2020 Hyundai Elantra: engine knocking or ticking

Filed Sep 29, 2026 · Engine · FL

Back in early July, I noticed a ticking sound coming from my engine so when I took it in to a Hyundai dealership, they told me the only way I could pursue any help further was by completing a oil consumption test, which I complied and paid for out-of-pocket very soon after within 48 hours my check engine light came on and was flashing. after pulling the code at an AutoZone which I have documentation of it was a P 1327 which signals that the car had entered limp mode. I very quickly reached out to Hyundai themselves and after going back-and-forth on paperwork, they assured me that since I had no coverage on the vehicle due to its mileageand that it was not produced in the same factory as the other recall vehicles with that same problem that they could not pay or help me with any of the services I would need done to my engine. They told me the only chance I had was by completing the oil consumption test, which would then put me and my safety at risk by driving a car with a faulty engine while it was also in limp mode. I’ve only had the car for about a year and a half when it threw the first sign at me and I’m now struggling to figure out how to afford a completely new engine all on my own with no financial assistance all because my car was not made in the same factory as all the other ones that have had the same issue. I have not been able to drive the vehicle in the last two months and it just put me into financial deficit, trying to figure out reliable transportation to get to my current employer. It also states that the previous owner must have had an engine inspection/replacement but was not specified of which specific action was taken on the official Hyundai website.

Filed Sep 10, 2026 · Engine · CA

The vehicle entered limp mode. The Hyundai dealer diagnosed a camshaft problem, said the repair would be covered, ordered the part, and began the work. After the engine was opened, the dealer noted sludge/varnish and denied coverage, claiming lack of maintenance. This VIN is included in safety recall 21V301 for improperly heat-treated piston oil rings on the 2.0L Nu MPI engine. Hyundai told the federal safety agency that chipped rings can scuff the cylinder bore, cause accelerated oil consumption, knocking, oil-pressure warning, connecting-rod bearing seizure, stall, and in limited cases fire. The published remedy is inspection of the cylinder bore and piston skirt, engine replacement if damage is found, and PNSS software, at no charge. Hyundai National Consumer Affairs Case #XXX. I sent a written demand that they complete Campaign 203 and not convert an open safety recall into a customer-pay job. On XXX, case manager Mohammad issued a letter denying only “limited warranty” coverage for lack of Owner’s Manual maintenance. That letter does not state whether the Campaign 203 bore/skirt inspection was done, does not state whether PNSS was installed, and does not decide the incomplete recall. Oil and filter were changed on a regular schedule by the owner’s family using the specified oil. A signed affidavit was provided. Hyundai’s warranty does not require dealer-only oil changes. The symptom of the recalled oil-consumption defect (varnish/sludge) is being used to refuse the recall remedy. The vehicle remains unrepaired. I have not authorized customer-pay work or disposal of parts. What I want the federal safety agency to do Record this as an incomplete recall remedy. Require Hyundai Motor America to complete Campaign 203 on VIN [XXX]: perform the official bore and piston-skirt inspection, replace the engine if abnormalities exist, install PNSS, and cover related camshaft/engine damage found when the engine was opened, at no charge. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 28, 2026 · Engine · AZ

"I was not notified of Campaign 974 and later experienced engine problems/failure. I am requesting review of whether the campaign was completed and whether the failure is related to the condition the campaign was intended to detect. My engine failed while pulling up to a house, stopping, then preparing to move again the car stalled, car stalled, car would not start for several times tried, then started was able to drive for about 10 miles then stalled again and would not start, car has been intermittently working, car has recent and regular oil changes on time with correct oil and still failed now there is metal in the oil per the mechanics there is knocking sort of like ticking sounds - the car left me stranded due to the engine intermittently working and not working to start the car - the car will attempt to start then turn right off immediately after starting the car and sometimes not turn over the car also had been jumping when in stopped positions as soon as attempt to give gas ever so slightly

Filed Apr 16, 2026 · Engine · IA

The check engine light came on at 101000 miles. I took it to the shop and the mechanic said there was no oil on the dipstick and he put in oil and said we need a new engine because it is knocking. We have noticed the vehicle has a rough idle now.

