2022 GMC Sierra 1500: fuel pump failure

Filed Oct 12, 2026 · Electrical, Fuel system · FL

The Fuel pump modular system failed leaving me unable to start the vehicle and left me stranded in the [XXX] heat for hours. The vehicle only has 57k miles. There was a recall for this specific issue for many GM vehicles but not mine. There was no warning! It has been towed to Sheehan Buick in [XXX] and diagnosed as the Fuel pump Modular system but I am being told it is not covered under the recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 8, 2026 · Fuel system · FL

Fuel pump module went out while driving on expressway engine had reduced power maximum speed uphill was 10 mph vehicle drove fine when on flat ground. Extremely unsafe spot to not be able to accelerate.

Filed Sep 12, 2026 · Fuel system · MD

I am filing this complaint regarding a potentially serious safety defect involving my 2022 GMC Sierra 1500 Denali four-wheel-drive with the V8 5.3 engine. The vehicle had approximately 28,786 miles at the time of the incident. While traveling on an interstate highway in heavy traffic, my truck suddenly lost engine power. I was extremely fortunate that I was able to maneuver through traffic and get the vehicle onto the shoulder without being struck by another vehicle. A sudden loss of engine power under these conditions could easily have resulted in a serious or fatal collision. Immediately follow the incident Onstar detected diagnostic trouble code P129F The vehicle was subsequently taken to an authorized GM dealership. The dealership diagnosed the problem and replaced the fuel pump power control module to repair the vehicle. I have since learned that General Motors issued service bulletin 24 –NA-139 concerning this condition. The bulletin specifically includes 2022 GMC Sierra 1500 vehicles and identifies loss of power stalling and DTC P129F among the possible symptoms. GM states the condition may be caused by an internal short in the K111 fuel pump driver control module/fuel pump, power control module. I am particularly concerned that GM has been aware of this potential failure condition since at least 2024. A failure capable of causing a vehicle to suddenly lose engine power while traveling at Internet speeds presents amsafety hazard not only to the occupants of the affected vehicle but also to surrounding motorist. I respectfully request that the federal safety agency review this issue including other owner complaints involving error code P129F, fuel pump power control, module failures, stalling, or sudden loss of power in affected GMC Sierra and related to GMC vehicles and determine whether a safety defect investigation or recall is warranted. Vehicle: 2022 GMC Sierra 1500 Denali four-wheel-drive Engine: 5.3 L V8

Filed Sep 10, 2026 · Fuel system · 31,298 miles · SC

The contact's son owns a 2022 GMC Sierra 1500. While the contact's son was driving at an undisclosed speed, the vehicle stalled and the engine seized. The driver attempted to restart the vehicle, but the vehicle failed to restart. The vehicle was towed to an independent mechanic, where it was diagnosed with a fuel pump drive module failure. The contact was informed that the fuel pump drive module needed to be replaced. The vehicle was repaired. The contact stated that the failure was a known failure with the vehicle. The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 31,298.

Filed Aug 30, 2026 · Transmission · TX

Truck died while driving on a major highway due to a faulty fuel pump module. The vehicle was blocking an intersection. The vehicle could not be put into neutral without the engine running because of the electronic transmission. Could not move the vehicle out of the intersection and out of traffic. I found out later that to put the truck in neutral requires a special tool, and going under the truck to engage the bypass, which is very difficult and unsafe on a major roadway.

