Honda CR-V engine failure problems

Filed Oct 31, 2026 · Engine · WI

Vehicle: 2016 Honda CR-V EX-L AWD Mileage: Approximately 135,000 miles Description of Safety Complaint I purchased my 2016 Honda CR-V brand new and have maintained it regularly. My most recent oil change was in August 2026. For approximately two to three weeks before the incident, I noticed a rattling noise coming from the engine, particularly when slowing down or driving downhill. On October 30, 2026, while driving on the highway, the engine suddenly stopped running. I was able to steer the vehicle and safely pull over to the side of the road. After some time, the engine restarted, but it was making a very loud noise. The check-engine and battery warning lights also came on. My mechanic inspected the vehicle and suspects a connecting-rod bearing failure, although the exact cause has not yet been confirmed. The mechanic indicated that the engine oil was slightly low but not critically low. I am concerned that the engine failed unexpectedly while driving at highway speed, creating a serious safety risk. I am requesting that the federal safety agency document and review this incident as a possible vehicle safety defect.

Filed Oct 29, 2026 · Engine · 244,372 miles · TN

The contact owns a 2018 Honda CR-V. The contact stated that while driving 60 MPH, the vehicle lost power with the fuel pressure failure, causing the vehicle to decelerate, and there was heavy smoke coming from the exhaust. The contact pulled over safely and the vehicle went into LIMP Mode while driving back to the residence. The check engine warning light and other unknown warning lights were illuminated. The contact became aware of an abnormal burning rubber odor prior to and during the failure. The manufacturer was notified of the failure. The vehicle was towed to a local dealership, where it was diagnosed with a blown engine head gasket, lack of oil in the engine, and other internal engine damage. The failure mileage was 244,372.

Filed Oct 1, 2026 · Engine, Transmission · WA

The timing chain and camshaft broke the car froze while driving 70 mh. No warning. With about 67000 mi on it. Yes it can be inspected. At risk on the freeway going 70 mph. Was able to coast to the right side before engine locked the wheels. Not able to restart. Towed to an independent garage. They gave a diagnostic test and then opened it up to find timing chain broke and caused camshaft as well as other damages. No warning! Taking it to Moses Lake Honda dealership tomorrow for another evaluation and replace the engine if needed. Low mileage and well maintained! Should have never happened.

Filed Sep 11, 2026 · Engine · VA

My 2018 Honda CR-V with the 1.5L turbo engine experienced an overheating condition while being driven. The temperature gauge fluctuated and reached the red zone, creating a potential risk of engine failure and loss of vehicle operation. The vehicle was inspected by a Honda dealership, which reported that the coolant was empty and recommended replacing the engine. I was given an estimate of approximately $7,000 for the replacement. A subsequent inspection by another mechanic included two cooling-system pressure tests that reportedly found no externally visible coolant leak. After the cooling system was topped off, I monitored the coolant level for approximately three weeks and observed no apparent decrease. There was also no coolant observed in the engine oil. The mechanic subsequently stated that a camera inspection showed coolant present in the cylinders and that the head gasket had failed. However, I have not received clear written documentation establishing the root cause of the coolant loss or overheating. The vehicle now has approximately 153,000 miles. I am reporting this because the vehicle experienced a significant overheating and coolant-loss condition that could recur without warning. A recurrence could result in engine failure or loss of power while the vehicle is being operated, potentially creating a safety hazard. I request that the federal safety agency review this complaint along with other complaints involving the 2018 Honda CR-V equipped with the 1.5L turbo engine, including reports of coolant loss, overheating, head-gasket failure, coolant entering the cylinders, and resulting engine failure. I specifically request that the federal safety agency evaluate whether this condition represents a safety-related defect and whether the available complaint and failure data warrant an investigation, safety recall, or other corrective action by Honda. Please include this complaint in the federal safety agency’s records for this vehicle and engine combination so that it can be considered with other potentially

Filed Sep 10, 2026 · Engine · NY

VTC actuator malfunction causing timing chain failure leading to engine failure dangerous if driving causing engine to fail on highway leading to dangerous situation paid to fix 10,000 miles later same issue with updated part installed. Problem confirmed by Honda

Filed Sep 8, 2026 · Engine · TX

On August 8, 2026, while operating a 2016 Honda CR-V (62,459 original miles) at highway speeds, the engine’s factory water pump experienced a sudden, catastrophic internal failure and froze completely. The seized water pump instantly sheared and shredded the serpentine belt. This induced an immediate, sudden loss of alternator charging, engine cooling, and power steering assist while driving at high highway speeds. This instantaneous component failure created a severe, life-threatening safety hazard, leaving the driver struggling to control the heavily disabled vehicle. This structural mechanical failure directly matches the engineering defect acknowledged by the manufacturer in Honda Technical Service Bulletin (TSB) #17-063, noting that factory water pump bearings were manufactured "out of specification." Despite knowing that this manufacturing defect causes sudden accessory drive-belt failure at highway speeds, Honda has failed to issue a proactive safety recall, placing drivers in immediate danger.

