Honda Pilot oil consumption problems

Filed Sep 29, 2026 · Engine, Fuel system · VA

While driving with my family in my 2021 Pilot on the interstate at 75mph, I felt a shudder while in traffic. Fortunately, I signaled to get over and cars around me responded, because the check engine light flashed on and off and the car shut off. We had enough time to roll to the side of the interstate safely because drivers around me were aware and considerate. The car would not restart so we had to tow it. The Pilot has been evaluated by an independent mechanic who says that a failure in the high pressure fuel pump caused oil to dilute gasoline. A full engine replacement is required. There was no prior warning of this issue. American Honda has been contacted for potential support. Early stage of that, but dealing with them has, so far, been great.

Filed Feb 26, 2026 · Engine · MA · crash

I bought my 2015 Pilot in 2024 and since then my local mechanic has told me I am burning oil and I have had to replace several spark plugs. I have had error codes like P0304 come up in conjunction with the replacements. I now have a total engine failure. I looked online after my failure and saw the VCM Warranty Extension, but I was never notified about it. I saw where the codes could come up as "misfires" but might actually be the engine failing. Component failure - engine Safety Risk - I was driving when it died. if i had not come to a complete stop i would have hit a snow covered rocky hill. Inspections - awaiting insurance inspector, engine failure confirmed by mechanic. Warnning - no lights were on when it happened.

Filed Feb 13, 2026 · Engine · CA

Component/System Failed: Engine – Excessive oil consumption (piston rings / internal engine components). The vehicle is available for inspection upon request. Description of the Problem: The engine is experiencing excessive oil consumption. During a monitored oil consumption test, approximately 0.9 quarts of oil were consumed over about 1,006 miles, which equals a consumption rate of approximately 1 quart per 1,118 miles. This rate is abnormally high and indicates an internal engine defect, likely related to piston rings and/or sealant failure. Safety Risk: Excessive oil consumption creates a significant safety risk. If the oil level drops too low between oil changes, it can lead to engine failure, sudden loss of power while driving, engine seizure, or stalling. This could place the driver and others at risk, especially at highway speeds or in traffic. There was no visible oil leak. The oil is being burned internally. Inspection / Confirmation: The issue has been monitored through an oil consumption test. Dealer diagnosis indicates internal engine repair is required (piston and seal-related repair). Estimated repair cost is approximately $6,000. Warning Lamps or Prior Symptoms: No external oil leak was present. Oil level dropped significantly between checks. (If applicable, add: “Oil warning light did/did not illuminate.” If unsure, write: UNKNOWN.) Manufacturer / Other Inspections: Vehicle has been inspected by dealership service department. (If Honda corporate has been contacted, add that here.) Additional Information: The repair cost is excessive for a defect involving internal engine components and appears to be a known oil consumption issue.

Filed Jan 10, 2026 · Brakes, Engine · OH

Repeatedly there has been a cylinder 1 misfire causing the check engine light to activate. The vehicle starts to shake and idling is rough. It has happened repeatedly over the past 3-4 years. In 2025 it happened in August, October and December despite repeated maintenance. Error codes that have popped up due to the issue primarily include cylinder 1 misfires a known and documented issue related to the faulty VCM system. The problem has repeatedly been identified by multiple mechanics. I use my vehicle primarily to transport my children to and from school. We have all been in the car during these misfires endangering their safety. At many of the times when the misfires have happened my children have been in the car and any engine failure while operating the vehicle puts them in danger. My children are ADHD/autistic and during the times the vehicle has broken down while driving it has caused them extreme distress. The vehicle is available for inspection at any time. I have reached out to Honda repeatedly to have the issue resolved however despite repeated promises the vehicle would be fixed due to recalls and extended warranties Honda officials have repeatedly made erroneous claims and insist my vehicle's vin needs to be approved for any repairs. This is a well documented known issue for this make and model due to the faulty VCM system causing oil to get into the cylinders leading to the misfires and piston ring wear and corroded spark plugs. All I am requesting is for Honda to make the necessary repairs so my vehicle is safe to transport my children. I have kept up with the maintenance of the vehicle. The problems we have experienced are directly caused by the known VCM/MIL failures. Also we have consistently had codes come up for the ABS as well. Under the Magnuson-Moss Warranty Act Honda is responsible for making the repairs.