Filed Aug 25, 2026 · Driver assistance, Electrical · TX

I am filing a formal safety complaint regarding my 2022 GMC Sierra 1500 Denali (5.3L engine). This vehicle has exhibited a pattern of severe electrical, fuel system, and active safety sensor failures that pose a direct threat to occupant and public safety.At approximately 4,000 miles, the high-pressure fuel injectors suffered an early-stage mechanical failure requiring dealer repair.At approximately 24,000 miles, the vehicle suffered a catastrophic, un-warned total power shutdown while driving in the middle of active, fast-moving 5:00 PM rush-hour traffic on a 100-degree day in [XXX]. The vehicle completely stalled, causing a loss of standard driving capabilities and leaving the occupants stranded without air conditioning or cabin ventilation in an incredibly high-risk, live-traffic environment. The dealership attributed the failure to the fuel pump switch/control module.The vehicle's active safety framework is deeply compromised. The forward-facing front collision camera and its integrated crash-avoidance sensors have completely failed and required a minimum of three (3) separate repair interventions, yet the safety system remains broken and unreliable.The vehicle exhibits phantom electrical bugs. The MultiPro tailgate audio system consistently turns itself on while the vehicle is parked, locked, and closed, hijacking the driver's phone Bluetooth from inside the home. While driving down the road, the internal cabin radio will abruptly cut out and begin blasting audio through the exterior tailgate speakers, creating a severe driver distraction. The dealership has repeatedly dismissed these electrical safety anomalies as untraceable.3. Activating Your Texas Consumer Rights INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 26, 2026 · Fuel system · GA

While driving enroute to a concert in [XXX]., in the passing lane on [XXX] around [XXX] & just before exit 22(mile marker 21) during rush hour on 7-23 at 5.09pm, my truck abruptly lost power and shut off! It would not start, I could not engage "N" from "P" to attempt to push my truck to the far left side of the highway. This was a "VERY DANGEROUS" situation as I could have been rear ended or much worse! I immediately called SOS/ON STAR for assistance. In the meantime, a police officer and state troopers showed up to divert the traffic around my truck. Eventually, a "HERO" vehicle showed up and at the direction of the police, my truck was "DRAGGED" from the passing lane to the emergency lane. As for getting a tow truck, 1 finally showed up after 5+ hours. I found out the you all have a contract with "AAA", which is the worse when it comes to getting any assistance. I was towed back to [XXX] to South Town GMC dealership & arrived at 11.25pm. It was only the next morning that I received an email from OnStar dated 7-23 at 5.07pm, with an "Advance Diagnostics" advising of a critical issue with the engine & transmission. The code was: P129F, which is the fuel pump and/or module. My truck now sits at the dealership with a dead battery, waiting for them to address. I have heard that there are issues and recalls in certain vehicles with this similar issue. I do have "extended warranty" protection thru Ally that I bought. However, the shock is finding out that the only way to get it into "N" is a special dealer tool that goes into the transmission under my truck! Are you SERIOUS??????? To have no ability to put my truck into "N" is not only unacceptable, but extremely dangerous. Especially with what happened to me & my family. At this point, I am at the mercy of my dealership to find the time to address this issue. Until then, I have no transportation & very upset with the stress of all that happened! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B

Filed Mar 18, 2026 · Engine, Fuel system · MO

Bought truck 0n 12/26/2025 from lot in Michigan had it transported to Missouri. First time I drive it Check Engine comes on and goes into "Limp Mode". Had it towed to GM Dealer and they say it was the high pressure fuel pump. Got it back and check engine light comes back on then goes off then back on again. Not happy at all!!!

Filed Mar 17, 2026 · Engine, Fuel system · FL

While driving on the road the vehicle started sputtering and stalled! We pulled to the side of the road and tried to start the car but it rolled and would not start. We called a a mechanic who had it towed and found out that the fuel pump and the fuel control board had failed. Both have been replaced and the truck seems to be working again. Heard several other persons had this issue with their GCM Sierra Elevation so we wanted to report since there is currently no recall. Luckily the traffic was not going that fast or we could have had an accident and been seriously injured.

Filed Aug 16, 2024 · Fuel system · FL

“Faulty fuel pump driver module” part Not available for inspection. Repaired at dealership and they kept the part. While driving 75 mph on the interstate during high traffic time my GMC Sierra 3.0 diesel truck engine shut completely down, not just once but on several occasions putting myself and three other in a life safety situation due to the traffic around us at the time. I had to navigate the truck through traffic and off the road. Once there the vehicle was turned off allowed to sit for a few minutes and restarted. The vehicle would restart and we continued only to have this scenario repeated again several times. Faulty fuel module was diagnosed by mechanic at dealership and replaced. Part was not inspected by no one to my knowledge except the mechanic. There was no prior warnings before this incident happened. After the incident the engine light came on with a message that stated check ESC.