2018 Hyundai Kona: engine stalls while driving

Filed Jul 13, 2026 · Engine · 123,000 miles · TN

The contact owns a 2018 Hyundai Kona. The contact stated that while driving approximately 20 MPH, there was a loud clunking sound coming from the engine bay, followed by grinding gear sounds. The vehicle lost drive power, causing the driver to coast over to the side of the road, where the vehicle eventually stalled. The vehicle was towed to a certified mechanic who diagnosed that the timing belt had failed, and the cam gear rod had sheared off inside the exhaust camshaft, which caused the timing belt to jump and the cam chain tensioner to fracture. The vehicle was repaired. The dealer was contacted, and it was confirmed that the vehicle was not included in a recall. The manufacturer was made aware of the issue, and it was confirmed that the VIN was not included in a recall. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 123,000.

Filed May 6, 2026 · Engine · 90,000 miles · OH

The contact owns a 2018 Hyundai Koa. The contact stated that while the daughter was driving the vehicle began to sputter and jerk before stalling. During the failure the oil warning light flashed off and on. The vehicle was towed to the local dealer who diagnosed that the engine had failed due to carbon buildup. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 21V301000(ENGINE) The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 90,000.

Filed May 1, 2026 · Engine, Transmission · VA

The vehicle suddenly stalled while driving on the highway at normal speed without warning. The engine lost power completely, creating a dangerous situation and a risk of collision with surrounding traffic. The vehicle had to be towed to a repair shop, where the issue was diagnosed as engine failure. There were no warning lights or prior symptoms before the incident. This appears to be a serious safety-related defect. I am aware that similar engine issues have been reported in Hyundai vehicles.

Filed Apr 14, 2026 · Engine · CA

The check engine light came on while driving. Vehicle was assessed by mechanic with strange diagnostic code; full oil and filter change done. Check engine light still on and engine stalled while driving on freeway. Took to dealer and was advised the car requires CVVTS (which is essentially a new engine), serpentine belt and spark plugs (approx $3600). There is a known engine defect with the 2018 Hyundai but they refuse to do as a recall and refuse discounted repair on a vehicle that 8 years old with 92,000 miles. This vehicle is owned by my young adult child and I believe it is undriveable since stalling at full speed is quite dangerous.

Filed Apr 9, 2026 · Acceleration, Engine · MD

The Kona barely wants to accelerate and stalls out while driving. Even though I recently got a oil change there’s oil consumption and the oil is black as if I never got a oil change. I took it to a hyundai dealer ship, i told them what was wrong they said it’s the timing belt. When that’s not the issue. I recently took it to a mechanic to get a third opinion and to see and fix what is wrong. He declined fixing it saying there’s more to it that is wrong and looks like there’s an engine defect and even complained that the oil was so black. I told him that doesn’t make sense because I’ve been getting my oil consistently. He couldn’t fix it. So now I’m stuck with a vehicle that barely drives and stalls out while I’m on the road and it keeps burning more oil. No one knows what is wrong with it.

Filed Jan 1, 2026 · Engine · CA

Prior to 100,000 miles, I noted knocking in the engine, especially while going uphill. The knocking would appear and disappear, possibly with oil change intervals. No check engine light ever appeared. After 100,000 miles, the engine progressively began knocking, losing power, and eventually stalling on the road occasionally. I have had to put on my hazards and restart my car. One time, I was barely able to pull over to the side. Again, no check engine light ever appeared. I have several videos of the vehicle in motion with audible knocking, and almost stalling. The videos show the dashboard with NO check engine light appearing. There was no sign of oil loss. No smoke. No oil stains under the vehicle. I was due for an oil change when the knocking and stalling became severe. I visited the dealer and informed them of the engine issues. They performed an oil change. And then could not reproduce the problem I experienced. Told me to come back if it happened again. This sounded odd to me given the severity of the knocking and stalling. Or it signaled to me that an oil change including refilling the oil solved the issue. Long story short. An oil consumption test was performed. The engine is consuming oil. I am scheduled for combustion chamber cleaning per the Technical Service Bulletin, as mentioned by the service rep. I am not confident that this will fix the problem. Given that this is the same / similar engine as the recalled 2018-2021 Kona for the same / similar issue. Oil consumption.

