2016 GMC Terrain: engine failure

Filed Aug 14, 2026 · Engine · WI

The timing chain snapped and caused the engine to seize on our 2016 GMC Terrain 2.4L SLC-1 SUV/Truck. Since this has occurred multiple times on the 2.4L engines in this model from 2012 - 2016, we believe that there should be a recall as this issue could cause a major accident if the timing chain snaps or breaks while traveling. It had 101000 miles on it when we bought it used from Klein Automotive, on April 12, 2024. We have only had it for 2 years and 4 months and kept it in good repair. We took it in for its oil change, brought it home, went to dinner 4 days after and the very next day it wouldn't start. We thought it was most likely the starter/solenoid, but the mechanic said those were both fine and that's when we got the bad news that the motor was shot because the timing chain broke which caused some engine rods to break. The GMC dealer, in Marinette, WI, we brought our used 2016 GMC Terrain to, told us that the timing chain stretched and broke the rods in the engine and therefore both the timing chain and engine need to be replaced. The check engine light was turning on all of the time, and we were told that it was because it needed the 88 fuels (medium grade). As long as we put in the 88, the light check engine light stayed off. We believe there should be a recall for the 2012 - 2016 GMC Terrain SLC-1 2.4L timing chain and engine. We also need assistance with the cost of the repairs because I'm on a limited income and cannot afford the $10,000 cost of getting this repaired, while I still owe $7800 on it.

Filed Jun 5, 2026 · Engine, Transmission · NC

My 2016 GMC Terrain 2.4L Ecotec first stalled while idling at a red light in Raleigh, NC. I restarted it and it sounded different, so I drove it home. The next morning it would not start. The failure occurred at approximately 69,939 miles with no meaningful warning. The dealer’s diagnostic report states there were no current relevant codes and no relevant codes in history. The dealer documented major timing-system failure: timing chain tensioner failure, timing chain guide failure, a timing chain guide bolt pulled out of the cylinder head, aluminum contamination in the cylinder head/oiling system, and engine replacement recommended. The vehicle was found unsafe to operate. This vehicle regularly transported my family, including my children. If the stall/no-start failure had occurred at highway speed, while merging, or in heavier traffic, it could have created a serious crash risk. The oil was maintained outside the dealership network and had been serviced before failure. I also topped off the oil shortly before this occurred. The 2.4L Ecotec engine family is known for oil-consumption issues, yet this vehicle gave me no direct warning that oil consumption had reached a dangerous level. A reasonable owner would not know to check oil every day when there were no relevant stored warning codes. Other the federal safety agency complaints involving 2016 GMC Terrain vehicles describe similar patterns: oil consumption, no warning lights, sudden stalling or no-start conditions, timing-chain failure, and engine replacement recommendations. I am filing because this appears to be an ongoing safety risk involving oil consumption without adequate warning, timing-chain/timing-guide failure, internal contamination, and sudden engine failure. I request the federal safety agency review this issue for investigation or recall expansion before this failure mode causes a preventable serious crash, injury, or fatality. The vehicle was inspected by a GMC dealer and remains unrepaired.

Filed Feb 3, 2026 · Engine · MD

excessive oil consumption....caused engine to fail....yes, car is available for inspection ...caused the car to lag and initially break down without any warning lights ...confirmed form dealer new engine needed...law suits in other states have proven that this seal problem has been known to GMC for years and they haven't repaired these faulty parts...again, no warning lights came on...please assist

Filed May 6, 2025 · Engine · MA

My 2016 GMC Terrain exhibited the excessive oil consumption outlined in both of the following Special Coverage Adjustment bulletins. In addition to the excessive oil consumption, the oil light and oil pressure warnings never gave any indication that there was an issue or that the oil was low. This ended in the engine shaking the whole car, jerking it forward when stopped, and causing the engine to seize and need replacing. GMC customer service has refused to acknowledge this issue, stating that until the government tells them to issue a recall, they can't do anything to fix my vehicle. GM acknowledged the issue for model years 2010 - 2013 (+2014 later) and alleged that they made production changes in 2013 that fixed the issue. From the experience with my vehicle and the posts on multiple consumer websites by other GM owners, it is clear that they did NOT fix the issue and that there are hundreds of owners of GMC Terrain and Chevy Equinox vehicles with the 2.4L engines that have had this problem and have lost all the value in their vehicles as a result (or had to pay up to $10,000 for a new engine.) [XXX] [XXX] Class action lawsuit about previous model years: [XXX] v. General Motors INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 6, 2025 · Engine · MD

I am reporting excessive oil consumption in my 2016 GMC Terrain with the 2.4L Ecotec engine. The vehicle burns through an abnormal amount of oil between routine oil changes, often requiring additional oil changes without any visible leaks or dashboard warnings until the oil level is dangerously low. This issue has been diagnosed by a certified GMC dealership, but the repair was not covered under warranty. I’ve learned this is a known and widespread defect related to faulty piston rings and PCV system issues in this engine model, which has led to engine damage or failure in many cases. GMC has not issued a recall for my VIN, and my request for goodwill assistance was denied despite the safety risk of low oil pressure and potential engine failure while driving. I believe this issue poses a safety concern and warrants formal investigation and potential recall expansion.

