2008 Hummer H2 problems

What is wrong

Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). A recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. However, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. These incidents resulted from a new failure mode attributed to the device's thermal protection feature. The significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber.

Risk

It is possible for the heated washer module to ignite and a fire may occur.

Remedy

Dealers will permanently disable and remove the heated washer fluid module. An updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. The safety recall began on june 11, 2010. Owners may contact buick at 1‑866‑608‑8080, cadillac at 1‑866‑982‑2339, chevrolet at 1‑800‑630‑2438, saturn at 1‑800‑972‑8876, gmc at 1‑866‑996‑9463 and hummer at 1‑800‑732‑5493 or at the owner center at www.gmownercenter.com.

Recall number 10V240000 · Recall details

What is wrong

Gm is recalling 857,735 my 2006-2008 buick lucerne; cadillac dts; hummer h2; my 2007-2008 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl, saturn outlook; and my 2008 buick enclave vehicles equipped with a heated wiper washer fluid system. A short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire.

Risk

This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire.

Remedy

Dealers will install a wire harness with an in-line fuse free of charge. The recall began on september 12, 2008. Owners may contact buick at 1‑866‑608‑8080; cadillac at 1‑800‑982‑2339 or http://www.cadillac.com; chevrolet at 1‑800‑630‑2438; saturn at 1‑800‑972‑8876 or http://www.saturn.com, gmc at 1‑866‑996‑9436; or hummer at 1‑800‑732‑5493; or through their website at http://www.gmownercenter.com .

Recall number 08V441000 · Recall details

What is wrong

On certain trucks, the wires in the ABS wheel speed sensor front or rear harness may be reversed.

Risk

This condition could result in increased stopping distance increasing the risk of a crash.

Remedy

Dealers will correct the ABS wheel speed sensor wiring and, if necessary, reprogram the brake control module free of charge. The recall began on september 27, 2007. Owners may contact hummer at 800‑732‑5493.

Recall number 07V373000 · Recall details

In a letter dated august 27, 2008, general motors corp. (gm) notified the federal safety agency that it will conduct a safety recall (the federal safety agency recall number 08v‑441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. According to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. This may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. In addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v‑441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. Gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed.

EA08010

In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles.

PE08010