Filed Jan 6, 2026 · Engine · IL

Engine is stalling and consuming oil at a higher then normal rate. Knock sensor is having issues at 24k miles both part of recall campaign 974 and recall 203. Took the auto to dealer for service and was told Hyundai would not honor the recall due to a branded title which now puts me in a scenario of possibly engine stall in the middle of highway traffic.

Filed Dec 30, 2025 · Engine · NC

Reporting motor has a cold start ticking sound coming from the motor.

Filed Dec 30, 2025 · Transmission · NE

Was driving car after a recent oil change. The oil change was performed early because the car was ticking and found oil to be low. Was going to take into dealer to be looked into but the car made a loud sound and stopped immediately and turned off. Luckily I was not driving too fast but had I been this could have posed a risk to myself, my passengers and other drivers. This complaint is consistent with prior engine failure complains of other Hyundai models. The Elantra has yet to be investigated. The maintenance lights that came on have only been for a high mount break light and low tire pressure. I did not get a low oil or oil change needed alert.

Filed Sep 18, 2025 · Brakes, Engine · 101,000 miles · OK

The contact's mother owns a 2020 Hyundai Elantra. The contact was informed that the vehicle occasionally stalled without warning and would be immediately restarted to continue driving. Additionally, the vehicle would hesitate before slowly accelerating. The contact stated that there was a knocking sound coming from the vehicle at start-up, with a constant ticking sound coming from the engine compartment. The check engine warning light was illuminated. There were signs of an oil leak, and the oil needed to be changed more frequently. While changing the oil, the owner noticed smoke coming from inside the oil pan. The traction control warning light and the ABS warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed that the ABS module and piston rings in the engine had failed. The vehicle was not repaired. The contact became aware of the federal safety agency Campaign Number: 21V301000 (Engine); however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the vehicle was not covered under recall or warranty. The contact was referred to the dealer for assistance. The failure mileage was 101,000.

Filed Oct 7, 2024 · Engine · OK

My vehicle stalled. I was heading to work and vehicle just cut off while driving. The day before it had started making a strange knocking, clicking sound. It will not charge and will not start up. I have not contacted manufacturer and not inspected by manufacturer. I checked vin # but not on recall list. I have kept my car up to date with servicing.The noise it made when it started to stall was really loud and then cut off. My safety was put at risk because I take the highway to work everyday and almost reached the highway that day before it stalled. My car is used for taking my kids to school, doctors appts and work. I am thankful my kids were not in the car when this happened. It had to be pushed off the road in a high traffic area causing a safety issue.

Filed Jun 1, 2024 · Engine · AZ

The car starting knocking while driving and later found out it’s due to a knock sensor issue, at first the check engine light didn’t come on, days later it’s been blinking on and off since then.

Filed Mar 11, 2024 · Acceleration, Engine · NJ

Engine seized while going 55-60mph with warning lights only 15 seconds before my vehicle completely stopped on the highway [XXX] ) The engine was replaced by Hyundai along with the manifold and catalytic converter. Vehicle lost all control and power and started excessively knocking while I tried to get to the shoulder but only made it to the right lane. The safety of others and myself were out at risk due to no control of the vehicle. Repair order attached INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 21, 2024 · Engine, Transmission · NV

Took our vehicle to the local hyundai dealer on 1/30/2024 to have them look at the engine as my regular mechanic stated the "engine was knocking" at the most recent oil change, and get it to the dealer as it should be under warranty. Turns out it did need an engine which they replaced yesterday finally, however when they took it for a test drive they still heard noises. They examined it further and today they notified me it also needed a new transmission. This vehicle we have had since we bought it new in january of 2021, had less than 10k miles on it when we took it into the dealer on 1/30/2024. This is absolutely unacceptable. Thank goodness I had all my receipts to prove regular proof of maintenance esp since I have a regular guy and did not have it done at the dealers.