2020 Hyundai Kona: engine failure

Filed Aug 25, 2026 · Engine · MD

My 2020 Hyundai Kona experienced an engine-related malfunction. An authorized Hyundai dealer inspected the vehicle, confirmed diagnostic code P1327, and determined that the complete engine required replacement. Hyundai authorized the replacement, and the vehicle remained out of service for approximately two weeks. The engine defect created a safety concern because an engine malfunction could cause reduced or complete loss of motive power while driving, increasing the risk of a crash. The dealer inspected and removed the original engine; I do not know whether it remains available for further inspection, but the repair order and diagnostic records are available. I am filing this complaint so the federal safety agency can document this engine failure and determine whether it is related to the federal safety agency Campaign 21V301 / Hyundai Recall 203 and whether additional investigation or corrective action is warranted.

Filed Mar 25, 2026 · Engine · NC

My car was taken in as a part of recall bulletin 203 for improperly heated piston rings treated pistons rings that result in premature engine failure and possible fire on 12/5/25. The knock sensor test was performed and the KSDS software was installed. On 3/12/26 my daughter who was on the way home from a trip called because her checking engine light started flashing and the engine was knocking. We had it towed to Hyundai and they are denying service under the recall stating improper codes yet one of the codes is P1327 KSDS detection which is related to the rod bearing failure the car currently has. They are trying to make me pay $4600 out of pocket plus the tow bill when this is directly related to the recall.

Filed Mar 19, 2026 · Engine, Steering · CA

My 2020 Hyundai Kona (VIN: [XXX] ) has a persistent engine stalling safety defect that matches Recall 203 (22-01-042H, the federal safety agency Campaign 21V301000 – Nu 2.0L Atkinson Engine Inspection and Replacement). The recall addresses improperly heat-treated piston oil rings causing cylinder bore scuffing, accelerated oil consumption, abnormal knocking, and potential engine stall while driving (increasing crash/fire risk).I first brought the vehicle to Corona Hyundai for repeated stalling while driving. They performed the recall vibration inspection and software update (Campaign 974), stated the test passed, and declared the vehicle "fixed", safe and "good-to-go" Immediately after pickup, the stalling returned worse: approximately 60-80 miles later on XX near the XXX exit (four-lane high-speed highway), the engine completely stalled at 65 mph while merging for an exit. This caused vehicles and semi-trucks behind me to swerve dangerously and very nearly collide with me. The vehicle stalled four more times on the way to my destination in [XXX] .I then took it to the nearest dealer, Carlsbad Hyundai for safety reasons. They performed the vibration inspection again, which also "passed," yet the real-world symptoms would continue unchanged: accelerated oil consumption (I monitor the dipstick and refill regularly), sputtering, knocking noises, and complete engine stalls (dozens of incidents, especially on local roads and turns). The vehicle remains undrivable due to imminent stall risk while moving and putting myself, my passengers and other commuters at high risk of severe injury or death.Both dealers and Hyundai Customer Care (Case #XXX) have refused further action, stating the vibration test passed, they cannot duplicate the concern, and no additional claim can be submitted for engine replacement. Hyundai's TSB [XXX] requires only the vibration inspection; engine replacement is authorized if "NO PASS" – no separate oil consumption test or monitored drive INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.

Filed Mar 11, 2026 · Engine · 108,000 miles · SC

The contact owns a 2020 Hyundai Kona. While the contact’s son was driving the vehicle on the highway at an undisclosed speed, there was a knocking sound coming from the engine and the vehicle failed to stop as intended. The gear shifter was shifted into neutral(N) and restarted; however, the engine failed shortly afterwards, and the vehicle was unable to restart. No warning lights were illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with piston rings failure and low engine oil. The vehicle was not repaired. The manufacturer was notified of the failure, where it was confirmed that the VIN was included in the federal safety agency Campaign Number: 21V301000 (Engine); however, the recall repair was already performed. The approximate failure mileage was 108,000.

Filed Oct 27, 2025 · Engine · KY

Vehicle suddenly began shutting off upon braking and/or acceleration at any speed, idling very hard, and/or barely starting or dying immediately after starting and making a very loud whining noise while driving on an interstate. A mechanic ran a diagnostic test on it and determined that it was a P1327 code and recommended it be taken to dealership for full engine failure. This particular code was known by Hyundai to occur on certain models and years, including Kona 2019-2021, as early as 2022 and while a recall campaign was initiated, no recall to date has been issued. No warning indicators on dash occurred in advance or even after the vehicle began malfunctioning (i.e., no check engine indicator, etc.). Vehicle is available at dealership upon request.

Filed Sep 29, 2025 · Engine · MI

I purchased a used 2020 Hyundai Kona with the Nu 2.0L engine. I drove the vehicle regularly without issue for several years, including two days before the incident. On the day of the incident, I attempted to start the vehicle but it ran irregularly. I shut off the vehicle after a few seconds and restarted. The vehicle stalled seconds after starting. On subsequent attempts it failed to start at all. I learned of Recall 203 (defective piston rings), which affects this model year and engine. I contacted Hyundai, who recommended I visit a dealer. Upon inspection, the dealer recommended engine replacement. Hyundai denied engine replacement under Recall 203, on the grounds that the recall was "closed" during an inspection in 2021 (prior to my ownership) despite the defective part not being replaced. This engine, with defective and recalled part, has now experienced sudden and unexpected failure. Hyundai has been uncooperative and I have been without a vehicle for nearly a month.

