2019 Hyundai Kona: check engine light

Filed Sep 7, 2026 · Engine, Fuel system · TX

My 2019 Hyundai Kona SE (2.0L Nu MPI/Atkinson engine) was previously subject to the federal safety agency Recall 21V301000 (Hyundai Recall 203) for defective piston oil rings that can chip and cause accelerated oil consumption, engine knocking, and stalling. That recall's remedy was performed under a prior owner in December 2021. In November 2025, a Hyundai dealership installed a Cylinder Noise Diagnostic System (CNDS) software update (Service Campaign 974) specifically meant to detect this defect's vibration signature before it causes engine damage. Approximately 7,000-8,000 miles and about nine months after that software update, the vehicle stalled unexpectedly while being driven on two separate occasions, with no check-engine light or other warning beforehand. A third stall left the vehicle unable to restart. It was towed to a service station, which found no engine oil and no external leak. A Hyundai dealership subsequently diagnosed cracked valves that allowed approximately 5 quarts of oil to burn through the engine, and determined the engine requires complete replacement. This is the same failure mode (oil consumption/engine damage leading to stalling) that the original recall and the 2025 software update were both meant to prevent, and the software gave no advance warning before the stalling occurred. The vehicle and dealership diagnosis are available for inspection upon request.

Filed Jun 26, 2026 · Engine · FL

My 2019 Hyundai Kona has been burning oil, I’ve done great upkeep on it, including topping the oil off in between services. This is because it obviously has been burning oil, well recently it started stalling, then starting/turning it over has been acting up. The RPM’s have not been stable at all an I’ve ran two diagnostic test on it, they came back as a “camshaft error” I can’t remember the exact code at the moment. However the mechanics I have questioned said it’s probably from the oil pressure being messed up from the oil burning up. Whether it be the sensor not regulating properly or the engine itself not getting enough lubricant. I have heard from others with Hyundais an it’s not just Kona’s, people are saying they burn through their oil fairly quickly compared to other cars they’ve had. With that being said, the car now stalls in traffic and the check engine light came on finally, that’s when we first ran diagnostics. Which I have had diagnostics ran at one place I go to for oil changes, a one at a Meineke, and soon to be a third at Autozone because I need to get the exact code again. I’m worried because my mom an I have been sharing this vehicle and the stalling makes it dangerous, it can be put in neutral and restarted but I have a service appointment with a dealership to see what they can do, however I feel this is happening from something caused straight from the manufacturer, not improper care or overuse. So I’m filing a complaint because if you stall while crossing traffic and could not restart, or know how to restart it, you could get in a wreck. This all seemed to start happening as well right after the vehicle rolled over 100,000 miles, go figure right? An if you needed to inspect this happening it would not be hard to do, all you would have to do is turn over the engine, then drive it for a bit an it will eventually stall, an you could also see the RPM’s bouncing and the noises it makes.

Filed Jun 16, 2026 · Engine · 113,000 miles · GA

The contact owns a 2019 Hyundai Kona. The contact stated that the vehicle had experienced excessive oil consumption. The contact stated that while driving 70 MPH on the highway, the vehicle stalled. The contact was unable to pull over to the side of the road. The contact was able to restart the vehicle and continued driving. The contact stated that the failure recurred while driving into a parking lot. The battery warning light illuminated on several occasions. Additionally, the contact stated that the check engine and low oil pressure warning lights were intermittently illuminated. The vehicle was taken to Auto Zone and to an independent mechanic, where it was diagnosed and determined that the piston oil ring failure had caused low oil pressure, which resulted in the timing failure. The failure was related to the federal safety agency Campaign Number: 21V301000 (ENGINE). The dealer and the manufacturer were notified of the failure but denied a loaner vehicle or towing assistance to the dealer located 75 miles away. The vehicle was not repaired. The failure mileage was approximately 113,000.

Filed Jun 9, 2026 · Engine · 100,000 miles · TX

The contact owns a 2019 Hyundai Kona. The contact stated that while driving on several occasions at various speeds, the AWD warning light illuminated and was reset each time the vehicle was restarted. The contact also stated that over a couple of months, while downshifting, stopping, or decelerating, the vehicle stalled on several occasions. Additionally, the contact stated that while driving at approximately 30 MPH, the Check Engine warning light illuminated. The vehicle was then taken to an AutoZone, where a handheld diagnostic machine retrieved diagnostic trouble codes: P0017 (crankshaft) and P0171 (system too lean), and it was observed that the oil reservoir was empty. Two quarts of oil were added to the vehicle. The contact stated that after being serviced, the vehicle was idling high and stalled while driving at unknown speeds on several occasions. The vehicle was taken to a dealer, where it was diagnosed with a sheared timing pin, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,000.

