I started driving and pulled out of a parking lot onto a busy road. The ICCU had failed unknownst to me and as I was underway the car started losing power and the dashboard lit up with warnings about the electrical system. I was limited to 25 MPH for a brief time and struggled to turn off into a parking lot amongst much faster traffic. While doing this the car slowed further to 10 MPH. I limped at this speed into the parking lot at which point it turned off and lot all power. This happened over the course of about 30 seconds. If it had happened on a busier road I would have been in trouble. On the highway and it would have been extremely dangerous. It was dangerous enough as is with cars passing me 20+ MPH faster than my car could go. This all occurred with no warning, and is due to an issue with the ICCU in the car that Hyundai has known about for years and has refused to address or fix.
2025 Hyundai Ioniq 5 transmission complaints
Page 2 of 3: complaints 11 to 40 of 58, newest first, as owners wrote them.
ICCU fuse blew during operation, car went into limp mode. Vehicle is currently being serviced under warranty through Hyundai
The Integrating Charging Control Unit (ICCU) failed while attempting to accelerate onto an Interstate Highway. The car then went into 'Limp' mode which only allowed a sped of 20 mph. Luckily I was able to get to the next exit without getting hit by car already on the highway going ~60-70 mph. The car showed both a 'battery warning' and a 'car over heating' symbol (the car has no engine, so assume it was the battery that over heated). The ICCU was recalled by Hyundai in the 2022-2024 Ioniq5 models, but was not recalled in the 2025 model (which I own). My suggestion is that the 2025 Hyundai Ioniq5 should be added to the the same recall as the 2022-2024 models since it is exhibiting the same problem.
1 Vehicle fails to start x 6 , dealer unable to fix, falsely identified 2 documented DTCs P31C507 specifically indicates a "possible condition with your Vehicle Control Unit (VCU) / Low DC-DC Converter (LDC)" dealer stated as charger problem when this is often associated with thousands of ICCU problems in this vehicle 2 many ADAS cruise control faults. A vehicle slows and, once stopped, at freeway speed on corners or when a large vehicle is in a nearby, separate lane. Fails to detect the vehicle in the next lane when activating lane change. 3. Keys and door locks fail electronic unlock and falsely lock the vehicle on approach. 4 decreased charging speed associated with a known prevalent main battery failure, and occasional main battery cell differential. 5 voice commands fail in the native and CarPlay app 6. Dealers unable to fix, give a delayed 2-week appointment and state that the car is out of service for a week or more with a loaner vehicle.
The ICCU (and the associated fuse blew) while I was driving and it caused the car to be slowed immediately to approximately 20 MPH. This apparently is a huge issue with this vehicle.
The vehicle exhibited charging failures on multiple occasions over the course of several days after being connected to a Level 2 home charging unit overnight. On repeated mornings, the high-voltage battery was found to have not charged. The vehicle also exhibited intermittent slow charging behavior during this same period. Approximately six months prior to the charging failures, the 12-volt auxiliary battery was found to be completely discharged. During this same period, the vehicle was started on one occasion to find that every warning and alarm indicator on the dashboard had triggered simultaneously. The vehicle was completely inoperable at that time. After several minutes, all warning indicators cleared and normal operation resumed without any intervention. The vehicle was brought to an authorized Hyundai dealership on March 6, 2026, where the technician diagnosed the root cause as a failed Integrated Charging Control Unit (ICCU). The ICCU is responsible for managing both high-voltage battery charging and maintaining the 12-volt auxiliary battery; a failure of this component can result in loss of charging capability, auxiliary battery drain, and potentially a complete and sudden loss of vehicle operability. As of the date of this report, the vehicle is awaiting parts with an estimated repair time of approximately one week. The repair is expected to be covered under the manufacturer's warranty. This failure occurred with fewer than 10,000 miles on a 2025 model year vehicle. Based on publicly available owner reports and online forums, ICCU failures appear to be a recurring issue across multiple Hyundai IONIQ model variants.
While driving, car displayed a check electrical vehicle system warning light. The 12 volt battery completely died and could not maintain charge resulting in slower and then complete loss of propulsion. Towed to dealer and the following Monday determined it was an ICCU failure. Part is back ordered but verbally told on 2/24/2026 that part would be delivered in two weeks. We'll see!!! If this issue occurred while driving on an interstate at full speed with traffic it seems this might result in an accident since the max speed dropped to 25 MPH and then 12MPH after warning before being able to safely pull over.
While attempting to leave home, the 'Check Electrical System' warning came on. The vehicle entered a 'safe mode' and was unable to accelerate. The car was towed, and the dealer confirmed a complete failure of the ICCU and associated fuse (DTC P1A9096). This is a known issue (Recall 24V‑204) and created a dangerous situation.
