2020 Hyundai Elantra: engine failure

Filed Oct 7, 2026 · Engine · CA

2020 Hyundai Elantra, VIN [XXX], ~79,239 mi. On or about [XXX], while entering a parking lot at low speed on an incline, I pressed the accelerator but the car had severe power loss and then stalled. It would not move in reverse. All dashboard lights came on only after the stall. I restarted it; the lights cleared. It was towed to Westlake Hyundai, 3610 Thousand Oaks Blvd, Thousand Oaks, CA 91362; checked in Sep 29, 2026 8:59 AM. Dealer found engine oil below the low mark, no external leaks, DTCs P0302/P0304 (misfires cyl 2 & 4), and all spark plugs worn/fouled. They replaced the plugs and started an oil consumption test per TSB 23-EM-008H. Critical safety issue: the oil pressure warning light never illuminated before or during the stall, despite critically low oil. This removed my only warning to pull over safely. A sudden stall in traffic could cause a crash. The vehicle has the 2.0L Nu MPI engine covered by Recall 21V301 for defective piston oil rings causing excessive oil consumption and engine failure. My VIN is not included, but it shows the same failure. Vehicle is available for inspection. No police/insurance inspection. Manufacturer not yet inspected. Concern: engine defect and oil pressure warning system failure. Attached: Westlake Hyundai repair order/inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 29, 2026 · Engine · FL

Back in early July, I noticed a ticking sound coming from my engine so when I took it in to a Hyundai dealership, they told me the only way I could pursue any help further was by completing a oil consumption test, which I complied and paid for out-of-pocket very soon after within 48 hours my check engine light came on and was flashing. after pulling the code at an AutoZone which I have documentation of it was a P 1327 which signals that the car had entered limp mode. I very quickly reached out to Hyundai themselves and after going back-and-forth on paperwork, they assured me that since I had no coverage on the vehicle due to its mileageand that it was not produced in the same factory as the other recall vehicles with that same problem that they could not pay or help me with any of the services I would need done to my engine. They told me the only chance I had was by completing the oil consumption test, which would then put me and my safety at risk by driving a car with a faulty engine while it was also in limp mode. I’ve only had the car for about a year and a half when it threw the first sign at me and I’m now struggling to figure out how to afford a completely new engine all on my own with no financial assistance all because my car was not made in the same factory as all the other ones that have had the same issue. I have not been able to drive the vehicle in the last two months and it just put me into financial deficit, trying to figure out reliable transportation to get to my current employer. It also states that the previous owner must have had an engine inspection/replacement but was not specified of which specific action was taken on the official Hyundai website.

Filed Sep 10, 2026 · Engine · CA

The vehicle entered limp mode. The Hyundai dealer diagnosed a camshaft problem, said the repair would be covered, ordered the part, and began the work. After the engine was opened, the dealer noted sludge/varnish and denied coverage, claiming lack of maintenance. This VIN is included in safety recall 21V301 for improperly heat-treated piston oil rings on the 2.0L Nu MPI engine. Hyundai told the federal safety agency that chipped rings can scuff the cylinder bore, cause accelerated oil consumption, knocking, oil-pressure warning, connecting-rod bearing seizure, stall, and in limited cases fire. The published remedy is inspection of the cylinder bore and piston skirt, engine replacement if damage is found, and PNSS software, at no charge. Hyundai National Consumer Affairs Case #XXX. I sent a written demand that they complete Campaign 203 and not convert an open safety recall into a customer-pay job. On XXX, case manager Mohammad issued a letter denying only “limited warranty” coverage for lack of Owner’s Manual maintenance. That letter does not state whether the Campaign 203 bore/skirt inspection was done, does not state whether PNSS was installed, and does not decide the incomplete recall. Oil and filter were changed on a regular schedule by the owner’s family using the specified oil. A signed affidavit was provided. Hyundai’s warranty does not require dealer-only oil changes. The symptom of the recalled oil-consumption defect (varnish/sludge) is being used to refuse the recall remedy. The vehicle remains unrepaired. I have not authorized customer-pay work or disposal of parts. What I want the federal safety agency to do Record this as an incomplete recall remedy. Require Hyundai Motor America to complete Campaign 203 on VIN [XXX]: perform the official bore and piston-skirt inspection, replace the engine if abnormalities exist, install PNSS, and cover related camshaft/engine damage found when the engine was opened, at no charge. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 2, 2026 · Engine · 46,961 miles · CA

The contact owns a 2020 Hyundai Elantra. The contact stated that while driving 25 MPH, there was an abnormal rattling sound coming from the engine, with the check engine warning light illuminated. The contact pulled over to the side of the road. The vehicle was restarted but unexpectedly stalled. The vehicle was taken to an independent mechanic and was diagnosed with camshaft failure. The vehicle was towed to the dealer and was diagnosed with engine failure caused by a misfire. The contact was informed that the engine needed to be repaired. The vehicle was not repaired. The vehicle was taken to another independent mechanic and was diagnosed with camshaft failure. The manufacturer was not made aware of the failure. The approximate failure mileage was 46,691.

