2020 Hyundai Kona: check engine light

Filed Sep 29, 2026 · Engine · AR

COMPONENT THAT FAILED: The engine short block piston rings (related to the federal safety agency recall 203) failed, causing severe cylinder wall scoring. The vehicle is currently located at an authorized Hyundai dealership and is available for manufacturer or the federal safety agency inspection. SAFETY RISK; The defective piston rings caused severe internal oil consumption, resulting in hydraulic oil starvation. This creates a high risk of sudden engine stalling, catastrophic engine seizure, and complete loss of motive power while driving in traffic. CONFIRMATION AND INSPECTION: Yes, the defect has been confirmed. The current Hyundai dealership performed a boroscope inspection, which physically confirmed severe vertical metal scoring in cylinder 3. They also documented that the engine was 1.5q low on oil with zero external leaks, confirming internal consumption. Despite physical proof of the recall defect, the manufacturer is currently refusing to honor the recall repair. WARNING LAMPS/SYMPTOMS: The check engine light illuminated, logging exhaust camshaft timing correlation codes (P0017). This first April 2026 at 169,000 miles. This timing code is a secondary hydraulic symptom caused by the severe internal oil starvation originating from priary lower block cylinder scoring defect.

Filed Sep 9, 2026 · Engine · OH

The contact owns a 2020 Hyundai Kona. The vehicle was taken to the dealer to be repaired under the federal safety agency Campaign Number: 21V301000 (Engine); however, the dealer was unable to perform the recall repair because the vehicle had not experienced a failure associated with the recall and there were no fault codes displayed or retrieved associated with the recall. However, an independent mechanic recommended that the engine be replaced. The contact provided the dealer with the fault codes and the failures that the independent mechanic had found; however, the dealer was unable to retrieve the same fault codes. The contact stated that the check engine warning light was illuminated. The manufacturer was notified of the failure and agreed with the dealer and refused additional assistance. The vehicle was not repaired.

Filed May 28, 2026 · Engine · 117,000 miles · OH

The contact owns a 2020 Hyunndai Kona. The contact stated while attempting to start the vehicle, the check engine warning light illuminated. The contact's fiance, who is an independent mechanic attached the portable diagnostic tester to the vehicle, and the failure code was P1327. The dealer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under warranty. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure and a case was filed. The contact as advised to take the vehicle to the dealer for diagnostic testing. The failure mileage was approximately 117,000.

Filed May 12, 2026 · Acceleration, Engine · PA

The vehicle all shut off as I slowed down for a stop sign. Put in Park turn the key off restarted it got to the next stop sign same thing. Also the red light same had to shut it off put it in put in Park shut off and then restart and step on the gas so I can get through before a car hit me. Happened several times till I finally got the car home done it started knocking loudly and shut off just as I got into my driveway. Check the oil. The oil is fine. Occasionally the oil light would come on if you put in Dr.. It is knocking really loud. The engine light keeps flashing constantly. I called Brown Dobb Hyundai in Easton Pennsylvania. They told me this recall has nothing to do with my car because of the VIN number. But everything that is happening to it is is under recall 187. But because of the VIN number they are insisting it’s not my car. What can I do before I get in an accident? I don’t have any other cars to rely on. I have a son with Autism and I am a single mother. What else can I do? I had this car not even three months.

Filed May 11, 2026 · Engine · PA

Engine light comes on starts flashing as well as the oil light occasionally. If you slow down or have to stop it completely shuts down you have to put in park and restart the car to get anywhere and start stopping in front in the middle of traffic. So if you slow down to go up a hill or anything, it just stops completely. Also making a clicking or grinding sound not sure.

Filed Mar 25, 2026 · Engine · NC

My car was taken in as a part of recall bulletin 203 for improperly heated piston rings treated pistons rings that result in premature engine failure and possible fire on 12/5/25. The knock sensor test was performed and the KSDS software was installed. On 3/12/26 my daughter who was on the way home from a trip called because her checking engine light started flashing and the engine was knocking. We had it towed to Hyundai and they are denying service under the recall stating improper codes yet one of the codes is P1327 KSDS detection which is related to the rod bearing failure the car currently has. They are trying to make me pay $4600 out of pocket plus the tow bill when this is directly related to the recall.