I was on the highway going at approximately 60mph when the car without any warning reduced speed to first around 40mph and then to 20mph all within a matter of a few minutes, causing me to pull over to the side of the highway. Luckily, I wasn't injured. I exited the highway, called my insurance company Geico and had the vehicle towed to the dealership where I leased this brand new vehicle from just about 7 months ago on a 2year lease. The dealer was kind enough to provide a smaller loaner vehicle but had no idea when my car would be returned, as there were others with similar failures ahead of me that were waiting for the part to arrive. Apparently, this is a known failure issue of the ICCU that Hyundai has done a poor job of addressing. I continue to make my lease payments while waiting for the part to arrive. In the meantime, I wanted to let the government know of my experience and how this could have had a disastrous effect on my family and other families with a similar build.
The ICCU failed under normal utilization The vehicle went into limp mode which changes expected driving dynamics The dealer confirmed ICCU failure and the manufacturer has confirmed the vehicle is a lemon as per MA state law No warnings prior to the failure
ICCU failure at 5308 miles. heard a loud pop while driving and 12v warning system errors
ICCU confirm dead by the dealer. IONIQ 5 2025 AWD. only had this car for 5 month, 4900 miles. vehicle stopped at the middle on the highway. luckey, no accident occur. no part avilable, no ETA for fix, no loaner from dealer.
ICCU failure causing the vehicle to be inoperable
The 12V system battery failed to keep a charge and the vehicle slowly reduced maximum speed until it fully died causing the car to coast to a stop on a 55MPH highway. At 9,500 miles on the odometer the ICCU has failed. The part is on backorder and my car has been in the shop for three weeks with no estimated completion date. A LOT of IONIQ 5 owners are encountering the ICCU failure.
Main battery failure, can not charge, can not drive car. Warning light(s) on dashboard. High voltage battery needs to be replaced.
Vehicle experienced a dashboard alert, "Check electric vehicle system." The car produced an OBD code: P1AD3(00). Upon taking it to the dealer, they determined that the EV required a new high-voltage battery.
ICCU needs to be replaced.
What failed: On February, 6, 2026, I experienced a complete failure of my Ioniq 5's electrical system due to the ICCU failing. Heard a loud "pop" and eight seconds later it reported a warning to check the vehicle's electrical system and 24 seconds after the pop it then chimed repeatedly saying to pull over immediately and come to a complete stop. The vehicle is currently at a nearby My safety: Once I was able to hobble the car off the side of the road, it left me in a dangerous situation. The vehicle was such in a state that the hazard lights were not operational and I had no way of getting any heat. (It was 20F with a wind chill down to 14F.) It also happened in a bad part of town, meaning that I did not want to leave the vehicle unattended for a tow truck. This also occurred 60mi from home. Reproduced: The dealership it was towed to is not open until Monday, February 9, 2026 but the tow's rescue battery made the system run enough to report the Diagnostic Trouble Code of "P1A9096". Doing a quick search online for that shows a number of cases with the same problem. While waiting for the tow, I tried to start the car a number of times to no avail. Inspected: Not yet, see "Reproduced" section above. Any other signs/symptoms? Nothing until the "pop" itself. Once that happened, basically every warning icon showed up on the instrument cluster/screen.
2:27 pm on 02/06/2026. Pop heard from the trunk area, then displayed "Stop vehicle and check power supply," the car lost power and then became completely immobile. The car has 3500 miles on it. Bluelink app showed "Everything looks good."
ICCU failure
I was at the grocery store and when I returned to my car and started it, I had an error message on the dashboard regarding the vehicle battery. When I put it into reverse, I heard a loud pop and received another error message. The car would only drive at 25 mph after that. I tried to drive home but the car died after a few miles and I was stranded at the side of the road. It was towed to a dealership and I have been told that it is an ICCU failure. At this point, I have been waiting 3 weeks for it to be fixed.
