Honda HR-V stalling problems

Filed Sep 17, 2026 · Electrical, Engine · SC

The 2025 Honda hrv will stall and cut off after pumping gasoline. It will stall out at a red light and not crank back up. It says emissions problem on the dash. I believe it is the fuel pump but there is no recall like the others i have seen online. It’s a brand new car it shouldn’t be having problems like this!

Filed Aug 10, 2026 · Fuel system · MI

AMENDMENT TO SAFETY COMPLAINT: FAILURE OF RECALL REMEDY / USE OF LEGACY PART Vehicle: 2020 Honda HR-V the federal safety agency Recall Campaign Number: 23V858000 (Low-Pressure Fuel Pump) [The 2020 Honda HR-V is under an active, massive federal safety recall for low-pressure fuel pump failure.] Chronological Safety History: •January 2025: Mandatory fuel pump safety recall performed at an authorized Honda franchise. •September 2025: Catastrophic engine stall occurred at highway speeds. •June 12, 2026: Second catastrophic engine stall occurred at highway speeds. Critical Update: Following these severe stalling events, I presented the vehicle to franchised dealer Zeigler Honda. The dealership service department engaged in fraudulent diagnostic practices to evade liability. They falsely claimed the stalling was due to "bad gas," refused to perform a secondary repair, and released a hazardous vehicle back onto public roads. Due to the immediate threat to public safety, I brought the vehicle to a certified independent mechanic. Upon replacement of the system, a component breakdown revealed that the recall part installed in January 2025 was actually an identical, low-density defective legacy component subject to the original recall. The independent mechanic's invoice factually confirms a total mechanical failure of this fuel pump component [The 2020 Honda HR-V is under an active, massive federal safety recall for low-pressure fuel pump failure.]. The system breakdown confirms the plastic impeller deformed and jammed, completely disproving Zeigler Honda's fabricated "bad gas" diagnosis [Honda’s official recall documentation states that the low-pressure fuel pump fails because the plastic impeller absorbs fuel, deforms, and jams against the pump housing, causing the vehicle to stall.]. Regulatory Request: I request that the Office of Defects Investigation (ODI) audit this dealership immediately. Zeigler Honda is actively falsifying safety diagnoses to cover up the defective fuel pump

Filed Jul 6, 2026 · Body, Electrical · MO

I am filing a formal complaint regarding two critical manufacturing defects on my 2018 Honda HR-V that pose immediate safety risks and financial losses: 1. CRITICAL SAFETY ISSUE (Instrument Gauge Failure): The digital display gauge on the right side of the driver's dashboard consistently blinks out and displays entirely unreadable, corrupted characters. This failure makes it impossible to monitor the fuel gauge or know how much gasoline remains in the vehicle. This defect is highly temperature-dependent, becoming severely worse during colder months. Not being able to read the fuel gauge creates an immediate, dangerous safety hazard, risking sudden, unexpected engine stalling on active highways or getting stranded in hazardous conditions. 2. MANUFACTURING DEFECT (Paint Delamination): The vehicle is exhibiting severe paint peeling and flaking on the roof in four distinct places. The exterior clear coat and base coat are actively separating from the underlying primer due to an inherent manufacturing adhesion failure. The vehicle features the White Orchid Pearl color (Paint Code: NH-788P). American Honda Motor Co. previously acknowledged this exact production defect by issuing a Warranty Extension under Technical Service Bulletin (TSB) 19-064, extending coverage for 2016–2018 HR-Vs for 7 years. However, because this premature failure is only now manifesting on my vehicle, Honda Corporate and local dealerships are refusing to cover the thousands of dollars in necessary repair costs, claiming the 7-year window has expired. Limiting the remedy to an arbitrary timeframe for an inherent manufacturing defect leaves consumers with a structurally degrading vehicle (exposure to rust and metal deterioration) & zero recourse. Respectfully request that the Office of Defects Investigation compel American Honda to address the dashboard electrical failures and expand or reopen the remedy for known White Pearl paint peeling defect to ensure consumer safety& manufacturer accountability

Filed May 30, 2026 · Electrical, Engine · NY

The vehicle has a recurring safety defect where it suddenly shuts off / stalls while driving. This has happened multiple times, including immediately after the dealership performed repairs and issued "clean" diagnostic reports stating no issues were found. Key details: PCU codes were present on the first visit but were not properly addressed. Repair orders contain clear inconsistencies, including claims of test drives and mileage that do not match the actual odometer readings. On the most recent visit, I did not authorize any further repairs, yet the dealership now claims the vehicle is "resolved" and ready for pickup. The vehicle has been at Honda dealerships for a total of 57 days across multiple failed repair attempts. I have refused to take possession of the vehicle due to the ongoing safety risk of it shutting off while driving.

