2016 GMC Terrain engine problems

Filed Aug 14, 2026 · Engine · WI

The timing chain snapped and caused the engine to seize on our 2016 GMC Terrain 2.4L SLC-1 SUV/Truck. Since this has occurred multiple times on the 2.4L engines in this model from 2012 - 2016, we believe that there should be a recall as this issue could cause a major accident if the timing chain snaps or breaks while traveling. It had 101000 miles on it when we bought it used from Klein Automotive, on April 12, 2024. We have only had it for 2 years and 4 months and kept it in good repair. We took it in for its oil change, brought it home, went to dinner 4 days after and the very next day it wouldn't start. We thought it was most likely the starter/solenoid, but the mechanic said those were both fine and that's when we got the bad news that the motor was shot because the timing chain broke which caused some engine rods to break. The GMC dealer, in Marinette, WI, we brought our used 2016 GMC Terrain to, told us that the timing chain stretched and broke the rods in the engine and therefore both the timing chain and engine need to be replaced. The check engine light was turning on all of the time, and we were told that it was because it needed the 88 fuels (medium grade). As long as we put in the 88, the light check engine light stayed off. We believe there should be a recall for the 2012 - 2016 GMC Terrain SLC-1 2.4L timing chain and engine. We also need assistance with the cost of the repairs because I'm on a limited income and cannot afford the $10,000 cost of getting this repaired, while I still owe $7800 on it.

Filed Jun 5, 2026 · Engine, Transmission · NC

My 2016 GMC Terrain 2.4L Ecotec first stalled while idling at a red light in Raleigh, NC. I restarted it and it sounded different, so I drove it home. The next morning it would not start. The failure occurred at approximately 69,939 miles with no meaningful warning. The dealer’s diagnostic report states there were no current relevant codes and no relevant codes in history. The dealer documented major timing-system failure: timing chain tensioner failure, timing chain guide failure, a timing chain guide bolt pulled out of the cylinder head, aluminum contamination in the cylinder head/oiling system, and engine replacement recommended. The vehicle was found unsafe to operate. This vehicle regularly transported my family, including my children. If the stall/no-start failure had occurred at highway speed, while merging, or in heavier traffic, it could have created a serious crash risk. The oil was maintained outside the dealership network and had been serviced before failure. I also topped off the oil shortly before this occurred. The 2.4L Ecotec engine family is known for oil-consumption issues, yet this vehicle gave me no direct warning that oil consumption had reached a dangerous level. A reasonable owner would not know to check oil every day when there were no relevant stored warning codes. Other the federal safety agency complaints involving 2016 GMC Terrain vehicles describe similar patterns: oil consumption, no warning lights, sudden stalling or no-start conditions, timing-chain failure, and engine replacement recommendations. I am filing because this appears to be an ongoing safety risk involving oil consumption without adequate warning, timing-chain/timing-guide failure, internal contamination, and sudden engine failure. I request the federal safety agency review this issue for investigation or recall expansion before this failure mode causes a preventable serious crash, injury, or fatality. The vehicle was inspected by a GMC dealer and remains unrepaired.

Filed Apr 22, 2026 · Engine · IA

My vehicle started turning off suddenly when stopped and then when starting to move. I replaced my rear seal. A week later, I have oil in my timing and my engine no longer works. I have had it checked by a shop. No warning was given. I have my oil checked regularly and changed on time. I had a car full of people, adults and children, in rush hour traffic. The car is sitting in my driveway as I will need to negotiate with the lender on money owed. I am currently without a safe vehicle to drive, and I need that as I am a caregiver and home aid.

Filed Apr 18, 2026 · Engine · SC

I check my oil every time I get gas as to ensure that i don't go below the threshold for the oil, as I know these engines have an oil consumption issue. My terrain started having a loud grinding sound after losing power on the highway and I was able to pull off before the car died completely over 60 miles from home. I have since changed the upstream, and downstream O2 sensors (they needed it), VVT solenoids, and now going to be required to change my catalytic converter because the excessive oil consumption has clogged it almost completely. Why will GM not issue a recall for this engine and get it fixed, when they have knowledge that there is an issue. A recall was issued for previous years (on the same model) having the same issue, but yet we are left to "figure it out" at our own expense? Come on GM and the federal safety agency, get it together and issue a recall already, you have all the complaints, and history you need to start one.

Filed Feb 17, 2026 · Engine · MD

Carr paused, and then stopped in the middle of the highway, without any warning lights or identifiers. Other vehicles had to come to abrupt stops or even veer to avoid hitting me the manufacturer is aware, and has had a large lawsuit settlement due to a faulty rear seal causes massive internal oil consumption without any warning to the operator of of the vehicle. My research has shown that it is a catastrophic common issue with this vehicles model and year a certified GMC dealership has identified this as the reason for the sudden shut down without warning, not one warning light illuminated to indicate low or any other issue. The car has had regular oil changes and maintenance. This well-known defect should normally be caused for alarm and the safety of drivers would also for a mass recall.

Filed Feb 3, 2026 · Engine · MD

excessive oil consumption....caused engine to fail....yes, car is available for inspection ...caused the car to lag and initially break down without any warning lights ...confirmed form dealer new engine needed...law suits in other states have proven that this seal problem has been known to GMC for years and they haven't repaired these faulty parts...again, no warning lights came on...please assist

Filed Jan 15, 2026 · Engine · WI

I bought the vehicle in November of 2025. No warning lights or problems running. Check the engine oil upon purchase and have the dealership sticker showing oil change was recently done and oil showed that it was full. Approximately 3 weeks after purchasing, the car starting idling rough and stalled a few times during my commute to work. The check engine light came on and it showed that the vvt was a possible solution for the code P0014 this was on December 12th 2025. I replaced the suspected part with no change in vehicle condition. I checked the oil and found that it was empty/no oil on dipstick. I had to add 5 quarts of oil and then it showed it was in the safe zone on the dip stick. Today (January 15th 2026) I checked the oil again and it showed no oil on the dipstick. I had to add 2 quarts for it to be at the bottom of the safe zone on the dipstick.

Filed Jul 7, 2025 · Engine · IL

Excess Oil consumption

Filed May 16, 2025 · Engine · GA

My vehicle started shaking & stalling really badly out of nowhere on April 18, 2025. Had to have it towed to GMC dealership. They said the engine was showing low compression. Got timely oil changes and everything on this engine. The check engine light nor any other warning light ever came on when this happened. After some research, the engine in my car, the 2.4 L engine on the 2014 - 2017 models of the GMC Terrain has known defects which although GMC has known about, they have done nothing to address the issue. There was no prior warning that the engine was failing. It was very sudden and I was in traffic when this happened putting both my safety and the safety of other drivers and pedestrians in danger.

Filed May 6, 2025 · Engine · MD

I am reporting excessive oil consumption in my 2016 GMC Terrain with the 2.4L Ecotec engine. The vehicle burns through an abnormal amount of oil between routine oil changes, often requiring additional oil changes without any visible leaks or dashboard warnings until the oil level is dangerously low. This issue has been diagnosed by a certified GMC dealership, but the repair was not covered under warranty. I’ve learned this is a known and widespread defect related to faulty piston rings and PCV system issues in this engine model, which has led to engine damage or failure in many cases. GMC has not issued a recall for my VIN, and my request for goodwill assistance was denied despite the safety risk of low oil pressure and potential engine failure while driving. I believe this issue poses a safety concern and warrants formal investigation and potential recall expansion.