The contact owns a 2016 Grand Design Recreational Solitude RV. The contact stated that while the RV was parked, the side skirts separated from the wall. The contact also stated that the wall separated from the camper and that the rear of the RV moved from side to side independently. No warning lights were illuminated. The RV was taken to an independent mechanic, where it was diagnosed with excessive frame flex, with the body moving approximately 3/8 inch from side to side. The contact was also informed that the RV frame was severely cracked and that the weld points were damaged. The contact was informed that the RV frame needed to be replaced and that reinforced welding was needed. The RV was not repaired. The manufacturer was made aware of the failure via email and telephone.
The worst 2016 Grand Design Solitude problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Body2
- Brakes2
- Suspension1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Body2
- Brakes2
- Suspension1
Recalls 3
Equipment: appliance: refrigerator
- What is wrong
- Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
- Risk
- An electrical arc increases the risk of a fire.
- Remedy
- Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1‑574‑825‑9679. Grand Design's number for this recall is 910026.
Recall number 22V038000 · Recall details
Equipment
- What is wrong
- Grand Design RV (Grand Design) is recalling certain model year 2015-2016 Momentum toy haulers and Solitude recreational trailers manufactured July 8, 2014, to August 31, 2015, equipped with certain aluminum black ladders manufactured by Christianson Industries. These ladders have retractable hinges, each with a welded 'top hat' that can separate from the hinge.
- Risk
- If the hinges separate from the ladder while in use, the ladder may fall from the vehicle, increasing the risk of injury.
- Remedy
- Grand Design will notify owners, and dealers will install a bracket over the back of existing hinges, free of charge. The recall began on December 16, 2016. Owners may contact Grand Design customer service at 1‑574‑825‑9679. Grand Design's number for this recall is 910008.
Recall number 16V841000 · Recall details
Suspension: rear: axle: non-powered axle assembly
- What is wrong
- Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2016 Reflection 303RLS, 308BHTS and 313RLTS, model 2016 Solitude 375RE trailers manufactured March 12, 2015, to April 6, 2015. In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break.
- Risk
- If the wheel studs break, the wheel could detach from the vehicle, increasing the risk of a crash.
- Remedy
- Grand Design has notified owners, and dealers will replace any affected wheel hub, free of charge. The recall began on April 14, 2015. Owners may contact Grand Design customer service at 1‑574‑825‑9679. Grand Design's number for this recall is 910003.
Recall number 15V212000 · Recall details
Technical service bulletins for the 2016 Grand Design Solitude 2
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 2016 Grand Design Solitude owners say
Most recent owner complaints, unedited.
The contact owns a 2016 Grand Design Solitude Camper. The contact stated while while the camper was traveling, the side door independently unlatched and opened. In addition the contact stated while the camper was parked , the contact noticed that the midddle slider was detached about 10 inches. The camper was not diagnosed or repaired by an independent mechanic or dealer. The contact stated in the past the camper was taken to the dealer, however the failure was not duplicated. The contact was informed that the slider needed to be reset. The manufacturer was not made aware of the failure.
On 26 september 2018, I ordered a suspension kit for this trailer from www.etrailer.com. Order# 106838902. The kit I ordered was a roadmaster slipper spring kit #rm-2570 with the rm-2460 shock absorbers. This equipment is for an axle that is rated at 7,000 lb, which is what the axles on my trailer are rated for. I installed the kit on my trailer. After installing the springs I noticed a tag on one of the springs. Using the number found on the tag, e5226, I did some research on the internet and discovered that the spring is rated for 3,000 lbs which is suitable for an axle that is rated for 6,000 lbs. Roadmaster is the manufacturer of the spring kit. Etrailer is the retailer selling the kit. My complaint is that the springs in the 7,000 lb kit are only suitable for 6,000 lb axles. Persons using the rm-2570 kit may buy the kit and install it thinking the equipment they installed was safe. But in fact, the springs are underrated for their intended use and this could result in spring failure and an accident. I have notified both roadmaster and etrailer, but it's after hours and I don't expect to hear back from them until their offices open tomorrow.
Brand new 2016 never towed by me. Trailer delivered by dealer. All 4 brakes covered in grease. Well known problem. No action by manufacture
I purchased this 5th wheel rv new in april of 2016. I have towed it approximately 800 miles. I figure that between delivery from the factory to the dealer in raynham, ma and my personal use that there is about 1700 total miles on this rv. I have been monitoring the grand design owners forum and frequently an issue was discussed about grease appearing on the brake shoes. Being I own one, I decided to inspect this area to see if grease was getting on my brakes. I found that the grease from the wheel bearings was getting through the rear seal and had started spreading throughout the brake system. Grease on the brakes of a 15,000 lb towed vehicle will hinder the ability stopping, particularly in the event of a sudden or emergency condition. The company that manufactures the axel and assembles the components associated with the grease and brakes are lippert. When I contacted the dealer that I purchased the rv from they stated they were aware of the issue and that grand design, rv manufacturer along with lippert were very willing to repair this problem. The real issue I feel is that if this is a well-known problem, and the company is willing to fix it, it is very possible that owners rv's with the lippert axel system may not know there is a pending problem if they don't have forum access or have not been notified by the rv manufacturer of this problem. What does it take to "encourage" the manufacturer to make a sincere recall notification so there does not have to have a death or lawsuit involved. I was not otherwise injured by this condition, just inconvenienced.
Compare the 2016 Grand Design Solitude
Other model years
Questions about the 2016 Grand Design Solitude
Is the 2016 Grand Design Solitude reliable?
Owners have filed 5 complaints about the 2016 Grand Design Solitude, fewer than a typical Solitude model year.
What is the 2016 Grand Design Solitude year score?
The 2016 Grand Design Solitude scores 85 out of 100 (good). The score compares it with the other model years of the Grand Design Solitude: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2016 Grand Design Solitude?
Body and structure, with 2 complaints. Next is brakes (2).
How many recalls does the 2016 Grand Design Solitude have?
3 recalls, covering equipment and suspension.
What year does the Grand Design Solitude have the most body problems?
The Grand Design Solitude model years with the most body complaints are 2022 (27 complaints), 2021 (24 complaints) and 2023 (11 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Grand Design Solitude?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history