Filed Mar 9, 2026 · Engine · 94,634 miles · OH

The contact owns a 2019 Hyundai Kona. The contact stated that while driving at an undisclosed speed, there was a knocking sound coming from the vehicle with the check engine warning light illuminated. The vehicle was driven to an independent mechanic, where it was diagnosed with engine failure. The contact referenced the federal safety agency Campaign Number: 21V301000 (ENGINE); however, the VIN was not under recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 94,634.

Filed Feb 25, 2026 · Engine · 100,220 miles · NC

The contact owns a 2019 Hyundai Kona. The contact stated that while his daughter was driving 45 MPH, the check engine warning light illuminated, and the vehicle shut off. The driver pulled over to the side of the road and the vehicle was towed to an independent mechanic to be diagnosed. The mechanic related the failure to the federal safety agency Campaign Number: 21V301000 (ENGINE); however, the vehicle was towed to a dealer and the dealer declined to honor the recall repair due to sludge in the oil cap. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 100,220.

Filed Feb 25, 2026 · Engine · 68,000 miles · CA

The contact owns a 2019 Hyundai Kona. The contact stated that while driving at various speeds, there was an abnormal knocking sound coming from the vehicle with the check engine warning light illuminated. Upon inspection of the vehicle, the contact discovered that the engine oil was low, and the contact added oil to the engine. The contact stated that the failure was intermittent. Upon investigation, the contact discovered the federal safety agency Campaign Number: 21V301000 (Engine). The contact continued to investigate the failure and discovered that the vehicle was previously repaired before owning the vehicle. The contact reached out to several dealers and the manufacturer about the issue; however, no assistance was provided. The contact continued to speak with the manufacturer, and the manufacturer agreed to have an oil consumption test performed on the vehicle. The vehicle tested by two dealers for the consumption test and the results came back inconclusive. The vehicle was not repaired. The failure mileage was approximately 68,000.

Filed Feb 9, 2026 · Engine · LA

Vehicle started to stall at low RPMs. While idling at red lights, engine would stall and go into limp mode. All safety features, such as forward collision would stop working. Car would need to be turned off and restarted for a temporary fix. No engine lights would come on. Car inspected by dealership and cannot figure out what the cause is. VIN comes up saying that my car is not part of the recall.

Filed Feb 3, 2026 · Engine · 94,000 miles · ME

The contact owns a 2019 Hyundai Kona. The contact stated that while operating the vehicle, the check engine warning light illuminated, with a knocking sound coming from the engine compartment. The contact stated that the vehicle shutoff while idling. The vehicle was taken to the local mechanic who was unable to determine the cause of the failure. Later, while idling at a stoplight, the vehicle stalled and failed to restart. The vehicle was eventually towed to the local dealer, who confirmed that the connecting rods had failed and punctured a hole in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was informed that the VIN was not included in the federal safety agency Campaign Number: 21V301000 (ENGINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 94,000.

Filed Oct 26, 2025 · Engine · CA

My Kona has been stalling/hesitating when accelerating. It has been happening for a little over a year. It got very bad and the check engine light came on. I had it towed to Hyundai dealership and they said it was the fuel injectors so I paid to have those replaced, they said my warranty didn’t cover it. Replacing the fuel injectors made the car drivable but it was still stalling/hesitating but Hyundai said it was working properly. So I took it home. I have been driving it and it just keeps stalling and hesitating more and more. It is stalling and hesitating and has lack of power when I try to accelerate. I am afraid one day I’ll stall in traffic and get hit or cause an accident. I have also just realized my Kona has been using excessive oil. I just had an oil change mid August and today had to add at least 3 quarts. Even when I had my oil changed, the shop said I barely had maybe a quart in there, when it was just changed in May. We do not see any oil leaking out from anywhere. I have no choice but to use it to get around and Hyundai said it was working properly. I have recently looked online and I seen a lot of other owners reported the same issues. I have contacted Hyundai but they say theres nothing they can do. I am not sure where to go from here.

Filed Sep 9, 2025 · Transmission · NY

Engine light blinking. Code P1327

Filed Aug 8, 2025 · Engine · 81,000 miles · CA

The contact owned a 2019 Hyundai Kona. The contact stated that while driving 50 MPH, the vehicle stalled while driving uphill, and the contact heard a loud clanking sound coming from the engine compartment, with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer suggested that an oil consumption test be performed and return the vehicle be returned to the dealer every 1,000 miles. The manufacturer was not made aware of the failure. The failure mileage was approximately 81,000.