Honda Pilot windshield crack problems

Filed Sep 25, 2026 · FL

In April 2026 we had a windshield crack that appeared spontaneously and went horizontally over half of the windshield. It occurred while the vehicle was parked in a garage. There could have been a rock or other object that had previously hit the window, we are not sure. The windshield was replaced through an insurance claim. On 9/23/26 we got in the vehicle to notice a vertical crack running from the very top of the windshield to the bottom. This occurred while the car was parked overnight. We had driven the vehicle the previous day and the crack was not there. Two days prior we had cleaned the windshield and there were no dings or marks but we did notice a ding at the very bottom of the windshield in the darkened portion. That could have happened the previous day but we do not recall anything hitting the window. We are concerned there is a defect with the windshields in this Honda model because we had two very large cracks in less that six months that occurred while the vehicle was parked.

Filed Aug 12, 2026 · Visibility · LA

I am writing to formally report a potential safety-related defect involving the front windshield of my 2025 Honda Pilot. The windshield has demonstrated what I believe to be an abnormal susceptibility to cracking and chipping under what appear to be normal driving conditions, including ordinary interstate highway travel. The damage has occurred from relatively minor road debris and/or without a significant impact that would reasonably explain the severity or rapid progression of the cracking. I contacted Honda regarding this issue and requested assistance with the windshield repair/replacement as well as further investigation into whether there may be a defect involving the windshield glass, its installation, mounting, or related vehicle components. Honda declined to provide assistance or initiate any further investigation. My concern is not simply that windshield glass can occasionally be damaged by road debris. Rather, I am concerned that the windshield may be unusually susceptible to cracking under conditions that should reasonably be expected during normal operation of the vehicle. A windshield is a critical safety component, and repeated or unusually easy cracking could potentially affect driver visibility and the structural integrity of the windshield. I am also aware of other reported complaints involving windshield cracking on 2025 Honda Pilot vehicles. The existence of similar reports raises additional concern that this may not be an isolated incident and that the issue may warrant further investigation. I respectfully request that Honda: 1. Review the circumstances surrounding this windshield failure; 2. Determine whether similar windshield complaints have been reported for the 2025 Honda Pilot; 3. Investigate whether there may be a defect involving the windshield glass. Because the windshield is an essential safety component, I believe this matter deserves more than a determination that the damage is simply ordinary road debris.

Filed Jul 13, 2026 · NJ

Front windshield was cracked on 1/21/26. It was replaced right after by a new Honda windshield and it was installed at a Honda dealership. On 7/6/2026, I found a chip in my windshield again. It feels that the windshield from Honda has a bad quality

Filed Jun 18, 2026 · Driver assistance · PA

Windshield cracked majorly after being hit by a small rock on the highway. Even after having it replaced and the camera recalibrated, 7 safety warnings of the ADAS come on. Reportedly, the frontcamera has failed, which is concerning in a car that has less than 50k and is just about 4yrs old. I believe this is a larger issue, the windshield truly should not have broken that easily and the camera failing so soon is problematic. It is also a very expensive fix.

Filed May 26, 2026 · Visibility · FL

four cracked windshields while driving from debris hitting windsheild

Filed May 25, 2026 · VA

My front windshield cracked without any impact. I noticed quite a few honda pilots on the road with almost the exact same crack. It started on the passenger side and went completely across to the driver's side.

Filed Dec 29, 2025 · Visibility · 5,000 miles · NY

The contact owns a 2025 Honda Pilot. The contact stated that the front windshield was cracked. The contact stated that a rock or stone had most likely hit the windshield. The vehicle was taken to the auto glass center, and the windshield was replaced. After the repair, the contact noticed that the windshield was cracked at its base. The contact noticed that the lower half of the windshield was cracked, and the crack expanded from one inch to three inches rapidly. The vehicle was taken to the auto glass center, where the contact was informed that the glass needed to be replaced. The vehicle was taken to the local dealer, who declined to take responsibility and referred the contact to the insurance company because the VIN was included in a related recall. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 5,000.

Filed Nov 20, 2025 · Visibility · PA

My 2025 Honda Pilot (purchased Oct 2024) has experienced three windshield cracks, all starting in the same lower driver-side corner near the inspection stickers. 1st crack – July 2025: A long horizontal crack appeared overnight while parked, with no impact point at all. Dealer claimed “impact damage” and refused warranty. 2nd crack – August 2025: After paying for an OEM replacement and Honda Sensing calibration, the new windshield cracked on the drive home from a very small road debris impact. The star-shaped crack spread rapidly to the edge. Glass shop staff informally said the first crack looked like a stress crack. They replaced the glass again with OEM and calibrated, offering their labor for free. Dealer declined to pay even for only glass itself and told us to talk to Honda USA. We contacted Honda USA by phone, received a case number, and were told to “deal with the dealer.” The dealer then told us to contact Honda USA again. Neither party investigated, and both said the windshield is “not covered.” 3rd crack – November 2025: A tiny debris impact again caused a crack in the same exact corner. The impact chip was extremely small, but the crack still spread more than normal. All photos attached with repair invoices. We paid out of pocket as our insurance does not cover OEM glass. The repeated cracking in the identical corner, including one with no impact, suggests a possible structural stress point, mounting issue, or overly thin/brittle OEM glass. I also found another the federal safety agency complaint from June 2024 reporting similar cracking on a 2025 Pilot. These repeated failures pose a visibility and safety risk on a new vehicle.

Filed Sep 22, 2025 · Driver assistance, Electrical · MD

2019 Honda Touring: driving down the highway the windshield would crackle ( Electricity) then we started experiencing transmission delays in shifting and the transmission sounded rough and it was delayed. when the car was put in park the whole dashboard lit up with emissions system problem, Stop driving when safe. transmission problem, Blind spot info system problem. after this showed up the car was not able to move at all. it would not move to gear. the problem was not reproduced at the Honda dealer. They recommend replacing the transmission. I had it towed to another shop where they tell me all codes that pertain this the initial issues stated and refer back to dealer to reset the tmc system failure and to reset the electrical system. Honda refuses to do work as they want to replace the entire transmission

Filed Aug 20, 2025 · Visibility · CA

While parked, I heard a pop. Later on there was a crack in the windshield around the camera. Nothing impacted the windshield this looks definitely like a stress fracture but the dealership was not helpful.