2003 Honda FSC600 Problems: 1 Complaint, 3 Recalls

The worst 2003 Honda FSC600 problems

Ranked by number of owner complaints. Mileage and cost come from what owners wrote.

Body
1
Fuel system
1
Steering
1

Problems by type

Tap a problem to see which part fails, at what mileage and in which other years.

Body
1
Fuel system
1
Steering
1

Recalls 3

Structure: motorcycle: kickstand/center standReported June 25, 2004 · 7,494 vehicles affected

What is wrong: On certain motorcycles, the main stand is attached to the frame with two brackets, nuts and bolts. The nuts are spot-welded to the brackets. If clearance exists between the nut and bracket, the spot welds may be broken when the bolt is torqued.
Risk: Over time, a bolt can loosen and fall out. The main stand could partially or completely detach from the frame, interfering with or damaging the rear wheel, and increasing the risk of a vehicle crash without warning. A completely detached stand falling on the roadway also creates a hazard for other vehicles.
Remedy: Dealers will install new brackets, longer bolts and locknuts. Owner notification began on june 29, 2004. Owners should contact american honda at 1‑800‑999‑1009.

Recall number 04V290000 · Recall details

Fuel system, gasoline: storage: tank assemblyReported April 12, 2004 · 2,497 vehicles affected

What is wrong: On certain scooters, some fuel tanks were improperly manufactured and do not meet material strength specifications.
Risk: Engine vibration or riding on bumpy roads could cause these tanks to crack and leak. Fuel leakage, in the presence of an ignition source, can result in a fire.
Remedy: Dealers will perform an inspection procedure that identifies defective fuel tanks. If the fuel tank fails the inspection, the dealer will replace it with an updated fuel tank. Owner notification began during april 16, 2004. Owners should contact honda at 1‑866‑784‑1870.

Recall number 04V163000 · Recall details

Steering: steering wheel/handle barReported December 10, 2003 · 4,997 vehicles affected

What is wrong: On certain scooters, excessive clearance between the lower handlebar clamp and handlebar holder creates stress that can eventually cause the handlebar to loosen or detach.
Risk: This could result in a loss of steering control, which could lead to a crash.
Remedy: Dealers will install two lower handlebar clamps, add washers between the lower clamps and handlebar holder, and install new locknuts. Owner notification began on december 11, 2003. Owners should contact honda at 1‑866‑784‑1870.

Recall number 03V513000 · Recall details

See all 3 recalls for the 2003 Honda FSC600

Technical service bulletins for the 2003 Honda FSC600 5

Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.

Aug 6, 2014 Service bulletinDealer message
Jul 23, 2014 Service bulletinDealer message
May 31, 2008 Service bulletinLoad carrying capacity reduced label for all honda vehicles.
May 9, 2008 Service bulletinHonda: warranty extension-vehicle warranty mileage
Feb 1, 2004 Service bulletinSafety recall tip

What 2003 Honda FSC600 owners say

Most recent owner complaints, unedited.

Filed Oct 11, 2005 · Body, Fuel system · 500 miles · NC

Purchased vehicle new from schroder's honda. After the purchase transaction was complete, they informed me that there were 3 recalls that need to be performed, we scheduled a date to do them at that time. When I brought the vehicle back to do the recalls they were too busy to do them and rescheduled. The second time there, they allegedly performed 2 of the 3 recalls. One of them was replacing the handlebar mounts to prevent them from coming loose. They didn't do all three because they forgot to order the parts. The next morning while riding, my handlebars came loose. I pulled the cover off to find out that they forgot to tighten 2 of the 4 bolts that held them on to the bike. I called the dealer about it and the service manager didn't even apologize or attempt to make the problem right. At that point I didn't feel comfortable with that service department performing the final recall, so I took it to another honda dealer. They cannot perform the recall though because schroder's honda reported that they already did that recall. Mr honda verified on the bike that the recall hasn't been done. Now I have a vehicle that's not safe and no way to make it safe. Please help.

Used buying checklistWhat to check on a 2003 Honda FSC600 before you buy

Compare the 2003 Honda FSC600

Other model years

200220032007 2009 2010

Questions about the 2003 Honda FSC600

Is the 2003 Honda FSC600 reliable?

Owners have filed 1 complaint about the 2003 Honda FSC600, close to a typical FSC600 model year.

What is the most common problem with the 2003 Honda FSC600?

Body and structure, with 1 complaint. Next is fuel system (1).

How many recalls does the 2003 Honda FSC600 have?

3 recalls, covering structure, fuel system, gasoline and steering.

Was there a recall on the 2003 Honda FSC600 body?

Yes, 1 recall: 04V290000. Check your VIN to see if your car still needs the free repair.

VIN decoder

See the problems and recalls for an exact car

Buying a used 2003 Honda FSC600?

Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.

Check its history

2003 Honda FSC600 problems