Filed Nov 12, 2025 · Acceleration, Transmission · SC

The timing system was repaired in February 2025. After similar symptoms of vehicle stalling, the check engine light came on Found a software update that needed to be completed to determine if engine needed replaced. Dealership has refused for seven weeks to complete the entire job of the update which includes running a diagnostic of codes. Instead, they have been arguing that the timing system needs replaced and not providing the codes from the safety software update. Obviously there's a much deeper issue if the timing system keeps breaking down.

Filed Oct 27, 2025 · Engine · KY

Vehicle suddenly began shutting off upon braking and/or acceleration at any speed, idling very hard, and/or barely starting or dying immediately after starting and making a very loud whining noise while driving on an interstate. A mechanic ran a diagnostic test on it and determined that it was a P1327 code and recommended it be taken to dealership for full engine failure. This particular code was known by Hyundai to occur on certain models and years, including Kona 2019-2021, as early as 2022 and while a recall campaign was initiated, no recall to date has been issued. No warning indicators on dash occurred in advance or even after the vehicle began malfunctioning (i.e., no check engine indicator, etc.). Vehicle is available at dealership upon request.

Filed Aug 1, 2025 · Engine · TX

I am the original owner of a 2020 Hyundai Kona equipped with the 2.0L Nu MPI engine. This engine has been subject to known manufacturing defects, including excessive oil consumption, timing component wear, and premature failure. Hyundai has acknowledged that my specific engine falls within the range of engines affected by this defect and has confirmed that it is part of a recall/service campaign group. However, Hyundai is refusing to repair or replace the engine because it passed a vibration test back in 2021. That test was performed over three years ago, and my vehicle is now experiencing major engine problems, including the activation of check engine light with code P0017, which refers to crankshaft-camshaft correlation issues — a known symptom of the engine defect. Hyundai is denying coverage based on a test that is now outdated and irrelevant, despite the fact that the engine is part of the known defect group and is showing signs of failure consistent with hundreds of similar cases. The vehicle is no longer under powertrain warranty, but the root cause of the failure is clearly related to the previously identified defect. Hyundai’s refusal to act puts me, and potentially others, at risk of sudden engine failure due to timing or lubrication problems. This is a potential safety issue if the engine stalls while driving. I respectfully request that the federal safety agency investigate Hyundai’s use of past vibration tests to deny coverage for active and dangerous engine defects. Owners like myself should not be penalized for a test performed years ago when clear evidence of failure now exists.

Filed Jun 23, 2025 · Engine · GA

Car is losing power. Car is stopping in the middle of the road. Car was towed to my Personal mechanic on June 21,2025 who has ran a diagnostic on vehicle & vehicle is throwing out an Engine Failure Code. Check Engine light is blinking ; car is making odd "knocking type" noises. First appeared June 20, 2025. Car is not safe to drive due to losing power. Vehicle is now being towed to the dealership (after multiple calls) and the loss of power is concerning/dangerous if vehicle looses power with traffic around. I feel I won't be able to get the vehicle and myself off the road safely before an accident/injury/fatality occurs. I will upload a copy of the diagnostic report

Filed Mar 27, 2025 · Engine · OK

Recall 203 was done on vehicle immediately upon purchase in 2021. Recall 974 was done and CNDS software installed in 2022. Engine stalled and check engine light came on at the end of February. Took car in March 11th to the dealership was told that the engine would need to be replaced due to code P1327. Said there was piston noise. Told me none of it is covered and that I would be out of pocket almost $9,000.00 with a car that is 5 years old. Have a case open with Hyundai Consumer Affairs (Case#[XXX]) and have not heard anything back from them. I am needing to know if this should be covered. According to my research it should be. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 16, 2025 · Engine · OH

While driving the car it stalled and all dash lights came in. After about 20 mins it started back up and I proceeded down the road. After a few minutes the engine light came on blinking. I got the car to a local mechanic who placed it in the diagnostic machine. It came back code engine-pistons. I have a Hyandai 2020 Kona MPI-NU 2.0l engine but it was not included in the recall of the same vehicles.