Consumer was driving a 2005 international 9400i, but the 2006 great dane trailer he was towing had the tire blow out. Right rear tire on unit 1 blew. Tire re-tread from unit 1 struck unit 2 grill. *bf (ohio traffic crash police report # 10-078-90. *jb updated 08/06/10
The worst 2006 Great Dane Trailer problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical1
- Suspension1
- Tires1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical1
- Suspension1
- Tires1
Recalls 3
Trailer hitches
- What is wrong
- On certain trailers, stainless steel mounting bolts of a lesser grade were used in lieu of the standard grade 8 carbon steel bolts to attach the pintle hooks.
- Risk
- This could result in separation of the towed vehicle from the semi-trailer which could result in a crash.
- Remedy
- Dealers will install the grade 8 carbon steel bolts in order to insure that the mounting of the pintle hook meets the required recommendations free of charge. The recall began on october 29, 2007. Owners may contact great dane at 1‑800‑633‑4176.
Recall number 07V461000 · Recall details
Service brakes, air: antilock
- What is wrong
- On certain federal express (fed-ex) trucks equipped with haldex antilock brake system (ABS) electronic control unit (ecu) valves, the valves need to be modified in order to relocate the valves in an upright position. The valves contain a ball seat piston that may become dislodged during an ABS event and not perform properly.
- Risk
- Drivers would not be warned of a brake system failure increasing the risk of a crash.
- Remedy
- Great dane is working with fed-ex to replace the ABS valves free of charge. Fed-ex has dead-lined these vehicles until the repair has been performed.
Recall number 07V406000 · Recall details
Suspension
- What is wrong
- On certain van and refrigerated semi-trailers equipped with tuthill suspensions, model 20/22ar and rs3162, the beam/axle pivot connection joint is mis-aligned causing excessive play with the trailer allowing the trailer to wander.
- Risk
- Should the trailer wander a vehicle crash could occur without notice.
- Remedy
- Great dane is working with tuthill to notify the owners of the affected vehicles and provide free remedy. Owners may contact tuthill at 800‑753‑0025 or great dane at 912‑644‑2100.
Recall number 05V493000 · Recall details
What 2006 Great Dane Trailer owners say
Most recent owner complaints, unedited.
Tl* the contact's employer owns a 2006 great dane trailer. The electrical system h failed. The manufacturer diagnosed the trailer as needing a new wiring harness. The current and failure mileage was unknown. The trailer information unknown.
Dt*: the contact stated the rear and side light markers could not be seen in the rear mirrors when the trailer was being towed, although the glow was visible. The manufacturer was notified. Manufacturer: great dane trailers. Model: freedom
Rear axle of 2006 great dane trailer is over heating to the point that it melts the oil caps. Has been in the garage three times, each time they loosened the bearings 0.001 of an inch even though it states in the manual that adjusting nut should be torque to 50 lb-ft not loosened. Loosening the adjusting nut could cause the wheel to come off during vehicle operation.
Compare the 2006 Great Dane Trailer
Other model years
Questions about the 2006 Great Dane Trailer
Is the 2006 Great Dane Trailer reliable?
Owners have filed 4 complaints about the 2006 Great Dane Trailer, 4.0 times a typical Trailer model year.
What is the most common problem with the 2006 Great Dane Trailer?
Electrical system, with 1 complaint. Next is suspension (1).
How many recalls does the 2006 Great Dane Trailer have?
3 recalls, covering trailer hitches, service brakes, air and suspension.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Great Dane Trailer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history