Filed Sep 3, 2025 · Engine · CT

Car has extreme oil consumption and power stalls which are related to a recall in 2021 for bad poston rings which werent properly heat protected. I brought in and they said it was checked for recall but engine was never actually replaced. My warning lights come on for oil when this happens. My engine could either seize or I could lose power on highway. Car dealership laughed in my face when brought and told me id have to fork over 10k for a new engine which doesn't seem accurate considering Hyundai manufactured this vehicle with bad piston rings.

Filed Aug 12, 2025 · Engine, Transmission · AR

The engine on my 2020 Hyundai Kona failed suddenly while driving, causing complete loss of power. There were no warning lights until after the failure. The vehicle was towed to a Hyundai dealership. Initially, the dealership stated the failure was related to an open recall from 2021 and warned that repairs might not be covered because the recall had not been completed. I sent them a written request outlining both the federal safety agency Recall 21V‑301 (federally mandated) and Service Campaign 974, asking for documentation supporting their diagnosis and any communications with corporate. This request was ignored. Afterward, the dealership said they would replace the engine, but upon completion they recommended replacing certain bolts and hoses at my expense ($849), claiming that if I declined, any future related repairs would not be covered. When asked why these parts were not included in the repair or how their condition would void future coverage, I was told they were “normal wear” items not covered under warranty. No documentation or policy basis was provided. When asked whether the repair was processed under Recall 21V‑301 or Campaign 974, they stated it was not tied to either and was filed under the powertrain warranty without corporate involvement. Multiple shop personnel had earlier confirmed verbally that the failed part matched the recall defect, but the service manager provided a different explanation and refused supporting documents. The dealership also claimed Recall 21V‑301 was “completed” in October 2021 via a software update, despite the vehicle never having been at the dealership since purchase. No proof of recall completion or CNDS software installation was provided. The lack of evidence that Recall 21V‑301 was properly remedied, the possibility of an improper closure in Hyundai’s system, and the fact that the failure matched the recall defect raise serious concerns about compliance with federal recall requirements. I am waiting for corporate to contact me also.

Filed Aug 1, 2025 · Engine · TX

I am the original owner of a 2020 Hyundai Kona equipped with the 2.0L Nu MPI engine. This engine has been subject to known manufacturing defects, including excessive oil consumption, timing component wear, and premature failure. Hyundai has acknowledged that my specific engine falls within the range of engines affected by this defect and has confirmed that it is part of a recall/service campaign group. However, Hyundai is refusing to repair or replace the engine because it passed a vibration test back in 2021. That test was performed over three years ago, and my vehicle is now experiencing major engine problems, including the activation of check engine light with code P0017, which refers to crankshaft-camshaft correlation issues — a known symptom of the engine defect. Hyundai is denying coverage based on a test that is now outdated and irrelevant, despite the fact that the engine is part of the known defect group and is showing signs of failure consistent with hundreds of similar cases. The vehicle is no longer under powertrain warranty, but the root cause of the failure is clearly related to the previously identified defect. Hyundai’s refusal to act puts me, and potentially others, at risk of sudden engine failure due to timing or lubrication problems. This is a potential safety issue if the engine stalls while driving. I respectfully request that the federal safety agency investigate Hyundai’s use of past vibration tests to deny coverage for active and dangerous engine defects. Owners like myself should not be penalized for a test performed years ago when clear evidence of failure now exists.

Filed Jul 3, 2025 · Engine · CA

I was driving when I heard a rattle below the car. About a mile later, my engine died. Turns out the oil plug fell out causing irreparable damage to my engine. Was fortunate to be able to coast down the bottom side of the bridge I was on to a safe spot off to the side.

Filed Jun 23, 2025 · Engine · GA

Car is losing power. Car is stopping in the middle of the road. Car was towed to my Personal mechanic on June 21,2025 who has ran a diagnostic on vehicle & vehicle is throwing out an Engine Failure Code. Check Engine light is blinking ; car is making odd "knocking type" noises. First appeared June 20, 2025. Car is not safe to drive due to losing power. Vehicle is now being towed to the dealership (after multiple calls) and the loss of power is concerning/dangerous if vehicle looses power with traffic around. I feel I won't be able to get the vehicle and myself off the road safely before an accident/injury/fatality occurs. I will upload a copy of the diagnostic report

Filed Apr 10, 2024 · Engine · NY

The vehicle shut down while I was driving approximately 40 mph on a major throughway out of town. I was unfamiliar with the area and had to quickly pull over into a resident's driveway. I immediately shut the vehicle down and tried to restart it. It would not turn over, so I waited a few minutes and tried again. The engine then made a noise that almost sounded like "I quit" and would not make any noise when I turned the key after that. I called a local tow company who towed it to Firestone Complete Auto Care which was the nearest open garage. After they ran their diagnostic, they said that the engine had seized and that there was no oil in the reserve. I never had any engine lights light up on the dashboard until the second the car stopped working, when they ALL came on. My mechanic friend says that these engines have computers that time stamp when the warning lights come on, so it will be interesting to know if they use that information. I have contacted Hyundai customer service and because we are not the original owners of the vehicle, they said the powertrain/engine is not covered under the 5 year/60k mile warranty from Hyundai. We do have an extended warranty through a 3rd party company, but they are giving us a difficult time too. We are still waiting to hear if they will cover the replacement of the engine. This is a HUGE safety risk because my vehicle gave no advanced warning that it was needing service/maintenance and just stopped functioning while I was driving. If I had been on a different street or in the middle of a turn, it could have resulted in injury/death of occupants of the vehicle. My oldest son is also just starting to drive. If he were driving this vehicle when this occurred, he may not have known what to do and could have been stranded in the middle of a busy highway, where an accident could have been imminent.