car had an engine knock at 110,000 miles and took it to a repair shop and said they are pretty sure it was an engine rod and that the whole engine needed to be replaced still waiting to get it to the dealership to see what they are going to do due to this car being a leased car and it will not run anymore.
2018 Hyundai Kona engine problems
44 complaints (59% of all complaints for this car). Typical mileage when it fails: 90,000. 1 crash reported.
- owner complaints
- 44
- of this car's complaints
- 59%
- typical mileage
- 90,000
- crashes
- 1
- recalls
- 0
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Hyundai Kona engine problems in other years
Specific symptoms reported on the 2018 Hyundai Kona engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Stalling 16Check engine light 14Engine failure 12Knocking 9Oil consumption 9
Related recalls
No recalls on record for this model year.
Related investigations
Loss of Motive Power
the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. Â There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agencyâs reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to
DP22003
What 2018 Hyundai Kona owners say
Most recent owner complaints, unedited.
I purchased a 2018 Hyundai Kona, and it has had one major issue after another. It burns an excessive amount of oil, the engine misfires, and now the turbocharger is failing. I’ve already spent approximately $2,300 repairing the air conditioner and engine, and I can’t afford thousands more in repairs.
The contact owns a 2018 Hyundai Kona. The contact stated that while driving approximately 20 MPH, there was a loud clunking sound coming from the engine bay, followed by grinding gear sounds. The vehicle lost drive power, causing the driver to coast over to the side of the road, where the vehicle eventually stalled. The vehicle was towed to a certified mechanic who diagnosed that the timing belt had failed, and the cam gear rod had sheared off inside the exhaust camshaft, which caused the timing belt to jump and the cam chain tensioner to fracture. The vehicle was repaired. The dealer was contacted, and it was confirmed that the vehicle was not included in a recall. The manufacturer was made aware of the issue, and it was confirmed that the VIN was not included in a recall. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 123,000.
The contact owns a 2018 Hyundai Kona. The contact stated that while driving it began to smoke, a noise was hear, put in neutral to coast down a hill and had to pull the parking break to stop the vehicle. The vehicle was towed to the dealer where it was diagnosed with defective piston oil rings, and the engine was rebuilt. The manufacturer was notified of the failure. The approximate failure mileage was.98,000.
The contact owns a 2018 Hyundai Koa. The contact stated that while the daughter was driving the vehicle began to sputter and jerk before stalling. During the failure the oil warning light flashed off and on. The vehicle was towed to the local dealer who diagnosed that the engine had failed due to carbon buildup. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 21V301000(ENGINE) The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 90,000.
The vehicle suddenly stalled while driving on the highway at normal speed without warning. The engine lost power completely, creating a dangerous situation and a risk of collision with surrounding traffic. The vehicle had to be towed to a repair shop, where the issue was diagnosed as engine failure. There were no warning lights or prior symptoms before the incident. This appears to be a serious safety-related defect. I am aware that similar engine issues have been reported in Hyundai vehicles.
The check engine light came on while driving. Vehicle was assessed by mechanic with strange diagnostic code; full oil and filter change done. Check engine light still on and engine stalled while driving on freeway. Took to dealer and was advised the car requires CVVTS (which is essentially a new engine), serpentine belt and spark plugs (approx $3600). There is a known engine defect with the 2018 Hyundai but they refuse to do as a recall and refuse discounted repair on a vehicle that 8 years old with 92,000 miles. This vehicle is owned by my young adult child and I believe it is undriveable since stalling at full speed is quite dangerous.
The Kona barely wants to accelerate and stalls out while driving. Even though I recently got a oil change there’s oil consumption and the oil is black as if I never got a oil change. I took it to a hyundai dealer ship, i told them what was wrong they said it’s the timing belt. When that’s not the issue. I recently took it to a mechanic to get a third opinion and to see and fix what is wrong. He declined fixing it saying there’s more to it that is wrong and looks like there’s an engine defect and even complained that the oil was so black. I told him that doesn’t make sense because I’ve been getting my oil consistently. He couldn’t fix it. So now I’m stuck with a vehicle that barely drives and stalls out while I’m on the road and it keeps burning more oil. No one knows what is wrong with it.
See attached document for complaint.
The car was burning through oil every 14 -21days. Car has been jerking and taking a while to accelerate. Went to machine to see what’s going he suggested I go to the dealership because there’s no leaks visible. But added more oil so I wouldn’t go without oil there was nothing available for me to come in right away and before my appointment my car started to speed up out of nowhere then completely slowed down then jerked until I could find a safe space to pull over. Check engine came on and the code was reading a misfire. Got a tune up still reading as a misfire now just stuck at the dealership playing guessing games with what’s wrong with the vehicle.
Questions about the 2018 Hyundai Kona engine
Does the 2018 Hyundai Kona have engine problems?
Owners have filed 44 complaints about the engine of the 2018 Hyundai Kona, 59% of all its complaints, more than any other problem.
At what mileage do 2018 Hyundai Kona engine problems start?
The typical (median) mileage in owner complaints is 90,000 miles.
Was there a recall on the 2018 Hyundai Kona engine?
There is no recall for this problem on this model year.
What year does the Hyundai Kona have bad engine?
The Hyundai Kona model years with the most engine complaints are 2019 (144 complaints), 2020 (113 complaints) and 2021 (81 complaints).
Other 2018 Hyundai Kona problems
Transmission 11Electrical 8Driver assistance 5Fuel system 4Acceleration 3Body 3Lights 3Visibility 3Airbags 2Steering 1Suspension 1Tires 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Hyundai Kona?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history