On [XXX], the vehicle was unable to be started - no lights, no power, unable to open the doors. I called Hyundai Roadside Assist and they sent someone from AAA a few hours later who was able to "jump start" the vehicle. I took it to the dealer, Manly Hyundai, on December 17th, 2025 and they determined nothing to be wrong with either the battery or the electrical system. On [XXX], while driving from home to the local grocery store, the car presented a warning light on the dash and the “gas pedal” stopped working. I was able to coast into a parking lot at which point an even larger warning light appeared and the vehicle then lost all electricity completely. I again called Hyundai Roadside Assist and they sent someone from AAA a few hours later who determined that the car was unable to be “jump started” and would have to be towed to the local dealer, Manly Hyundai. The dealer reported back to me that the component that failed is called an “ICCU” and is some kind of controller related to the charging and motors of the electric drivetrain. It is available to be inspected at the dealer currently, Manly Hyundai. My safety was put as risk because the car became essentially inoperable while driving downhill and gave no warning signs ahead of time before the lights lit up on the dash and I lost control. The dealer has confirmed that it is an issue with the “ICCU”. The dealer has inspected the component at their service department. The first warning light that appeared came at the same instant that the vehicle lost drive power. The second warning light that appeared came at the same time that the vehicle lost all electricity entirely. There were no indications that something might be wrong with the vehicle prior to the vehicle actually producing symptoms of being undriveable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The car is a brand-new 2025 Ioniq 5 with only 2,949 miles. All of a sudden and without warning, it entered "limp mode" while driving and did not go past 25 miles per hour. I was close to home so luckily I was able to street park it safely. Called roadside assistance and the car completely powered off (died) in front of the tow truck. The dealership says it is an ICCU failure and need to be entirely replaced. The part is backordered with no ETA for replacement.
On 1/15/2026, my 2025 Ionic 5 Limited AWD car with 11K miles on it suddenly lost power about 1/2 mile from my home. I pulled over to the side of the road and within seconds the car was totally dead (nothing worked). After waiting 1 1/2 hours (in an unheated car with outside temperatures in the 30's (F)) the car was towed to the dealership, where the ICCU was determined to be the problem. The dealership apparently has 3 other Ionic's waiting for new ICCU's. My car has been in the shop ever since, waiting for the replacement ICCU to be delivered to the dealership (delivery is apparently expected sometime in the next couple of weeks).
Diagnosis: ICCU and fuse failure. Situation: 1/17/26 No issues starting when starting/driving car to first store. Car started without issue and I drove to next store a few minutes away. Came out of store to start car and got a notification on dash to check electric vehicle system. Checked app and had error P1A9096 Air Flap Turned car off for a minute, turned car back on and still received the same error. Tried to drive back to house (only about 6 miles away) and realized the car was limited to 25 mph although no indication/notification of limit. Notification continued and I ended up getting a stop vehicle and check electrical system with flashing lights. Stopped and cycled off and on the vehicle a few times. Started vehicle and only check electrical system notification was on (no indication not to drive vehicle so I continued driving). Continued driving and heard what I believe was a pop noise and also got the notification to stop vehicle and check system. Pulled over turned vehicle completely off and checked app again. and Still only PA9096 error. Contacted Hyundai roadside. Truck driver contacted me shortly after letting me know they were on the way. Tried to turn vehicle around in parking lot so easier to tow. Vehicle limited to 1 mph. Vehicle died when I got in spot and wouldn't turn back on. Vehicle towed to dealer. 1/28/26 Over a week after issue, dealer diagnosed as ICCU and fuse failure.
ICCU failure. Vehicle was not able to be operated over 40mph creating significant safety risk.
ICCU failed. ICCU fuse blew limiting power making car unsafe to drive.
The ICCU in my Hyundai Ioniq 5 failed catastrophically today ([XXX]) after only 3109 mlles. I believe this to be the case because: • I heard a loud pop from behind me in the car. • The car immediately lost power and would only go very slowly. • An alert about the electrical system immediately came on and told me to stop driving as soon as possible. • A rather loud alarm sounded. • DTC P1A9096 appeared in my Bluelink app. All these point to a failed ICCU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving in traffic I heard a loud pop coming from the rear of the vehicle. A warning light came on on the dash board and the vehicle immediately slowed to about 10 mph. This was a dangerous situation as I was actively passing a vehicle on the highway and could have ended up colliding with oncoming traffic!
On [XXX] my there was a loud pop from the rear of the vehicle and electric vehicle warnings popped up on my dash. I turned around at the light, and as I drove I could tell that the vehicle was slowly losing power. Speed was limited to 30mph. Barely made it back home before the warnings on the dash told me to immediately stop driving. Vehicle was towed to the dealership, and they informed me on January 8, 2026 that the ICCU had went out and blown a fuse, so they needed to replace both. The car is unable to be driven until this is replaced. The current odometer reading is 3,390 miles. I called yesterday, January 21st and was informed that Hyundai has the ICCU on backorder and it will be at least two weeks before they can update me again. I've reached out to Hyundai Motor America National Consumer Affairs. They stated: 1) No recall exists for this issue and claim this is only impacting 1% of vehicles. 2) The supply of ICCUs was depleted in December 2025 and have been on backorder since. 3) There are no plans to redesign the ICCU to prevent failures so this could very well happen again, and as there are no indicators as to what causes it to malfunction it is making the vehicle unreliable. They have 'escalated' this but I likely will not get the vehicle back for a few more weeks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2025 Hyundai Ioniq 5?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history