Filed Aug 29, 2026 · Engine · TX

Car abruptly lost power while driving. I was barely able to pull over to the side and park the car in lot that happened to be next to where I was driving. The car was towed to a award-winning service facility (non-Honda) and it was determined that P0303 Cylinder Misfire and P16e8 engine error codes due to a blown engine head gasket. According to the head mechanic, they had recently had another Honda CRV experience the same issue. The replacement parts/kit/labor cost almost $4,000. Without it the car was undriveable, most concerning was the abrupt loss of power, thankfully was not on a highway when this happened as there had been no warning or degradation in performance prior to the issue occurring. In searching the internet, apparently many others with Turbo CRV's are reporting this type of issue? I contacted Honda and they were basically of no help other than suggesting I have the car towed to a dealership but with no guarantees that they would cover anything given the 'age' of the vehicle. It has been a very well maintained car.

Filed Aug 18, 2026 · Engine, Fuel system · AZ

I am the owner of a 2020 Honda CR-V equipped with the 1.5L turbocharged engine. The vehicle is experiencing a severe and dangerous engine oil dilution manufacturing defect where unburnt gasoline enters the oil pan. This is an active driving hazard. After a fresh oil change meant to remediate the issue, the oil level rapidly rose back up past the top dipstick indicator within less than 200 miles of driving, and the oil smells strongly of raw gasoline. This severe dilution degrades the engine oil viscosity, creating an immediate risk of sudden engine stalling, loss of propulsion, or catastrophic internal engine failure while driving at speed. Honda is aware of this defect on 1.5L turbo engines but has failed to issue a recall or provide a permanent engineering solution for 2020 models. I currently have 44,443 miles on the vehicle.

Filed Aug 12, 2026 · Engine · CA

On the evening of [XXX], I started my vehicle while it was parked in my garage. Within approximately five minutes, the vehicle suddenly produced a violent and unusually loud mechanical noise, followed by visible smoke billowing from beneath the hood. Recognizing the immediate potential fire and safety hazard to both myself and my property, I immediately shut the vehicle down. The following morning, I took directly to Honda North, an authorized Honda dealership in Clovis, California, for a professional diagnostic inspection. The dealership's certified inspection determined that the A/C compressor had suffered a catastrophic internal mechanical failure and had completely seized. According to the dealership, the compressor's internal failure while the system was operating resulted in metallic debris being circulated throughout and contaminating the A/C system. This catastrophic seizure heavily strained the engine's drive belt system. The failure was a direct result of the factory compressor shaft seal leaking out all system refrigerant and lubricating oil, causing the unit to run dry and seize. As a result, the dealership determined that replacing only the failed compressor would not be sufficient to properly restore the system. The recommended repair requires a complete A/C system overhaul, including replacement of the compressor, condenser, expansion valve, and associated refrigerant lines/components. Honda has openly acknowledged this exact factory defect in Service Bulletin 23-040, extending the shaft seal warranty to 10 years. However, Honda Corporate Customer Service is refusing responsibility for the downstream consequential destruction caused by their own defective component, citing only general vehicle age and mileage, despite the vehicle having 55,782 miles and sitting well within the 10-year extended warranty window. They have refused to provide an engineering justification or written analysis for this safety-related coverage denial. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

Filed Aug 11, 2026 · Engine · IL

While driving safely on the highway at 55mph speeds, my 2018 Honda vehicle suddenly displayed multiple unexpected warning lights and alerts on the dashboard. The vehicle experienced an abrupt loss of normal operation behavior, posing an immediate safety hazard and risk of a collision in fast-moving traffic. I took the vehicle to an authorized Honda dealership for diagnostics, paying a $200 diagnostic fee. The dealership confirmed a severe mechanical failure involving the head gasket. Because the vehicle is out of the limited warranty window, the dealership quoted a prohibitively high repair cost and advised me to trade the vehicle in rather than fix it. As a Costco employee who relies entirely on this vehicle for my livelihood and commute, this sudden catastrophic engine failure jeopardizes my employment. A core engine component like a head gasket failing prematurely at highway speeds is a critical safety and structural defect that puts drivers at risk. I am filing this complaint to request a federal investigation into potential 2018 Honda 1.8L engine and gasket defects.