2007 Harley-Davidson Flhtcu transmission problems

Filed Jun 19, 2017 · Engine, Transmission · 9,000 miles · MD

Tl* the contact owns a 2007 harley-davidson tri glide fltr. While driving various speeds, the drive belt malfunctioned and became misaligned. In addition, the bearings that held the pivot shaft together exhibited premature excessive wear. An unknown dealer was contacted about the failure. Another unknown dealer inspected the vehicle and determined that the bearings were faulty. The contact inspected the vehicle and found that the bearings contained fragments of rubber and metal. The manufacturer was made aware of the issue. The failure mileage was approximately 9,000.

Filed Dec 15, 2011 · Engine, Transmission · 12,500 miles · AL

Engine knocks and kicks backs, on starting and when accelerating,has been worked on several times, by harley davidson dealer. The problem I've been told is the compensator sprocket and assembly . Through many forums and talks with other harley riders that have had the same problems, the fix to the problem according to people who have researched the compensator is for it to be replaced with the screaming eagle compensator part #40274-08.if this is not recalled or repaired by harley it can be very expensive for the owner to repair approx. 600.00 dollars but more important the compensator can come apart possibly busting the primary case letting oil to spill on to road and tires which could cause an accident and possibly hurting someone or worse killing someone.

Filed May 17, 2011 · Transmission · 14,000 miles · TX

Tl* the contact owns a 2007 harley davidson flhtcu motorcycle. The contact stated that the vehicle would not start. The vehicle was towed to the dealer and they diagnosed that a metal piece was jammed in the chain, but the vehicle was not repaired. The manufacturer was not made aware of the failure. The failure and current mileage was 14,000.

Filed Jun 24, 2008 · Transmission · 7,000 miles · WY

Transmission will not shift out of 2nd gear (up to 3ed gear or down to n) . Transmission will pop out of 6yh gear back into 5th gear at highway speeds. Am afraid the transmission will lock up causing the rear wheel to lock and cause an accident.

Filed Aug 17, 2007 · Transmission · 200 miles · IL

My 2007 harley davidson ultra classic has developed a very loud rattle and knock in the driveline. It sounds as though something is very loose and getting ready to come apart. I have taken the bike to the dealer 8 times and the has not been any fix for the problem yet. There is a website (www.hdforum.com) where there are many, many 2007 ultra classic owners with the exact same complaint. I fear that if whatever is loose inside the driveline comes apart at highway speed it could cause rear wheel lockup and loss of control of the motorcycle.

Filed Jul 26, 2007 · Engine, Transmission · 10 miles · MS · 1 injury

The situation: on a motorcycle, drivetrain failure at typical operating speeds could very well mean severe injury or death of the rider. Abnormal heat or noise coming from the motorcycle's drivetrain are not issues to be ignored by a prudent rider or by the manufacturer of the motorcycle. For example the drivetrain on my 2007 flhtcu is excessively noisy when operated in gear. This implies excessive vibration and/or abnormal wear occurring somewhere within the system. In addition, the exhaust runs so hot as to present a burn hazard to the rider and passenger even when properly clothed. While riding even in winter temperatures I sustained a severe burn to my left leg, leaving a permenat 4" scar. It is well known that excessive heat will also contribute to longterm problems with any drivetrain, increasing the likelyhood of failure. What harley davidson has done: to date, the only half-hearted solution to these maladies offered by the harley davidson motor company has been the "torque smoothing download" which accomplished nothing when installed on my bike. Hd has asserted that the noise and heat are normal. On the contrary, many 2007 hd units do not have these issues, thus they are clearly not normal. Many owners have resorted to costly aftermarket solutions such as replacement gearsets and fuel management systems all installed a their own expense. I essence, hd has offloaded their responsibilities onto their customers. What hd should do: hd should issue a recall. Hd should retrofit all affected 2007 models with the ids rubbermount rear sprocket (now standard on the 2008 touring models) to reduce drivetrain vibration and wear. They should also provide adjustments and/or modifications as needed to the fuel system to reduce drivetrain heat. They should extend the warranty of all affected 2007 motorcycles appropriately.

Filed Jul 26, 2007 · Engine, Transmission · AR

The situation:on a motorcycle, drivetrain failure at typical operating speeds could very well mean severe injury or death of the rider. Abnormal heat or noise coming from the motorcycle's drivetrain are not issues to be ignored by a prudent rider or by the manufacturer of the motorcycle. For example the drivetrain on my 2007 flhtcu is excessively noisy when operated in 5th gear at normal rpms. This implies excessive vibration and/or abnormal wear occurring somewhere within the system. In addition, the drivetrain runs so hot as to present a burn hazard to the rider and passenger even when properly clothed. It is well known that excessive heat will contribute to longterm problems with any drivetrain, increasing the likelyhood of failure. What harley davidson has done: to date, the only half-hearted solution to these maladies offered by the harley davidson motor company has been the "torque smoothing download" which accomplished nothing when installed on my bike. Hd has asserted that the noise and heat are normal. On the contrary, many 2007 hd units do not have these issues, thus they are clearly not normal. They are certainly common problems, however. Many owners have resorted to costly aftermarket solutions such as replacement gearsets and fuel management systems all installed a their own expense. I essence, hd has offloaded their responsibilities onto their customers. What hd should do: hd should issue a recall. Hd should retrofit all affected 2007 models with the ids rubbermount rear sprocket (now standard on the 2008 touring models) to reduce drivetrain vibration and wear. They should also provide adjustments and/or modifications as needed to the fuel system to reduce drivetrain heat. They should extend the warranty of all affected 2007 motorcycles appropriately.

Filed Jul 24, 2007 · Transmission · 10 miles · TX

Excessive clattering noise coming from drive train of motorcycle. Motorcycle has been examined at dealer and was serviced to upload new computer program into engine control module. Drivetrain still clatters and feels as if engine or transmissions shafts are about to break. Dealers say this is normal. Motorcycle does not feel safe to drive. From my reading on internet this is a common issue with 2007 touring class harley davidson. I personally feel this needs to be investigated to reassure owners bikes are sound and that drivetrain is not going to lock up at highway speeds.

Filed Jul 16, 2007 · Transmission · 100 miles · OH

Harley davidson 2007 ultra classic motor cycle defective 6 speed transmission, and over heating engine problem.

Filed Jun 4, 2007 · Transmission · 3 miles · NH

Tl*the contact owns a 2007 harley davidson flhtcu. The contact stated that on the day his vehicle was delivered, it failed to shift into neutral. The dealer and manufacturer were notified. The clutch was adjusted, but the failure persists. The current mileage is 150 and failure mileage was 3. Updated 02/04/08. *lj the consumer stated the motorcycle manual informing the customer of hazardous situation. Updated 02/01/08