Filed Sep 12, 2025 · Engine · 100,000 miles · GA

The contact’s daughter owns a 2018 Hyundai Kona. While the contact’s daughter was driving approximately 65 - 70 MPH, the vehicle started decelerating and sputtering before the vehicle coasted to the side of the road and stalled. The check engine warning light was illuminated. The vehicle was towed to a certified mechanic, who diagnosed the vehicle and determined that the engine needed to be replaced. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was informed and opened a case. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 100,000.

Filed May 7, 2025 · Engine, Fuel system · TN

My engine started shuddering and stalling out on me. This was very dangerous as the car would stall out at street lights and intersections. The check engine light only came on after the car stalled out and has not stayed on during the times that it stalls out. When I went to get a mechanic to check it out they said that they had seen many Hyundai and Kia cars that had the same issues. The issue was oil consumption. It was consuming oil faster than it should have, even though I was regularly getting my oil changed. This lead to a problem with my pistons. Now the engine needs to be replaced. But Hyundai won’t cover it because there is no recall on it and the power train warranty only last for the first owner. Is there any way we can request for a new recall on this vehicle as it is clearly a problem that Hyundai is having.

Filed Apr 11, 2023 · CT

Car stalled while driving. This happened 5 times in a 5 day period. 2 times while crossing traffic. Oil was checked and found to have less than 1 quart of oil. No low oil level warning light came on.

Filed Mar 29, 2023 · Engine, Fuel system · CA

8/29/20002, the ABS brakes system and Fuel Injection system 10/31/2022, Battery 11/8/2022, car stalled on the freeway 11/9/2022, Car stalled on the freeway 11/19/2022, Timing Control and camshaft position sensors 12/2/2022, Engine fire, the smell of burning plastic 1/9/12, Grinding noise near the right rear tire. I can provide the invoices under separate cover .

Filed Mar 14, 2023 · Engine, Transmission · TX

Oil change was on 1/13/2023 at 33,505 miles. On 2/25/2023 at 35,366 miles after driving on the highway for about 30 mins at 65 mph, the oil light came on and car was making a loud noise as I pulled in to park. My car was parked for about 1.5hrs at my destination. I attempted to drive home and get back on the highway when my engine stalled at about 40 mph and my engine and battery light came on. I had to pull over to the shoulder as my car would not drive anymore. My car was then towed to my house and later to the hyundai dealer where they determined that my engine stalled due to lack of oil because my drain plug was missing. Hyundai refuses to fix this under warranty because the drain plug is missing and they are insisting this is because of the oil change place I went to nearly 2 months ago. When I went to the oil change place, they insist that they didn't do anything wrong, and if they did incorrectly put the drain plug on, my oil would've leaked much sooner than it did. There is currently and investigation with the federal safety agency with my exact issue where the oil drain plug still falls out, even if the person performing the oil change puts the drain plug on exactly how it should be. Directly from the federal safety agency site: "Apparently, the thin metal, along with engine vibrations and expansion/contraction tend to loosen the drain plug without any other intervention. the federal safety agency is investigating this as a factory defect issue." My safety was deeply put at risk as I was driving on the highway when this happened and I could've easily gotten into an accident and faced injuries. I'm stuck in the middle as the oil change place denies it is their fault and hyundai refuses to fix under warranty strictly because the oil drain plug is missing. When I explained to them that I would've have this issue with my engine if the drain plug was present, they agreed. They are stating that it is $10,000 to repair my car and that I have to pay upfront and cannot do multiple payments

Filed Feb 2, 2023 · Engine · KY

The car stalls out and I have to now replace the entire engine. There has been recalls for this exact issue on other years of this car but not on this one.