Filed Jul 28, 2026 · Engine · AZ

"I was not notified of Campaign 974 and later experienced engine problems/failure. I am requesting review of whether the campaign was completed and whether the failure is related to the condition the campaign was intended to detect. My engine failed while pulling up to a house, stopping, then preparing to move again the car stalled, car stalled, car would not start for several times tried, then started was able to drive for about 10 miles then stalled again and would not start, car has been intermittently working, car has recent and regular oil changes on time with correct oil and still failed now there is metal in the oil per the mechanics there is knocking sort of like ticking sounds - the car left me stranded due to the engine intermittently working and not working to start the car - the car will attempt to start then turn right off immediately after starting the car and sometimes not turn over the car also had been jumping when in stopped positions as soon as attempt to give gas ever so slightly

Filed May 26, 2026 · Engine · 105,000 miles · CA

The contact owns a 2020 Hyundai Elantra. The contact stated that while driving, the vehicle unexpectedly stalled. The vehicle was able to restart. The check engine light illuminated. The vehicle was taken to an independent mechanic Camshaft sensor failure. The camshaft sensors were replaced; however, the issue persisted. The vehicle was then taken to the dealer where it was diagnosed with engine failure but the vehicle was not repaired. The manufacturer was notified of the issue. The contact associated the issue with the federal safety agency Campaign Number 21V301000 (Engine). The approximate failure mileage was 105,000.

Filed Apr 27, 2026 · Engine · FL

My engine failed due to a known piston problem code P1327. The recall 203 was performed 7/1/22 which put in a sensor so the dealership said that Hyundai said they do not have to fix it because it is out of warranty at 141,000 miles and was manufactured in South Korea so they say it doesn't qualify for the extended warranty Recall 203 Dealer Best Practice Date: October 12, 2021 Subject: HMA Recall 203 – Nu 2.0L Atkinson Engine Inspection and Replacement - (TSB #21-01-054H-1) - Remedy Available v3 Updates To This Document Date • TSB# 21-01-054H-1 – The TSB supersedes TSB # 21-01-054H to revise the Parts and Warranty Information sections, specifically related to add engine and service kit part numbers and op codes for engine replacement. 10/12/21. My car is available for inspection. The sensor light came on on the highway when the engine was already out of oil which caused the failure. The car could have caught fire or stalled on the highway which is the safety issue. The vehicle was inspected by Tires Plus and got the P1327 code and also the Wallace Hyundai dealer in Ft. Pierce, FL which got same code.

Filed Apr 16, 2026 · Engine · IA

The check engine light came on at 101000 miles. I took it to the shop and the mechanic said there was no oil on the dipstick and he put in oil and said we need a new engine because it is knocking. We have noticed the vehicle has a rough idle now.

Filed Apr 6, 2026 · Electrical, Engine · PA

Within a matter of a few days my car has been stopping by itself. The car was smoking and stopping in the middle of the highway, my dealership is proving me with a new engine but is trying to have me come out of pocket for an fuel injector, please help !

Filed Jan 20, 2026 · Engine · TX

This vehicle’s engine failed on 10/25/21. This was 2 months after it was purchased. When we tried to have a Hyundai dealership diagnose the car, they said it would be an extended amount of time before the could look at it. When they finally did, they said it was not eligible for the warranty or recall relief. I reached out to the Hyundai corporate office and received no assistance. They tried to say it was due to no drain plug. It was recommended that we take it to another dealership who said the same thing. We ended up paying out of pocket to replace the engine. The mechanic who replaced the engine said there was no oil splatter under the car that would indicate an oil leak. Now on 1/15/26, the 2nd engine has now failed for apparently the same recall. For either engine there was never any warning of low oil or any evidence under the car of a leak.

Filed Dec 30, 2025 · Transmission · NE

Was driving car after a recent oil change. The oil change was performed early because the car was ticking and found oil to be low. Was going to take into dealer to be looked into but the car made a loud sound and stopped immediately and turned off. Luckily I was not driving too fast but had I been this could have posed a risk to myself, my passengers and other drivers. This complaint is consistent with prior engine failure complains of other Hyundai models. The Elantra has yet to be investigated. The maintenance lights that came on have only been for a high mount break light and low tire pressure. I did not get a low oil or oil change needed alert.

Filed Dec 12, 2025 · Engine · CA

Subject: Abnormal Engine Failure – Hyundai Case #[XXX] I am filing this complaint regarding my Hyundai vehicle, which suffered catastrophic engine failure at approximately 150,000 miles. While the vehicle is outside the standard warranty, this type of failure is not consistent with normal use or expected durability. Hyundai Motor America has acknowledged receipt of my certified demand letter (Case #[XXX]) but has refused to provide coverage, instead directing me to pay for towing and diagnostic costs. This position is unacceptable given Hyundai’s history of abnormal engine defects and related settlements. Key points: • The failure is abnormal and consistent with systemic defects Hyundai has faced in prior litigation, including the Theta II and Lambda II engine defect class actions, which resulted in recalls and settlements covering millions of vehicles. • Hyundai has previously extended goodwill repairs and recall coverage for similar failures, even outside warranty periods. • Engine failure at this mileage presents a serious safety hazard, including risk of stalling, fire, or loss of power while driving. • Hyundai’s refusal to cover towing and diagnostic costs places an unfair burden on consumers and may violate consumer protection statutes. Requested Action: I request that the agency investigate Hyundai’s handling of abnormal engine failures, ensure compliance with consumer protection and safety laws, and require Hyundai to provide coverage or reimbursement for towing, diagnostic, and repair costs in cases where engine failure is abnormal and unsafe. Supporting Documentation: • Certified demand letter sent to Hyundai Motor America. • Hyundai’s written denial (Case #[XXX], dated December 11, 2025). • Vehicle mileage and details of engine failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)