Filed Nov 17, 2025 · Fuel system · CA

My 2012 Honda Pilot is experiencing the same engine defect that Honda acknowledged in later model years (2013–2015) and issued recalls/extended warranty coverage for. The defect involves the Variable Cylinder Management (VCM) system causing excessive oil consumption, spark plug fouling, cylinder misfire, rough idle, fuel odor, and drivability issues that create an unsafe driving condition. I brought the vehicle to a Honda dealership in 2023 due to rough idle and a strong fuel smell — symptoms consistent with Technical Service Bulletin 13-082 for misfire and piston ring failure in 2009–2013 Honda Pilots. The dealer did not repair the issue or disclose that this matched a known defect. The vehicle now exhibits severe engine performance issues that pose a safety risk, including hesitation, engine shuddering, loss of power during acceleration, and strong fuel odor that may indicate improper combustion. Honda has issued recalls and warranty extensions for the identical defect on 2013 and newer Honda Pilot models with the same 3.5L V6 VCM engine but refuses to repair or acknowledge the defect for my 2012 Pilot, even though it uses the same engine architecture and has the same symptoms. This discrepancy indicates a potential gap in recall coverage that leaves owners of 2012 Pilots with a known safety-related defect unprotected. I am requesting that the federal safety agency investigate why the 2012 Pilot was excluded, despite identical engine design and failure patterns.

Filed Sep 23, 2025 · Engine, Fuel system · CA

The catalytic converter system on my vehicle is failing prematurely due to the vehicle’s built-in fuel management and energy-saving computer settings. These settings cause excess fuel to be burned and pushed into the catalytic converter, damaging the unit. In addition, this flaw is causing oil to be pushed out of the car, creating both a mechanical hazard and an environmental concern. This is not the result of poor maintenance or misuse — it is a hazard caused by a design flaw in the system itself.

Filed Jul 7, 2025 · Engine · CO

Car had a low oil light and started a knocking noise on 6/6. Stopped vehicle and had it towed to dealership on 6/7 report came back with a connecting rod problem. No further inspection after that. Was made aware that there is a current recall on my vehicle specs but not my specific vin number.

Filed Jun 14, 2025 · Engine · TN · fire

According to the Honda dealership of Winchester, West Virginia, an engine rod came through back of block and into oil plan, causing oil to leak on exhaust, which then caused the car to catch on fire. My daughter was driving and her safety was at risk. There were no warning signs about this prior to the incident. We had just driven the car from Nashville to West Virginia with no problems. I was told that there was a recall for this for 2016 Honda Pilots, but that my VIN was not included. This has cost me $215.31 in car rental fees, $169.38 in Uber fees, $1661.35 in auto transport and towing fees, $165.99 inspection from Honda. I'm still waiting on final costs for a new engine; I was quoted $12K from Honda; trying to find a cheaper alternative.

Filed Dec 6, 2024 · Electrical, Engine · FL

I was driving and I began slowing down as I approached a red light. My vehicle suddenly stopped. I was unable to turn the vehicle back on nor change the gear. When I would press the start button while pressing the brakes, some dash lights would turn on but again I was not able to change the gear. After several attempts of turning the car on, the car started and I was able to change gears to Drive. Approximately one or two blocks later, while in motion, the car abruptly stopped again. This time the dash displayed “Engine Oil Pressure Low” Stop Engine. Do not Drive”. The car was subsequently towed to a nearby Honda Dealership where an inspection was allegedly done and the issue was supposedly fixed. The service notes stated the vehicle was found with low oil levels and that no leak was found. They released the car back to me. Now, one week after I picked the car up from the Honda Service Department, I encountered the same issue again. While stopped in traffic, my vehicle shut down. I was unable to turn it back on nor change the gears. An orange steering wheel with an orange exclamation mark next to it popped up on the upper right hand corner of my dashboard along with a red battery logo below it. I was on the roadway unable to turn the car back on for approximately one hour. After continuous failed attempts to turn the car on and change the gear, at one point it turned back on and I was able to drive the car.

Filed Jul 9, 2024 · Engine · GA · fire

A rod bearing in the engine failed and broke through the side of the engine block damaging the catalytic converter and causing oil to spray every where and the engine to seize and catch fire.