Filed Jan 16, 2025 · Engine · IN

I was driving my vehicle to the gym when I noticed it was driving weird, it would not accelerate like normal, was having a hard time getting going and was making a weird noise. I had just put some oil in the car because we had known for a little while that it had a problem with burning oil because of the make and model (as told by other mechanics previously), when I got to the gym I heard a pop noise and the car stalled on me, I eventually got it started up again after 2 hours of being stranded at the gym. The next day I had to drive 40 minutes away for nursing school Clincial where on the way home it was back to driving weird and making a loud horrible noise from the engine. I was only 5 minutes from home when it was really bad and once there I noticed the burning smell from the engine. When I checked the oil level after an hour and half of cooling down I could not get any oil reading on the dipstick, after adding almost 4 quarts there was still no reading on the dipstick. We finally drove the car to my mechanic (8 minutes away) and it was already back to making the loud noise, having trouble accelerating, and producing the foul odor. I was told the PCV was restricted and caused the engine to over pressurize and that lead to the Main Rear bursting and all the oil in my car being thrown over the entire underside and probably the roads. They also checked the oil filter in the car to see if the engine itself was salvageable, where they found metal flakes in the oil filter and deemed the engine failed and are saying the engine needs replaced in order to fix the car I’ve had for 15 months… I’m still paying this car off and I have only driven it for less than 17,000 miles. It is a 2016 GMC terrain that only has 91k miles, I truly hope GM makes this right seeing as so many have come with the same exact problem due to poor design and vehicle quality. My car has had regular oil changes and I check the oil every week because of the prior burning problem.

Filed Jan 18, 2024 · Engine · MD

Driving down the road yesterday and outta nowhere I lost power and got a low oil pressure warning then the car just shut off merging onto a busy highway. Blown rear main seal and locked up the engine with no warning. Only 65k miles on the car. Dealership wants to charge me 11k to replace the engine. This is a very common occurrence with this vehicle I’m reading now. This could’ve caused a major accident

Filed Oct 16, 2023 · Driver assistance, Engine · MN

The engine - My engine blew because oil evaporated out of the #1 cyclinder, which drained the oil. No warning lights went on and the vehicle stalled in the middle of rush hour traffic. The dealership told me it was because of a factory defect, but no recall on that part of the vehicle. This could have been much worse if the vehicles behind me were going faster than they were and not able to stop before rear ending me. Because this was a factory defect it should have been recalled and I should have been notified of this problem when I bought the vehicle.

Filed Mar 18, 2023 · Engine · WI

While just starting on my way home on a cold 9 degree day,I have an 2016 GMC Terrain that I had since 2018 and bought from a dealer. After driving for about 12 miles on the interstate the Terrain engine light came on and there was a vibration coming from the front of my GMC. There was an exit ramp about 1/4 mile so i pulled off the interstate and my vehicle showed loss of power and steering and shut down, barely made it on the exit ramp. Very dangerous not having steering with little notice. I noticed alot of oil dripping from the undercarriage so I called a local automobile shop to get my vehicle towed. They diagnosed that I needed a new engine and comented that the 2.4 engine had many issues. I recently had it towed to my house and currently going to have a local chevy dealer give me a second opinion and cost for repairs since I still have a loan on the vehicle.I believe that this is a very unsafe vehicle and needed to be reported so nobody gets hurt. Thank You

Filed Feb 24, 2021 · Acceleration, Electrical · 111,000 miles · NJ

Vehicle since purchase shows no signs of leak but goes through oil at about 1 quart every 1000 miles max. Check engine light always on, sensors indicate possible faulty piston rings. All were problems in later model gmc terrains. When low on oil while driving and stationary all lights will light up and engine will go into reduced power mode saying to service stabilitrack. Car will not go above 10 MPH when in this mode, sometimes unable to move at all. Goes away after more oil added. Gmc terrain had recalls on years 2010-2013 for all engine failure problems/repairs due to faulty piston rings/oil consumption issues. Numerous 2014-2016 gmc terrains have claims of the reduced power/stabilitrack problem with no solution, I believe both problems are directly related.

Filed Feb 16, 2021 · Engine · 70,000 miles · MN

Tl* the contact owns a 2016 gmc terrain. The contact stated that while driving 40 MPH, there was and abnormal clicking sound coming from the engine. The vehicle was later towed from his residence to an independent mechanic, where the vehicle was diagnosed with a blocked pcv valve which caused the rear main seal failure. The mechanic informed the contact that the clicking sound was from the oil draining at a rapid speed and that the engine needed to be replaced. The contact then called mauer chevrolet (1055 50th st e, inver grove heights, mn 55077) and was informed of an upcharge for the engine replacement. The contact also called the manufacturer, and was informed that the vehicle needed to be diagnosed by an authorized gmc dealer. The vehicle was not repaired. The approximate failure mileage was 70,000.*dt

Filed Jan 30, 2020 · Engine · 75,930 miles · IL

I was on my way home from work driving on the expressway, then all of a sudden every light on my dashboard came on...then my vehicle said reducing speed. I was able to get on the shoulder before it turned off completely. I had to wait for a tow truck for 2 hours. It was cold. I had to tow it to my house because the place that I previously went to was closed and I couldn't leave the vehicle there. So, it was towed to the shop the next day and I was told that I needed a new engine. Engine failure due to lack of oil from blown rear main seal. Seal blown out due to pcv.