2021 Honda Pilot tires problems

Filed Mar 29, 2026 · Tires · TX

I am reporting a safety defect involving Continental CrossContact LX Sport tires, size 245/50 R20 used on my 2021 Honda Pilot. These tires are not currently included in the existing Continental recalls, but they are showing the same types of failures described in the federal safety agency recall 21T‑001 and related Continental bulletins. Specifically, my tires developed cracking/localized tread wear/vibration and visible separation in the tread/sidewall area. This matches the recall descriptions of carcass breaks and belt‑edge separations that can cause sudden air loss or partial/full tread and belt loss, leading to loss of vehicle control and increased risk of a crash. I believe these tires were manufactured with a similar defect and should be investigated and included in the recall.

Filed Jan 13, 2025 · Tires · FL

Size of tires: 245/59 R 20, 102H DOT serial #: [XXX] The 2021 Honda Pilot came equipped with the tires in this discussion. At 30,000 mile check up at dealership, we were informed the 3 tires with this DOT number had “dry rot” and needed replacing. A fourth tire with a different number is in excellent shape. These tires are NOT on a recall list. Many of the Continental tires of this type have been recalled. Obviously since 3/4 tires are falling apart, it is not environmental or from road conditions or driving. These tires should be included in a recall. They are not safe and should last much longer than 30,000 miles of wear. We are going to have to replace them as soon as possible so they are not available for inspection. If they had failed, we could have crashed. There were no warning messages or lamps. I noticed they looked odd but it was just confirmed last week during the service visit that they had “dry rot” and needed replacing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 6, 2024 · Tires · NY

Traveling at 35mph in village. my passenger and I attest there was no road hazard. The tire popped and I managed to drive about 70 yards to a parking lot to change my tire. it had a clean tear on the inside sidewall. The tear had no marks made against it. I'm complaining since I see there have been 2 other similar complaints about this tire on this website.

Filed Feb 6, 2024 · Tires · PR

I am writing to formally address a concerning issue I have encountered with my vehicle’s front tires. Since the initial tire swap, I have observed significant degradation in the condition of the Continental Cross Contact LX Sport 245/50 R 102H tires. Specifically, I have noticed gradual chunking of the tire tread, occurring piece by piece. Upon bringing this matter to the attention of , I was informed that this issue falls within the purview of the manufacturer’s warranty. However, upon further communication with the manufacturer, I was informed that the observed deterioration is attributed to road conditions in my locality rather than a manufacturing defect. I am deeply concerned as my SUV has only accumulated 29,000 miles, yet the tires exhibit a severe lack of tread thickness, rendering them nearly unusable. Given the discrepancy in responses between the dealer and the manufacturer, I seek clarification and resolution to this matter at the earliest convenience. I kindly request a thorough investigation into the root cause of the tire deterioration and a comprehensive assessment of its eligibility for warranty coverage. Additionally, I urge for prompt action to rectify this issue to ensure the safety and performance of my vehicle. I appreciate your attention to this matter and look forward to a swift resolution.

Filed Jun 27, 2023 · Tires · FL

On 6/23/23, my wife was driving on a street & was changing lanes (from left to right) when the driver-side rear tire suddenly ruptured. She heard a loud pop coming from the tire and immediately scanned for a car impact or debris on the road—but neither was present. The vehicles within her proximity yielded to allow her to pull out of the street and into a safe parking lot. Since our children were in the car, she confirmed that they were safe. Upon my arrival, I could see a visible tear in the side wall of the tire. It is apparent that the tire side wall tore so rapidly that when the rim hit the asphault of the street its impact was so hard— that it left a gaping hole in the rim! Our family’s safety was in jeopardy because had vehicles not yielded , a crash may have been inevitable. Our local dealer has recommended reaching out to the tire manufacturer for a possible claim. There were no warning lamps prior to this incident.

Filed May 7, 2023 · Tires · CA

I was researching recalls on my 2021 Honda Pilot and came across the federal safety agency Campaign number 20V725000. When i inspected my tires I can confirm that they are the ones in question as they are the Continental CrossContact LX Sport tires with tire size 245/50 R20 102H and DOT serial number of A376. When I brought the vehicle into the dealership over the weekend they were dismissive and stated they only have one recall on the vehicle. I have explained my concern to a body shop previously and they recommended I do some research to see if any recalls are in effect, to my surprise I located this from the federal safety agency. I showed them the federal safety agency campaign number 20V725000 and they were dismissive. I went on to inform them that my tires match what is outlined and this is a safety concern for me. I have had issues with the tires losing pressure and I have had them rotated on a regular basis. I have not looked specifically at the spare tire, but I am asking that to be remedied as well if I have a full size spare that matches the recall. The tires have lost air suddenly where I have had to go into a tire shop or a gas station to add air routinely on occasion. It is hit and miss when it needs to happen and the weather is consistent, so now sudden change in temperatures to warrant this.

Filed Dec 20, 2022 · Tires · MA

I have Continental cross contact 245/50 R20 104H. Upon 1 year inspection of the vehicle I was told all 4 tires need to be replaced and the vehicle is failing inspection. At the time the vehicle, which is a newer lease, had 30k miles on it. I’ve never owned a vehicle of any kind that has needed 4 new tires in just over 1 year. The garage is saying he has seen this issue before because the tires are too soft for the type of vehicle. I’ve managed to find the identical tires recalled just 2 weeks before the tires on my vehicle. I found recall date 2920 and my tires are 3120. It’s hard to image the same tire, manufacturer, and location didn’t have a recall issue they were unaware of just 2 week Ma later. It seems more likely it hasn’t been reported yet with that date.

Filed Dec 19, 2022 · Tires · 29,000 miles · IN

The contact owns a 2021 Honda Pilot equipped with Continental Tires, Tire Line: Crosscontact LX Sport, Tire Size: 245/50R/20, DOT: A376D3K92321. The contact stated while driving 35 MPH, the vehicle started jerking and the contact was able to pull over and notice that both front and rear passenger’s side tires experienced blowouts on the sidewall of both tires. The vehicle was towed to the dealer and the tires were replaced. The vehicle manufacturer was contacted and advised the contact to reach out to the tire manufacturer for assistance. The tire manufacturer was contacted but the contact received no response. The failure mileage was 29,000.

Filed Nov 3, 2021 · Tires · CA

Continental Cross Contact LX Sport tire size 245/50 R 20 102H has a crack on the sidewall, which caused sudden air loss. I can see there are recalls for Pilot tires. I think this tire should be reviewed as well.

Filed Oct 19, 2021 · Tires · IL

Purchased vehicle in August 2021. Discovered that driver side rear tire was completely flat while parked in my driveway. Noticeable gash in sidewall of tire Continental Crosscontact LX A376 D3K9 2321; 245/50R20 102H. Dealership had no explanation for the gash and since no recalls, had to pay nearly $300 for a new tire on a vehicle that was driven 2 months since purchased. My other tires are 2321, 2421, 2421, and the new tire is 4720. I saw there were two recalls for Pilot tires in the recent past and these tires should be reviewed as well.