Filed May 14, 2026 · Fuel system · SC

While driving, starting from a stop sign / or traffic light, the vehicle will stall out upon light acceleration. Going through the recall information, it appears that many 2017 Honda HRV and 2018 Honda HRV have a safety recall for the fuel pump ( located inside the fuel tank / under the drivers seat). For whatever reason, my HRV is not included in the recall but suffers from the exact same problems as the recalled vehicles. This has happened numerous times, in light traffic and in extremely heavy traffic where my life was put in danger by this stalling issue.

Filed May 6, 2026 · Brakes, Electrical · 28,000 miles · FL

The contact owns a 2023 Honda HR-V. The contact stated that all the warning lights were illuminated. The vehicle stalled upon starting. The vehicle was taken to an independent mechanic, where the fuse was replaced. The vehicle was repaired, but the failure recurred. While depressing the start button, the look in the rear mirror was displayed. The vehicle failed to start. The brake pedal was kicking back. The vehicle was taken to the local dealer, who was unable to determine the failure. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 28,000.

Filed Feb 27, 2026 · Electrical, Engine · OH

While stopped at a traffic signal, the vehicle failed to restart when the light turned green. On another occasion, the vehicle stalled during operation and would not start. The engine would crank but there was no ignition. This created a safety risk because the vehicle was disabled in traffic and unable to move out of the roadway, increasing the risk of a rear-end collision or other crash. The vehicle was towed to a dealership for inspection. The dealer diagnosed a failed Powertrain Control Module (PCM). The diagnosis indicated no spark and that the ignition coils were not receiving signal, although the crank sensor signal was present. The PCM was replaced, and the vehicle started and operated normally after replacement. No additional wiring, fuse, or grounding issues were identified. There were no prior warning lights, dashboard messages, or drivability symptoms before the failure occurred. The failure happened unexpectedly at approximately 52,889 miles. The replaced PCM is available through the servicing dealership if inspection is requested.

Filed Feb 12, 2026 · Engine · 37,000 miles · NY

The contact owns a 2020 Honda HR-V. The contact stated that while driving approximately 45 MPH or faster, and while driving uphill, the vehicle suddenly stalled. During the first failure, the message “Emergency – Stop Driving Vehicle” was displayed on the instrument panel. The vehicle was turned off and restarted, and the message was no longer displayed. The vehicle was then driven to the residence. The vehicle had stalled three times on three separate occasions. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.

Filed Oct 25, 2025 · Engine · MD

my name is [XXX] . My address is [XXX] , phone number [XXX] . I purchased a 2018 Honda HR-V and on yesterday I was driving on the beltway when my engine stalled. The car slowed down n the dashboard became black. It happened at 415pm and I put hazard lights on. Traffic was moving fast and I had just a small area to pull over. I turned the car key off and started the car again n proceeded to drive again. It was very scary. I looked for recalls with my vin number and didn’t see anything. I looked at the issues with my type car n that’s one issue with engine stalling for fuel pumps. I have a full tank of gas. I travel out of town a lot. I need you to add my car to the recall for fuel pump issue. Here is the vin number: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 25, 2025 · Fuel system · NY

My car keeps stalling. It stalled on me about 10 times already. It keeps happening when I’m driving slow and on a stop light. I took it to 2 mechanics and they said the system is not showing anything. I took it to the dealer and said the same thing. The dealer had my car for 3 days, trying to test drive it but they said nothing happened and they don’t know what’s wrong. I took the car back, drove it the next day and it stalled on me again. It stalled on a parking lot, it stalled on a stop light 4 times today 9/25/2025. I took it to another mechanic and they said it’s the fuel pump. They told me that 2020 Honda HRV had recalls for the fuel pumps but my car VIN is not part of it.