, and an inoperative rear turn signal lamp will not convey the driver's intention to turn to drivers in following vehicles. Both of these failures can increase the risk of a crash.
- Remedy
- Dealers will inspect the tail lamp/stop lamp assemblies, and if necessary, replace them. The recall began on november 22, 2004. Owners should contact chevrolet at 1‑800‑630‑2438, oldsmobile at 1‑800‑630‑6537, buick at 1‑866‑608‑8080, or gmc at 1‑866‑996‑9463.
Recall number 04V527000 · Recall details
Related investigations
Loss of Headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at under the identification numbers in the attached document.
RQ17002
Turn signal failures
By letter dated april 29, 2005, gm notified the agency that it is conducting asafety recall ( the federal safety agency recall no. 05v198 ) involving certain model years (my) 2003-2004 isuzu ascender, chevrolet trailblazer, gmc envoy, oldsmobile bravada and my 2004 buick rainer vehicles.the recall applies to vehicles built from april 2003 through november 2003 for a total vehicle population of 286,478.gm reports the directional/hazard signals failure is due to sticking contacts on routing relays in the flasher module.gm will replace the flasher module on all involved vehicles.based on gm's safety recall action, this investigation is closed.
PE05006
Brake lamp failure
Gm states that some brake/tail lamp bulbs can prematurely become inoperative due to malfunctioning brake/tail lamp sockets.on march 2, 2004, gm initiated a 6-year/72,000 mile special policy for 989,487 subject vehicles to inspect and replace the rear brake/tail lamp bulb socket assemblies.on april 4, 2004, the office of defects investigation (odi) opened a preliminary evaluation (pe04-032) based on consumer complaints alleging brake lights not operating when the brake pedal is depressed.on august 3, 2004 odi upgraded pe04-032 to an engineering analysis (ea04-021).by letter dated october 27, 2004 gm notified the federal safety agency that it will conduct a safety recall (the federal safety agency # 04v527) covering subject vehicles that were not already repaired under gm's special policy.my 2004 subject vehicles built after august 8, 2003 contain improved brake lamp assemblies and are not included in the recall.gm dealers will install the improved brake lamp assembly on subject vehicles built on august 8, 2003 and earlier.the action taken by gm is sufficient to resolve the issues raised by this investigation.accordingly, this investigation is closed.
EA04021
What 2004 GMC Envoy XL owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 2004 gmc envoy xl. While driving various speeds, the turn signal indicators became inoperable without warning. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 184,000.
Tl* the contact owns a 2004 gmc envoy xl. While turning the ignition to the on position, the headlights failed to activate. The vehicle was taken to a dealer where it was diagnosed that the headlight driver module needed to be replaced. The vehicle was repaired. The failure recurred numerous times. The manufacturer was not made aware of the failure. The failure mileage was approximately 117,000.
Tl* the contact owns a 2004 gmc envoy xl. The contact stated that the interior lighting on the front driver?s side door would dim and illuminate intermittently. The vehicle was not repaired and the manufacturer was not notified. The approximate failure mileage was 99,700. Updated 8/12/14*cn the consumer believed there was a short in the wiring. Updated 09/23/14
I purchased this vehicle 10 months ago and have to replace the headlights 9 seperate times not including the brake lights 5 times. After the 3rd time the man at the auto parts store stated this is a known problem with gmc> the lights get too hot and burn up the bulb and the connectors. I have had 2 buy now 4 rabbits connectors and they make the bulb last a little longer but the exspense is sad. If this is a known problem and it is posted all over the interent from customers with the same issues why has not recall beem placed for these lights. If it is heating hot enough to melt a connector that is a fire hazard and needs to be recalled. Now my speedometer stoped working and to my surprise I wass advised this also a common gmc problem with the cluster repair being required to fix it.
High beams on vehicle project straight up to the sky. When weather is clear it is not noticeable but when raining, foggy or snowing visibility is affected a great deal. My internet search indicated a problem with an aftermarket headlamp assembly but mine are gm stamped. This is definitely a safety issue.
2004 gmc envoy slt- headlights go off with no warning at night- happened on a dark road, almost went in a ditch- also, speedometer does not work.
I traded my 2005 ford focus 26410 miles to wade raulerson gmc on october 3, 2007 wrote two checks in the amount of 500.00 each that they held for four weeks for a down payment. We looked at a 2004 gmc envoy with 65,000 miles the salesman quoted us a price of 17,000 so we did the paper work the first time on the 16th we were called in again and told we had to sign more documents this time the price of the envoy rose to 21698.35, I asked about my 05 focus was told it sold the next day and we had to have gap protection. Payoff on my car was 12,502.95 and it looked as if they were giving me 14900.00 but raised the price of the truck by 4000.00. Bad deal to begin with. The problems began. I had to return it at the end of the month in october 2007 to have the headlights, seatbelt, and motor in the window replaced, and diagnosed to find why the service engine light will not go out. Two weeks later stranded at the daycare I had to buy a new battery. On 05/05/2008 the conditioner went out. I paid the dealership over 100.00 to tell me it would be an additional 600.00 plus dollars to repair the mode actuator door motor. October 17, 2008 I spent 375.02 to have both the shift control cable and gear shift lever removed and replaced. Thank god I was actually on a parking lot when the cable broke and not in traffic. Contacting wade raulerson gmc has been useless I have practically been told you bought the "lemon" as-is now it's your troubles! There should be a law against this type of business and not just for new cars. Now no-one will touch it because of the problems it is having and the large amount that's now owed. Every time the VIN is pulled I get pushed out of the door faster than I can blink. Btw the service engine light is still on and has been since I left the dealership. I?m tired of honest hard-working people being raked over the coals by unscrupulous dealers while they get protected by the "as-is" rule then laugh all the way to the bank.
Problem with brake light not coming on. The fuses and tail lights have been checked; all fuses and bulbs are functioning. This is hazardous and dangerous while driving, for myself as well as unsuspected drivers behind me. This will also create problems with law enforcement for me or anyone operating this vehicle.
When there is moisture in the air, the headlights will cast a beam of light straight up in front of the vehicle when headlights are on high. It doesn't matter if it is rain, snow or fog, it is enough of a hazard to cause you to not be able to see what is in front of you. Then, you have to drive on low beam and this can also be a hazard due to the overrunning of the headlights. This is a very dangerous condition. This 2004 gmc envoy xl has done this since day one. I have called gmc and told them about this problem. I like this vehicle, I'm just concerned that a potential bad accident can happen as a result of this problem.
Questions about the 2004 GMC Envoy XL lights
Does the 2004 GMC Envoy XL have lights problems?
Owners have filed 12 complaints about the lights of the 2004 GMC Envoy XL, 6% of all its complaints.
At what mileage do 2004 GMC Envoy XL lights problems start?
The typical (median) mileage in owner complaints is 117,000 miles.
Was there a recall on the 2004 GMC Envoy XL lights?
Yes, 1 recall: 04V527000. Check your VIN to see if your car still needs the free repair.
What year does the GMC Envoy XL have the most lights problems?
The GMC Envoy XL model years with the most lights complaints are 2003 (16 complaints), 2004 (12 complaints) and 2002 (11 complaints).
Other 2004 GMC Envoy XL problems
Electrical 81Fuel system 28Engine 20Transmission 20Visibility 10Acceleration 9Airbags 7Brakes 6Body 5Tires 5Seats 4Seat belts 3Steering 3Locks 2Suspension 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 GMC Envoy XL?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history